Table of Contents
Advertisement
PELLET STOVE
OPERATIONS
GUIDE
Manufactured for
Manufactured by
For the following models: FPP, IPP, CC1, CC2, CC3, CCGB1, CCGB2, CCGB3
Installations shall conform to:
CAN/CSA B365 Installation Code For Solid-Fuel-Burning Appliances and Equipment in Canada and
NFPA 211 Chimney, Fireplaces, Vents and Solid Fuel Burning Appliances in the USA
READ THIS ENTIRE MANUAL BEFORE INSTALLING YOUR PELLET STOVE/HEATER/INSERT. FAILURE TO
FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH
Advertisement
Table of Contents
Related Manuals for Dansons Group CAN/CSA B365
Summary of Contents for Dansons Group CAN/CSA B365
- Page 1 For the following models: FPP, IPP, CC1, CC2, CC3, CCGB1, CCGB2, CCGB3 Installations shall conform to: CAN/CSA B365 Installation Code For Solid-Fuel-Burning Appliances and Equipment in Canada and NFPA 211 Chimney, Fireplaces, Vents and Solid Fuel Burning Appliances in the USA READ THIS ENTIRE MANUAL BEFORE INSTALLING YOUR PELLET STOVE/HEATER/INSERT.
- Page 2 - Initial setup of the stove is the most important step to ensure consistent, comfortable operation. - Know the quality and characteristics of the pellets you burn.
-
Page 3: Start-Up Checklist
WITH PELLETS BURN If the fire does not start, your stove will continue to feed pellets and run the fans for 15 minutes. The stove will then automatically shut off. If the stove fails to ignite a second time, refer to the section of your manual or contact your pellet stove dealer. -
Page 4: Initial Setup
PELLETS BLOWN OUT OF BURN GRATE It is critical for the correct operation of your stove that the burn grate, air inlet damper, combustion fan speed and fuel rate be set correctly! START THE APPLIANCE AS PER THE LIGHTING INSTRUCTIONS. - Page 5 To DECREASE fuel feed rate, turn the trimmer CLOCKWISE. IMPORTANT: The #1 and #4 trim pod dials ONLY adjust fuel feed rates 1 and 4. WARNING: Adjusting FEED RATE #1 too low (clockwise) may cause your stove to shut down. ADJUSTMENTS...
-
Page 6: Pellet Fuel
PELLET CONSUMPTION Fuel consumption will vary somewhat between fuel brands and stoves. The following ‘rough guide’ to pellet usage may be useful in assessing your stove’s operation, for ordering fuel and in providing information to your authorized pellet stove dealer. -
Page 7: Pfi Pellet Standards
- Premium Quality - Standard Quality NOTE: Because Dansons Group Inc. and Canadian Comfort Industries have no control over the quality of pellets that you use, we assume no liability caused by issues relating to the quality of chosen pellets. -
Page 8: Recommended Maintenance Schedule
Fly ash may be removed by vacuuming inside the trap area with an approved ash vacuum (A HOME SHOP VAC MAY BE USED TO REMOVE ASH FROM YOUR STOVE *ONLY* WHEN THE ASHES HAVE COOLED). A bottle cleaning brush can help remove build-up inside the traps. - Page 9 Painted surfaces may be wiped down with a damp cloth. If scratches appear or you wish to renew your paint, contact your Dealer to obtain a can of ‘satin black’ (Stove Brite brand) TIP: Use a hair dryer to warm the surface prior to touching up the paint; this helps to reduce paint runs.
-
Page 10: Troubleshooting
TROUBLESHOOTING Proper cleaning, maintenance and use of quality pellets will prevent common operational issues with your pellet stove. However, when your appliance is simply operating poorly or not at all, the following troubleshooting tips may be helpful. WARNING: Disconnect the electrical cord prior to opening the sides of your stove or opening the exhaust system for any inspection, cleaning, maintenance or service work. -
Page 11: Warranty
REMOVAL OR REINSTALLATION COSTS ARE NOT COVERED BY THIS WARRANTY. CCI LIABILITY IS LIMITED TO THE WHOLESALE COST OF THE STOVE. Some states do not allow the exclusion or limitation of incidental or consequential damages, or limitations of implied warranties;... - Page 12 My local dealer is: To register your purchase, visit www.dansons.com/support Technical Support Monday to Friday, 11 am to 7 pm EST or Monday to Friday, 9 am to 8 pm EST Saturday, 11 am to 7 pm EST COPYRIGHT Copyright 2006, Canadian Comfort Industries. All rights reserved. No part of this manual may be copied, transmitted, transcribed, stored in a retrieval system in any form or by any means without the expressed written permission of: Canadian Comfort Industries 26319 Twp Rd 531...