MAD AMPX ESC 120A HV Manual

AMPX ESC 120A HV
5~18S
Electronic Speed Controller manual
Disclaimer
Thank you for choosing this product. Please carefully read this manual before using this product. Using this product will indicate you're agreed
with the all items in this manual. Please strictly follow these items during usage. We'll not commit any responsibility including but not limited to
indirect loss or joint responsibility caused by improper usage, private modification and other faults. The maximum compensation will be not
more than the cost of product itself.
Attention
Please follow local laws and regulations to legally use this product in flight, and be sure to stay away from people, high-tension lines, and
public places.
This product has strong power and high speed propeller operation with certain safety risks. Users must older than 18 years old and have
relevant professional knowledge.
Do not get close to the motor or propeller that rotates at high speed to avoid being cut.
Before flight, please carefully check that all parts are in good condition, propeller and motor are installed correctly, and screws are not loose.
Features
Quick response. it will take only 0.25 seconds from starting motor to full speed running.
Good compatibility and stability with special control algorithm for disc motors.
Synchronous freewheeling technology can bring better throttle linearity, driving efficiency and automatic energy recovery when lowering
motor speed.
Have output interfaces of RPM and error signal.
IP67 waterproof grade with sealing, fireproof and waterproof process, and packaging with anti-corrosion shell.
Convenient installation screw holes without considering ESC part front and back sides.
Protection Function
Short Circuit Protection
Short circuit protection is triggered when the ESC detects a short circuit. ESC will power off, and will rework after trouble shooting and
powering again.
Stalling Protection
Motor stall will trigger stalling protection. ESC will resume after making throttle zero and powering again.
Voltage Protection
Once checking voltage is less than 16V or more than 64V, ESC will alarm and will not start up motor. But it will be out of effect during flying.
Temperature Protection
During flight, if the temperature of the ESC is higher than 125°C, it will generate a fault signal and start reducing the output power to 50% of the
maximum value. If the temperature continues to rise to 140°C, the ESC will turn off the output, and the normal output will not be restored until
the throttle setting is reset to zero. When the temperature drops to 80°C, the output power of the ESC starts to rise to the maximum value.
Throttle Loss Protection
When the detected throttle signal is lost for more than 2 seconds, the ESC will automatically shut down. After the throttle signal is restored,
the ESC will work again.
Start Protection
When the motor is not started after increasing the accelerator for 10 seconds, the ESC will automatically shut down. After the accelerator is
reset to zero, and the accelerator is pushed again, the ESC will return to normal.
Throttle Stroke Setting
First to connect motor with ESC, then to power on & adjust throttle to top, you will hear sound of Beep-Beep for two times. Then adjust the
throttle to lowest, you will hear a sound of Do-Mi-So, that means the throttle stroke has been set successfully.
V1.0