How To Start; Maintenance; Customer Responsibilities - Craftsman CM0200141A Instruction Manual

How to Start

1.
to build. Motor will stop when tank pressure reaches
2.

MAINTENANCE

WARNING: To reduce the risk of serious personal
injury, turn unit off and disconnect it from
power source before making any adjustments or
removing/installing attachments or accessories.
WARNING: Risk of unsafe operation. Unit
cycles automatically when power is on.
When performing maintenance, you may be
exposed to voltage sources, compressed air,
or moving parts. Personal injuries can occur.
Before performing any maintenance or repair,
disconnect power source from the compressor

Customer Responsibilities

Before each
use
Check Safety Valve X
Drain Tank
Remove tank from
service
1- For more information, call our Customer Care Center at 1-888-899-0146
or 1-888-331-4569.
NOTE: See Operation
To Check Safety Valve (Fig. C)
WARNING: Risk of Bursting. If the safety valve
does not work properly, over-pressurization may
occur, causing air tank rupture or an explosion.
WARNING: Risk from Flying Objects. Always
wear certified safety equipment: ANSI Z87.1 eye
Before starting compressor, pull the ring on the safety
to make sure that the safety valve operates freely. If
the valve is stuck or does not operate smoothly, it must be
to "On" and allow tank pressure
clockwise to increase pressure
Daily or after See tank
each use warning
label
X
X
Fig. C
To Drain Tank (Fig. A, D)
WARNING: Risk of Unsafe Operation. Air tanks
contain high pressure air. Keep face and other
body parts away from outlet of drain. Use
draining as debris can be kicked up into face.
WARNING: Risk from noise. Always wear proper
hearing protection during use. Under some
conditions and duration of use, noise from this
NOTE: All compressed air systems generate condensate
that accumulates in any drain point (e.g., tanks, filter,
aftercoolers, dryers). This condensate contains lubricating
oil and/or substances which may be regulated and must be
disposed of in accordance with local, state, and federal laws
1
WARNING: Risk of Bursting. Water will condense
in the air tank. If not drained, water will corrode
and weaken the air tank causing a risk of air
NOTICE: Risk of Property Damage. Drain water
from air tank may contain oil and rust which can
1.
2.
3.
4. Place a suitable container under the drain valve to
5.
6.
to "Off".
counterclockwise to set the
allowing air to bleed from
tank.
ENGLISH
8
on
7