Table of Contents
Related Manuals for amiad ABF-10000
Summary of Contents for amiad ABF-10000
- Page 1 AMIAD Water Systems "ABF-10,000" FILTERS Automatic Brush Filters 8" - 14" Serial number: Order number: Catalog number: Filtration degree: Tested by: Installation, Operation and Maintenance Instructions Ref: 910101-000596 / 08.2019...
- Page 2 Amiad or consult Amiad experts or its authorized representatives if you have any questions. Amiad Water Systems Ltd. D.N. Galil Elyon 1, 1233500, Israel Tel: 972 4 690 9500 | Fax: 972 4 814 1159 Email: info@amiad.com ABF-10000 FL Filter 910101-000596 / 08.2019...
-
Page 3: Table Of Contents
Parts schedule ............................14 Parts drawing (View #1) ..........................15 Parts drawing (View #2) ..........................16 Limited Warranty ............................20 With any inquiry please quote Filter Serial Number, located on the filter nameplate. ABF-10000 FL Filter 910101-000596 / 08.2019 - 3 -... - Page 4 Stainless Steel 316, PVC and Delarin Exhaust valve Epoxy-Coated, Cast Iron Seals Control system Brass, Stainless Steel, Engineering plastic, Polyethylene Filtration degrees available Perforated Screen Wedgewire Screen Micron 3500 2500 1500 ABF-10000 FL Filter 910101-000596 / 08.2019 - 4 -...
-
Page 5: Safety Instructions
➢ Always observe standard safety instructions and good engineering practices whilst working in the filter’s vicinity. ➢ Use the filter only for its intended use as designed by Amiad, any misuse of the filter may lead to undesired damage and may affect your warranty coverage. - Page 6 Operation procedures exactly as described in this manual. ➢ Commissioning the filter should be done by an authorized Amiad technician, do not attempt to commission the filter unaccompanied since this may lead to undesired damage and may affect your warranty coverage.
- Page 7 Maintenance Before any maintenance or non-regular operation please read the following: ➢ Servicing the filter should be done only by technicians authorized by Amiad. ➢ Disconnect the filter from the power supply and lock the Main Power Switch. ➢ Disconnect the compressed air supply, release the residual pressure and lock the Pneumatics Main Valve.
-
Page 8: Dimensional And Recommended Installation Drawing
DIMENSIONAL DRAWING & RECOMMENDED INSTALLATION This is a conceptual installation drawing. Note that piping is not included. KEY: 12" INLET MANIFOLD. 12" INLET BUTTERFLY VALVE. 12" ABF-10000 FILTER. 3" HYDRAULIC VALVE. NON RETURN VALVE. 12" OUTLET BUTTERFLY VALVE. 12" OUTLET MANIFOLD. - Page 9 4. The exhaust valve closes. Through the self-cleaning process there is no interruption of flow, and the PDS is constantly monitoring the pressure differential between the inlet and outlet of the filter. ABF-10000 FL Filter 910101-000596 / 08.2019 - 9 -...
-
Page 10: Installation And Start-Up Instructions
After the 15 second cleaning operation, the flow out of the exhaust valve should stop immediately. Be sure to observe that there is no significant leakage occurring from the exhaust valve once the cleaning operation has completely stopped. ABF-10000 FL Filter 910101-000596 / 08.2019... -
Page 11: Electrical Control System Description
It is possible to order control boards with additional features such as sequential operation of a few filters in a battery, flushing counter, etc. Follow the drawing in this manual for proper wiring of the control board to the filter. ABF-10000 FL Filter 910101-000596 / 08.2019 - 11 -... - Page 12 11. Re-connect the power cables. 12. Switch the power on. 13. Press the TEST push-button and make sure that the filter is working properly. 14. Gradually, turn on the water, watch and eliminate any leaking. ABF-10000 FL Filter 910101-000596 / 08.2019 - 12 -...
-
Page 13: Maintenance
4. Clean the 3/4" control filter. Maintenance prior to re-operation 1. Change the shaft sealing O-ring (#8 & #9). 2. Connect the control board to the mains. 3. Check proper operation of the filter. ABF-10000 FL Filter 910101-000596 / 08.2019 - 13 -... -
Page 14: Parts Schedule
Hex Bolt Full Thrd M6X15 S/ST316 DIN933 Flat Washer M6 DIN125 S/ST316 Spring Washer M6 DIN127 S/ST316 Electrical Junction Box for Baccara (ABF-10000) Phillips Pan Machine Screw M5x16 S/St304 DIN7985 Flat Washer M5 DIN125 304 Hex Nut M5 304 DIN934 Pressostat Sub-As. - Page 15 O-Ring Seal P2-112 NBR Raccord Nut 3/4" for 3/4" Filter Pressure Check Point Connector 1/4"X1/4" Pilot Tube 8 MM Black Catalogue Number might differ to filter diameter, flange standard or electricity specifications. ABF-10000 FL Filter 910101-000596 / 08.2019 - 15 -...
- Page 16 PARTS DRAWING Standard ABF 10000 - Section #1 (Page 1) ABF-10000 FL Filter 910101-000596 / 08.2019 - 16 -...
-
Page 17: Parts Drawing (View #1)
Standard ABF 10000 PARTS DRAWING - Section #1 (Page 2) ABF-10000 FL Filter 910101-000596 / 08.2019 - 17 -... - Page 18 PARTS SCHEDULE Standard ABF 10000 - Section #2 Description ABF-10K Zinc Coat Coupling Shaft Motor Side Plastic Washer Coupling ABF-L Coupling Assy ABF-10000 (Brush Side) Zinc Coated ALLAN SCREW M10X35 DIN 912 ST/ST304 PARTS DRAWING Standard ABF 10000 - Section #2 ABF-10000 FL Filter 910101-000596 / 08.2019...
- Page 19 PARTS SCHEDULE Standard ABF 10000 - Section #3 Description Spindle and Frame ABF-10000 (Coupler) BRUSH - ONE UNIT (ABF-10000) Hex Bolt Full Thread M6X25 S/ST316 DIN933 Flat Washer M6 DIN125 S/ST316 Hex Nut M6 S/ST316 DIN934 PARTS DRAWING Section #3 ABF-10000 FL Filter 910101-000596 / 08.2019...
-
Page 20: Limited Warranty
Buyer Complaint Form, the submission of the complaint or any questions please contact your service representative. Upon written demand by Amiad the Buyer shall return the Defective Product - or a sample thereof - to Amiad, at Amiad's cost. If the Buyer ships any such Defective Product, Amiad suggests the Buyer package it securely and insure it for value, as Amiad assumes no liability for any loss or damage occurring during shipment. - Page 21 Amiad Water Systems Ltd. D.N. Galil Elyon 1, 1233500, Israel. Tel: +972 4690 9500 | Fax: +972 48141159 | Email: info@amiad.com Obelis s.a. Bd Général Wahis 53, 1030 Brussels, Belgium. Tel: +(32) 2732 5954 | Fax: +(32) 27326003 | Email: mail@obelis.net...
Need help?
Do you have a question about the ABF-10000 and is the answer not in the manual?
Questions and answers