Main Control Panel - Corkill Systems Reporoa Engineering 2807D Instruction Manual

THE REPOROA HIGH LIFT GATE CONTROLLER ELECTRONIC SYSTEM
COMMONS
TO S UPPL Y
TE RMINAL S
3
1 & 2
BAR
PL US EARTH
MULTICORE CABLE
MAIN
JUNCTION
BOX
MAIN
SUPPLY
230V
PUSH BUTTON STATION
CONNECTIONS
1. MULTICORE CABLE:
(a) Connect corresponding numbers in the Control Box to the Multi-core cables #3 through to #8.
(b) Connect corresponding numbers in the Main Junction Box to the Multicore cables #3 through to #8.
2. Push Button Station, connect in the Main Junction Box as per the following;
Multicore #3 to White/Orange (Common)
Multicore #6 to White/Blue (Down Button)
3. Microswitches, all switches are normally closed and open when activated, all switches share Common Terminal #3 at the Main Control Panel. The Gate Lift
Microswitch only requires three cores (shared Common) and Forward and Reverse switches require two cores.
4. Siren, this is hard wired in the Main Control Panel. The sounder has two tones, the first sound (Red Wire) is for normal Forward operation,
the second tone (Blue wire) will be activated if an Alarm condition is activated in the Main Control Panel.
Reset by turning the Isolator "OFF" for 40 seconds and then back on after rectifying fault condition.
This manual subject to copyright and not to be copied without the express permission of Corkill Systems Limited
CSLRHLG-MANUAL-2014.DOC
Model 2807D – 2014

MAIN CONTROL PANEL

MULTICORE CABLE NUMBERS
3 4 5 6 7 8 UP
1.5mm
SIMLPLE CONNECTION WITH 8 CORE
MULTICORE
S U D F R
P O E
T O
W V
O R
N E
P W
R
A
S
R
E
D
Multicore #4 to Orange/White (Stop Button)
Multicore #7 to Green/White (Forward Button)
Copyright June 2001 – Steve Corkill
MICROSWITCHES SIREN OUTPUT
DN FWD REV RED BU BK
LOCATED ON GATE
TO TERMINAL 3
REVERSE
M S/W
FWD
M S/W
DOWN
M S/W
UP
M S/W
F R
W E C
D V Y
C
W W L
A A E
S S
H H
Multicore #5 to Blue/White (Up Button)
Multicore #8 to White Green (Reverse Button)
CORKILL SYSTEMS LTD
OPUNAKE, T ARANAKI. NEW ZE ALAND
Ph (06) 761 7531 Fax (06) 761 7336
REPOROA LIFT GATE CONTROL
24Volts DC CIRCUIT DIAGRAM
CSLRH LG-WIRE-24V-2012.PUB
Page 17
C
O
M TERMINALS
3 A
SIREN
MULTICORE
CABLE
1.5mm
PRESSURE (NO)
M S/W
USE 12 CORE MULTICORE
TO USE THESE OPTIONS
P
S
P U
Y
U L
N
L L
C
S
/
E S
W
5 Tasman St, PO Box 16
2012 Model
22/02/2012
24/07/2014
TOP
B C
MAIN
JUNCTION
BOX
S
Y
N
C
S
W