U-Line Wine Captain Echelon Series Installation Manual
Hide thumbs
Also See for Wine Captain Echelon Series:
- Installation manual (16 pages) ,
- Use and care manual (24 pages)
Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for U-Line Wine Captain Echelon Series
Summary of Contents for U-Line Wine Captain Echelon Series
- Page 1 Installation Guide ® 2175WC Wine Captain ® and 2175WCOL Wine Captain with Overlay www.U-LineService.com Phone (414) 354-0300 • FAX (414) 354-7905 Service & Parts Tech Lines Phone (800) 779-2547 • FAX (414) 354-5696 OnlineService@U-Line.com ©2006 U-Line Corporation 06/2006...
-
Page 2: Table Of Contents
2175WC/2175WCOL Wine Captain ® Contents 1 Follow Safety Precautions Exterior Cleaning ......Cut-Out Dimensions . - Page 3 2175WC/2175WCOL Wine Captain ® General Precautions 2 Inspect and Plan Use this appliance for its intended purpose only and follow these general precautions along with those listed You have received a carton containing your 2175WC or throughout this guide: ® 2175WCOL Wine Captain with a package inside containing a Use and Care Guide, a Product Registration...
-
Page 4: Exterior Cleaning
Stainless Steel Polish and Cleaner or comparable product or a mild detergent and warm water solution and soft Your U-Line product has been designed for either free- cloth. Do NOT use abrasive cleaning agents. standing or built-in installation. When built-in, your unit does not require additional air space for top, sides or rear. -
Page 5: Product Dimensions
Reversing the Door 23-15/16" (Black Units Only) Wood Overlay Figure 2 All U-Line units (except Stainless Please note that the unit has adjustable feet that can add Steel models) may be one additional inch to height during leveling or to match left- or right-hand adjacent cabinets (see Figure 29 on Page 13). -
Page 6: Other Site Requirements
ULIN_0003_A Figure 7 Figure 8 Environmental Requirements Many U-Line models are designed to operate in harsh 5. Remove existing bottom hinge (3 screws) and remount outdoor/marine environments. Special considerations on opposite side TOP. Remove hinge screw pin. include the following: 6. -
Page 7: Side-By-Side Installation Instructions
For a complete refreshment center, install your 2175WC or trimmed wine racks that are coated at the factory with a 2175WCOL unit beside a U-Line Refrigerator, Ice Maker or clear vinyl sealer, which will adequately protect the wood Combo Model (see Figure 11 for typical cut-out). Note in normal usage. -
Page 8: Wood Trim Finishing
4. Allow stain to dry for a minimum of three hours before applying the final finish. Interior components of your U-Line unit are equipped 5. If desired, sand the wood with very fine sandpaper to with a natural wood trim for appearance and durability. -
Page 9: Overlay Frame
2175WC/2175WCOL Wine Captain ® Overlay Frame 2. Typical routing dimensions 3/4" are shown in Figure 14. (2175WCOL Units Only) Frame Preparation 1-1/8" 1-13/16" An overlay frame covers the door frame to give a built-in 2-1/4" appearance. Appropriate hardware and a copy of these 11/16"... - Page 10 2175WC/2175WCOL Wine Captain ® Height: 1-17/32" from top edge of frame (less 1/8" for 2. Visually check for gap between frame and glass. If there depth of notch on top of frame) is an objectionable gap, follow steps under Applying Foam Tape to Overlay Frame.
- Page 11 2175WC/2175WCOL Wine Captain ® Note: The door frame is designed with a slight amount of IMPORTANT “play” to square it to the overlay frame. User-supplied cabinet handle MUST be counter bored to 6. Remove all traces of tape securing overlay frame to make sure mounting hardware is below surface of overlay door frame.
-
Page 12: Checking Door Alignment
2175WC/2175WCOL Wine Captain ® 5 Adjust Door Checking Door Alignment Slotted Mounting The unit’s door is aligned at the factory before shipment. Holes However, its alignment could have been disturbed during Angled Edge Towards Center shipment or during overlay frame installation. of Door IMPORTANT Properly aligned, the door should be 1/8"... -
Page 13: Electrical Specifications
2175WC/2175WCOL Wine Captain ® 6 Prepare Power Supply 7 Level the Unit Electrical Specifications Leveling Information Note: It is recommended that the unit is level. CAUTION 1. Use a level to check the Electrical installation must observe all state and local levelness of the codes. -
Page 14: Anti-Tip Bracket Installation
2175WC/2175WCOL Wine Captain ® 8 Install the Unit Anti-Tip Bracket Installation 1. Locate two Anti-Tip Brackets included inside the unit. 2. Place the unit into the area where it will be installed. Check the door, sides and top for a proper fit. Also test to make sure the door opens and closes freely. -
Page 15: Installation Troubleshooting
2175WC/2175WCOL Wine Captain ® Installation Troubleshooting 9 Start-Up for the First Time Problem Initial Start-Up The door remains open unless it is pushed closed. The unit is shipped with the control preset. No adjustments should be necessary at this time. For information about Solution Adjusting the Temperature Control, see the Use and Care The hinges should be self-closing when the door is open... -
Page 16: Service Information
For more than four decades, U-Line has distinguished itself as the leader in built-in undercounter ice making, refrigeration and wine storage appliances. U-Line Corporation, located in Milwaukee, WI, is a family operated manufacturer of built-in ®...
Need help?
Do you have a question about the Wine Captain Echelon Series and is the answer not in the manual?
Questions and answers