Owner's Manual for Petrol Generator Introduction This unit has been designed to provide DANGER high-performance, efficient operation, and years of use when maintained properly. Indicates a hazardous situation which, if not avoided, will result in death or serious injury. WARNING Consult Manual.
Owner's Manual for Petrol Generator DANGER WARNING Asphyxiation. The exhaust system must be properly Injury and equipment damage. Do not use generator maintained. Do not alter or modify the exhaust system as a step. Doing so could result in falling, damaged as to render it unsafe or make it noncompliant with parts, unsafe equipment operation, and could result local codes and/or standards.
Owner's Manual for Petrol Generator Electrical Hazards WARNING DANGER Explosion and fire risk. Do not smoke near unit. Keep fire and spark away. Failure to do so could Electrocution. Contact with bare wires, result in death, serious injury, or property or terminals, and connections while generator equipment damage.
Owner's Manual for Petrol Generator Figure 2-1. Features and Controls Know Your Generator TABLE 1. Generator Components WARNING Recoil Starter Consult Manual. Read and understand manual Fuel Tank Vent completely before using product. Failure to completely understand manual and product Fuel Cap could result in death or serious injury.
Page 7
Owner's Manual for Petrol Generator TABLE 2. Product Specifications Generator Specifications AI2300 60 Hz 2300 W 1800 W 120 V AC Output Amperage 15 A Dimensions L x W x H (in/mm) 19.7 x 11.8 x 18.1 (500 x 300 x 460) 20 Kg ** Operating Temperature Range: -13 deg.
Owner's Manual for Petrol Generator Connection Plugs Economy Switch The economy switch has 2 modes of opera- AC Socket tion: • ON: The quietest mode and best when run- The AC outlet is overload protected by the ning appliances or equipment that are invertor.
Owner's Manual for Petrol Generator If this occurs, disconnect all electrical loads to NOTE: The generator is shipped without oil in the engine. Add oil slowly and verify oil level determine the cause of the problem before often during filling process to ensure overfilling using the generator again.
Owner's Manual for Petrol Generator Figure 2-9.Fuel Cap Figure 2-8. Safe Operating Range 4. Turn cap slowly to remove. 7. Remove dipstick and verify oil level is within safe operating range. 5. Slowly add recommended fuel. Do not overfill. NOTE: Verify oil level often during filling pro- 6.
Owner's Manual for Petrol Generator Before Starting Engine Grounding the Generator When 1. Verify engine oil level is correct. In Use 2. Verify fuel level is correct. The generator is equipped with an equipment 3. Verify unit is secure on level ground, with ground connecting the generator frame and proper clearance and is in a well ventilated the ground terminals on the AC output recep-...
Owner's Manual for Petrol Generator is provided to assist Wattage Reference Guide Oil Fired Space Heater (30,000 Btu) in determining how many items the generator *Paint Sprayer, Airless (1/3 HP) can operate at one time. NOTE: All figures are approximate. See data Paint Sprayer, Airless (hand-held) label on appliance for wattage requirements.
Owner's Manual for Petrol Generator 3-2. When engine starts, rotate Figure Low Oil Level Shutdown System OFF/ON/CHOKE dial to ON (2).CHOKE The engine is equipped with a low oil level operation reduced OFF/ON/- sensor that shuts down the engine automati- CHOKE dial is rotated towards ON.
Owner's Manual for Petrol Generator Parallel Operation For output power up to 3420W, two invert- ers can operate in parallel using Parallel Kit (optional). See the Parallel Kit Operator’s Manual. NOTE: All connections to the parallel kit should be made while both inverters are turned off and all loads disconnected.
Owner's Manual for Petrol Generator Maintenance Preventive Maintenance Regular maintenance will improve perfor- Dirt or debris can cause improper operation mance and extend engine/equipment life. and equipment damage. Clean generator We recommends that all maintenance work daily or before each use. Keep area around be performed by an Independent Autho- and behind muffler free from combustible...
Page 16
Owner's Manual for Petrol Generator 7. Replace oil fill cap and hand-tighten. NOTE: Some units have more than one oil fill location. It is only necessary to use one oil fill SAE 30 point. 10W-30 Change Engine Oil Synthetic 5W-30 WARNING Accidental start-up.
Page 17
Owner's Manual for Petrol Generator 9. To check oil level, remove funnel and insert dipstick into oil filler neck without screwing it in. See Figure 4-2. 10. Remove dipstick and verify oil level is within safe operating range. NOTE: Verify oil level often during filling pro- cess to ensure overfilling does not occur.
Owner's Manual for Petrol Generator 4. Replace the screens, and retainer, and Prepare Fuel System/Engine for secure with clamp. Storage Fuel stored over 30 days can go bad and damage fuel system components. Keep fuel fresh, use fuel stabilizer. If fuel stabilizer is added to fuel system, pre- pare and run engine for long term storage.