02/2005 2075WC/2075WCOL Wine Captain 2 Inspect and Plan You have received a carton containing your 2075WC or 2075WCOL Wine Captain containing a User Manual, a Product Registration Card and an Anti-Tip Bracket Installation Kit. 2075WCOL units are shipped with a cardboard-wrapped door and an additional package of hardware.
® 3 Prepare Site Your U-Line product has been designed for either free- standing or built-in installation. When built-in, your unit does not require additional air space for top, sides or rear. However, the front grille must NOT be obstructed and clearance is required for electrical connection in the rear.
(see Figure 29 on Page 13). 02/2005 2075WC/2075WCOL Wine Captain Door Swing/Clearances Information Black, White and Wood Overlay units have a zero clearance for the door to open 90° (see Figure 3).
2075WC/2075WCOL Wine Captain 2. Remove plastic screw plugs (3 each, top and bottom) from new hinge location. Do not discard (see Figure 6). Figure 5 Figure 6 3. Remove top hinge (3 screws), reinstall hinge screw pin, and remount on opposite side BOTTOM (see Figure 7).
7. Allow the final coat to dry for 24 hours. 8. Reinstall wood trim to wine racks using screws removed in Step 2. 9. Reinstall wine racks in unit. 10. For 2075WC units, go on to 5 Adjust Door. ® ® is equipped with wood- CAUTION ®...
10. Allow the final coat to dry for 24 hours. 11. Reinstall wood trim to wine racks using screws removed in Step 2. 12. Reinstall wine racks in unit. 13. For 2075WC units, go on to 5 Adjust Door. www.U-LineService.com ® Overlay Frame...
Page 9
5/16" Dia. x 1/2" Deep Back View Figure 15 02/2005 2075WC/2075WCOL Wine Captain Route notch in top corner of overlay frame as shown (see Top and Side Views). Top of notch is entire depth of frame, front to back. Width: 13/16"...
Page 10
2075WC/2075WCOL Wine Captain Installation Instructions Preparing Door Note: Door is not attached. It is in a separate box inside the unit box and taped to the unit. 1. Lay door on a clean, flat surface with the gasket facing up.
Page 11
3/8". Door frame and overlay frame must be aligned properly or the door will not operate correctly. 02/2005 2075WC/2075WCOL Wine Captain Note: The door frame is designed with a slight amount of “play” to square it to the overlay frame.
2075WC/2075WCOL Wine Captain 5 Adjust Door Checking Door Alignment The unit’s door is aligned at the factory before shipment. However, its alignment could have been disturbed during shipment or during overlay frame installation. IMPORTANT Properly aligned, the door should be 1/8" below the top of the unit’s cabinet, NOT flush with the top (see Figure 23).
• Never use an extension cord to connect power to the unit. Go on to 7 Level the Unit. 02/2005 2075WC/2075WCOL Wine Captain 7 Level the Unit Leveling Information Note: It is recommended that the unit is level. 1. Use a level to check the levelness of the Wine ®...
2075WC/2075WCOL Wine Captain 8 Install the Unit Anti-Tip Bracket Installation 1. Locate two Anti-Tip Brackets included inside the unit. 2. Place the unit into the area where it will be installed. Check the door, sides and top for a proper fit. Also test to make sure the door opens and closes freely.
Also, re-check leveling from front to back of the unit and readjust if necessary. Make sure that pivot plate is installed correctly. 02/2005 2075WC/2075WCOL Wine Captain 9 Start-Up for the First Time Initial Start-Up The unit is shipped with the control preset. No adjustments should be necessary at this time.
For more than four decades, U-Line has distinguished itself as the leader in built-in undercounter ice making, refrigeration and wine storage appliances. U-Line Corporation, located in Milwaukee, WI, is a family operated manufacturer of built-in undercounter icemakers, Combo ®...