Page 1
Insert / Built-In Bay View Insert / Built-In Freestanding Bay View Freestanding Toll Free Technical Support My local “Pelpro” dealer is: 1 - 866 - 456 -9269 Manufactured by: To register your purchase www.dansons.com/support READ THIS ENTIRE MANUAL BEFORE YOU INSTALL AND USE YOUR HEATER. FAILURE TO FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH! Installation shall conform to CAN/CSA B365 Installation Code for Solid-Fuel-Burning Appliances and...
Thank you for selecting a PELPRO wood pellet appliance. Sincerely, Canadian Comfort Industries & Dansons Group Inc. Up to date additions, product information, product registration and warranty extension registration can be found on Copyright 2004, Canadian Comfort Industries. All rights reserved.
The heater will not operate during a power outage. If a power outage does occur, check the heater for smoke spillage and open a window if any smoke spills into the room. o Keep foreign objects out of the hopper. adian Comfort Industries Copyright 2004 RECAUTIONS www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
Page 5
Note: Canadian Comfort Industries grants no warranty, implied or stated, for the installation or maintenance of your heater, and assumes no responsibility of any consequential damage(s). adian Comfort Industries Copyright 2004 . . . Continued www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
Copyright 2004 AFETY Vac uum Switch Low Lim it L1 20 Exha ust Air Intake Co mb ustion Fan AcuTron Wiring Harness www.pelprostoves.com EATURES High Lim it L 250 Fan Lim it F 140 PELPRO OWNERS MANUAL Dansons Group Inc.
Copyright 2004 HECK for Extended Warranty. Heat Tubes Tube Scraper Window Burn Grate Burn Pot E Z Clean Grate www.pelprostoves.com Hopper Auger Auger Motor Fan Motors Exhaust Air Intake Ash Pan Cutaway View Figure 4 PELPRO OWNERS MANUAL Dansons Group Inc.
4” If venting outside of shaded area. 3” “PL” Vent, if venting in shaded area. must 0’ www.pelprostoves.com GENERAL 33’ 30’ 25’ Diameter “PL” Vent 20’ 4” Diameter 15’ 10’ 5’ 0’ 5’ 10’ PELPRO OWNERS MANUAL Dansons Group Inc.
Must be a minimum of 36” above the roof and 24” above the highest point of the roof within 10’. adian Comfort Industries Copyright 2004 . . . Continued (Figures 7 & 8) 12” www.pelprostoves.com Figure 8 3’ 2’ 10’ Figure 9 PELPRO OWNERS MANUAL Dansons Group Inc.
1 – 2” Aluminum Flex Duct – compressed 15” length, extends to 30” – 36” 2 – 2” Worm Gear Clamps NOTE: Available from your local Authorized Dealer or Dansons Group Inc. 1-877-303-3134 Figure 9 adian Comfort Industries Copyright 2004...
3” From PL Vent to Combustibles 6” Non Combustible Surface In Front Of Heater 36” to drapes, doors, anything that can swing 3” 1” 1” 10” 2” www.pelprostoves.com NSTALLATION (FIGURES 10 – 15) NTERIOR ERTICAL 2” 6” Figure 11 PELPRO OWNERS MANUAL Dansons Group Inc.
Outside Air Intake Hearth Pad PL Vent Length Stove Exhaust PL 45 deg elbow PL Screened End Cap Fresh Air Hood Combustion Air Intake PL Pipe Adaptor Figure 16 www.pelprostoves.com (Figure 16) stove's outside air PELPRO OWNERS MANUAL Dansons Group Inc.
HORIZONTAL, OUT THE WALL, THEN VERTICAL THROUGH THE EVES AND ROOF , terminating with a rain cap. Figure 22. Figure 17 16” Figure 20 adian Comfort Industries Copyright 2004 . . . continued (Figures 17 - 22) Figure 18 Figure 21 www.pelprostoves.com Figure 19 Figure 22 PELPRO OWNERS MANUAL Dansons Group Inc.
Fresh Air Duct Fresh Air Hood Stove Exhaust Pipe Adapter Clean Out Tee Tee Support Bracket Pipe Firestop Spacer / Ceiling Support Roof Flashing / Storm Collar Rain Cap BOLT(S) FRAME GROUND W IRE Figure 24 PELPRO OWNERS MANUAL Dansons Group Inc.
(See Following statement) THIS FIREPLACE HAS BEEN ALTERED TO ACCOMMODATE A FIREPLACE INSERT AND SHOULD BE INSPECTED BY A QUALIFIED PERSON PRIOR TO RE-USE AS A CONVENTIONAL FIREPLACE! adian Comfort Industries Copyright 2004 NSERT NSTALLATION www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
Page 19
Copyright 2004 NSTALLATION … allowed in Canada Metal Sealing Plate 6” www.pelprostoves.com CONTINUED FULL CHIMNEY RELINE Note: This installation recommended for all chimney installations! Liner Support 8” Optional 18” Metal Plate Figure 26 PELPRO OWNERS MANUAL Dansons Group Inc. Deluxe Cap...
3 ½” 8 1/4” Air Inlet 2’ 10’ Wood Frame Construction 3” minimum air gap 2” Min. Air gap Wall Band / Support Brkt every 5’ 6” Clean Out Tee PELPRO OWNERS MANUAL Dansons Group Inc. Exhaust Exhaust 7 3/4”...
’ Vertical Vent Installation Chase 2’ 8” 18” Shroud 6” Stand Off Part ACISOVL PELPRO OWNERS MANUAL Dansons Group Inc. Rain Cap Storm Collar Metal Chase Cap Ceiling Support / Firestop Spacer Wood Frame Construction Wall Band / Support Brkt every 5’...
2. If stove fails to ignite a second time, disconnect and contact your dealer . 3. Adjust the FUEL RATE and the FAN SPEED to your desired settings you require upon completion of startup sequence. www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
The FEED RATE works in a synchronized manner setting both the fuel rate and combustion air at the same time. When fuel is increased by setting the FEED RATE higher, combustion air is automatically increased and visa versa. ANUAL OR HERMOSTAT HERMOSTAT www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
Down” mode. The fire will go out and the fans will continue to run until your stove cools down at which time the fans will automatically shut off and NO LED’s will remain ON. adian Comfort Industries Copyright 2004 CONTINUED – Factory Settings www.pelprostoves.com Decrease Increase FINE TUNE ADJUSTMENTS FAN SPEED AUGER CYCLE SPEED PELPRO OWNERS MANUAL Dansons Group Inc.
Contributing factors : venting system providing excessive draft. Refer to the "Trouble Shooting Guide" section of this manual, and if necessary, contact your local Specialty Retailer, Certified HVAC Service Depot, or Dansons Group Inc. Customer Service Department at 1-866-456-9269. adian Comfort Industries...
LED’s #3 and #4 flash together this indicates the thermostat will run in the HIGH / LOW cycle. When the #1 and #2 LED’s flash together this indicates the ON / OFF cycle has been chosen. (Flashing 3 & 4) www.pelprostoves.com (option) PELPRO OWNERS MANUAL Dansons Group Inc.
DAMPER. This will have to be set, as the Stove Back Panel Decrease FINE TUNE ADJUSTMENTS In a few instances the speed and INCREASE fuel rate turn trimmer PELPRO OWNERS MANUAL Dansons Group Inc. Air Inlet Slide Rod Rubber GrometT Right Hand Side Panel Increase...
Comfort Industries Copyright 2004 ELLET www.pelprostoves.com Amount of pellets burned 1.50 to 2.25 lbs. Per hour 2.25 to 3.00 lbs. Per hour 3.50 to 4.00 lbs. Per hour 4.00 to 5.50 lbs. Per hour PELPRO OWNERS MANUAL Dansons Group Inc.
NOTE: Since Dansons Group Inc. or Canadian Comfort Industries has no control over the quality of pellets that you use, we assume no liability caused by the quality of wood pellets used.
Grasp the burn grate adjustment tab (F), with a pair of pliers and bend it slightly to left or right (and re-install into burn box) until its length allows the burn grate top to rest tightly onto the burn grate bottom. (Location J) adian Comfort Industries Copyright 2004 www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
Remove the ashtry, (c), and dump the ash as needed. [COLD STOVE ONLY as hot glass may cause serious burns] To enjoy a www.pelprostoves.com LEANING Hopper Auger Auger Motor Fan Motors Ash Pan PELPRO OWNERS MANUAL Dansons Group Inc. Exhaust Air Intake...
Use a damp cloth to clean your gold door. DO NOT USE RIODIC We recommend using a high quality glass cleaner. Should a In the event you need replacement only Neo-Ceram of the correct size and www.pelprostoves.com PELPRO OWNERS MANUAL Dansons Group Inc.
Page 34
[COLD STOVE AND COLD ASHES ONLY] . After the last burn in the spring A yearly servicing and cleaning by your Authorized PELPRO Dealer is Window www.pelprostoves.com Hopper Auger Auger Motor Fan Motors Exhaust Air Intake Ash Pan PELPRO OWNERS MANUAL Dansons Group Inc.
CAUTION: The electrical, auger and heat control components of your stove are not owner serviceable. Contact your local Specialty Retailer, Certified HVAC Service Depot, or Dansons Group Inc. Customer Service Department at 1-866-456-9269 for proper diagnosis of problems and service of those components.
Comfort Industries Copyright 2004 IMITED ARRANTY or online at www.dansons.com/support SUPPLIERS www.pelprostoves.com PURCHASER, ACCEPTS PELPRO OWNERS MANUAL Dansons Group Inc.
"Acu-Tron" Control Board, Wiring Harness, Thermostat Interface, Wall Thermostat, 25' x18/2 wire Fahrenheit - Celsius Contact your local Specialty Retailer, Certified HVAC Service Depot, or Dansons Group Inc. Customer Service Department at 1-866-456-9269 for additional information. adian Comfort Industries Copyright 2004 “A”...
ACGLGA AGDRGA60 ACCBFGA ACCVFGA AGADGA AGNCGP AGNCGE ACSDGR AGSCGR top & bottom only AGSCGRKT ACSLGR ACHEEX AGHOEX06 (approx. 50lbs.) AGHOEX12 (approx. 100lbs.) AGDSPKT 1of each fan, motor, timers, AGDSAKT ACDDG ACCVLTM ACDSHB ACFNCKN ACFLCKN PELPRO OWNERS MANUAL Dansons Group Inc.
Page 39
3 Prong Plug Power Cord w/ ends Wall Thermostat Kit "Acu-Tron" Board c/w Low Volt Wall Thermostat Contact your local Specialty Retailer, Certified HVAC Service Depot, or Dansons Group Inc. Customer Service Department at 1-866-456-9269 for additional information. adian Comfort Industries Copyright 2004 …continued...
Has Dealer / Installer gone over the operation and maintenance of appliance? _________ adian Comfort Industries Copyright 2004 URCHASER DDRESS /PC: NSTALL ERIAL UMBER ESCRIPTION OF WORK DONE See www.dansons.com/support www.pelprostoves.com Service & Maintenance Log ’ TATE HONE NSTALLED URNED PELPRO OWNERS MANUAL Dansons Group Inc.