Related Manuals for Remington RA3000/50
Summary of Contents for Remington RA3000/50
- Page 1 3HP 50L AIR COMPRESSOR RA3000/50 The RA3000/50 is designed to tackle large tasks in the serious home work- shop such as tyre inflating, paint spraying, air nailing, stapling and operating an air wrench.
-
Page 2: Table Of Contents
CONTENTS Introduction..........3 General Safety Rules........4 Specific Safety Rules........5 Parts Overview..........6 Assembling the Compressor......7 Checking/Filling the Oil........7 Pre-start Checklist........8 Operating Instructions.........8 Preventative Maintenance Schedule..10 Troubleshooting.........11 Glossary of Terms........16 Warranty...........17 Notes...........18... -
Page 3: Introduction
Once registered, please log a request online or call us on 0800 387 678. Your new Remington Air compressor Specifications: has been manufactured under stringent AS/NZS Quality Standards to meet superior performance criteria. -
Page 4: General Safety Rules
GENERAL SAFETY RULES WARNING! Read and understand all instructions. Failure to follow all instructions listed below may result in electric shock, fire, and/or seriouis personal injury. -
Page 5: Specific Safety Rules
SPECIFIC SAFETY RULES... -
Page 6: Parts Overview
PARTS OVERVIEW Compressor Pump Air Tank On / Off Pressure Switch Non Return Valve Safety Valve Drain Valve Pressure Regulator 10. Electric Motor Regulator Gauge 11. Air Filters Tank Gauge... -
Page 7: Assembling The Compressor
ASSEMBLING THE COMPRESSOR This air compressor requires some minor assemble before it can be used. Locate the accessory pack. It should contain: • Wheels and Axle Set • Rubber Stopper • Air Filter • Oil Breather Plug • A Bottle of Oil 1. -
Page 8: Pre-Start Checklist
PRE-START CHECKLIST • Ensure the unit is stable in a well-ventilated dry position. Turn On • Ensure that the drain valve is closed and all air outlets are closed. • Connect the power lead to the mains. Turn Off Pressure Regulator •... - Page 9 ALWAYS MAKE SURE YOU:...
-
Page 10: Preventative Maintenance Schedule
PREVENTATIVE MAINTENANCE SCHEDULE WARNING! Before maintenance operation, stop the air compressor, disconnect the unit from the mains supply and discharge all air in the air tank. IMPORTANT! The pump oil must be changed after the first 10 hours of operation. This will remove contaminants contained in the crankcase due to break-in Recommended Compressor Oil: Use SAE30 for temperatures over 10 C and use SAE10 below 10... -
Page 11: Troubleshooting
In some cases, the operator or maintenance personnel can perform the corrective actions, while others may require the assistance of a qualified Remington compressor technician or dealer. This procedure has been written assuming that the unit has been installed correctly and has been operating &... - Page 12 Possible Cause Possible Solution Problem Possible defective safety / relief Operate safety valve manually by valve. pulling on test ring. If it still leaks, replace. Fittings not tight enough or leaking. Warning: Drain air before tightening. Tighten fittings where air can be heard leaking.
- Page 13 Possible Cause Possible Solution Problem Connecting rod, piston pin or crank Inspect all. Repair or replace as wrist pin bearings worn or scored. required. Air compressor is not large enough Check the accessory air requirements for air required. - if higher that the CFM or pressure supply of compressor a larger compressor is required.
- Page 14 Possible Cause Possible Solution Problem Detergent type lubricant being used. Drain existing lubricant and refill. Cylinder or piston scratched, worn Repair or replace as required. or scored. Connecting rod, piston pin or crank Inspect all. Repair or replace as wrist pin bearings worn or scored. required.
- Page 15 Possible Cause Possible Solution Problem Cylinder or piston scratched, worn Repair or replace as required. or scored. Connecting rod, piston pin or crank Inspect all. Repair or replace as wrist pin bearings worn or scored. required. Crankcase seal worn or crankshaft Replace seal or crankshaft assembly.
-
Page 16: Glossary Of Terms
GLOSSARY OF TERMS... -
Page 17: Warranty
Registered warranty period component to rectify and repair the non-warranty failure for the Remington RA3000-50 Compressor: is the customers’ full responsibility. 12 Months The decision that an issue with a product qualifies as a... -
Page 18: Notes
NOTES... - Page 20 Congratulations on your new Remington Air purchase. We are proud to have you as our customer and will strive to provide you with the best service and reliabil- ity in the industry. This product is backed by our extensive warranty and service network.
Need help?
Do you have a question about the RA3000/50 and is the answer not in the manual?
Questions and answers