Sealey RE229.V4 Quick Start Manual

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear a face
instruction shield
manual
1. SAFETY
▲ DANGER! Stop compressing the spring before the coil windings touch, fig.2.A. Exercise particular caution when using an air impact
wrench.
WARNING! DO NOT compress the spring to an extent where the jaws touch.
‰
WARNING! Ensure Health & Safety, local authority, and general workshop practice regulations are adhered to when using this
‰
equipment.
WARNING! Wear approved safety face shield (standard spectacles are not adequate).
‰
DO NOT operate spring compressor if parts are damaged or missing as this may cause failure and/or personal injury.
‰
DO NOT force the spring compressor to achieve a task it was not designed to perform.
8
DO NOT allow untrained persons to use the spring compressor.
8
Familiarise yourself with the applications, limitations and potential hazards of the spring compressor.
9
Maintain the spring compressor in good condition. Replace or repair damaged parts. Use genuine parts only. Unauthorised parts may be
9
dangerous and will invalidate the warranty.
Keep the work area clean, uncluttered and ensure there is adequate lighting.
9
Keep hands and body clear of the spring when operating the spring compressor.
9
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
9
Remove ill fitting clothes. Remove ties, watches, rings, other loose jewellery. Contain and/or tie back long hair.
9
Wear appropriate protective clothing.
9
When not in use clean and store the spring compressor in a safe, dry, childproof location.
9
2. INTRODUCTION
Suitable for MacPherson strut coil springs. Features a yoke extension bracket that also allows use on conical springs. Supplied with
three pairs of different sized interchangeable yokes, for a wide range of vehicle applications. Plastic yoke protectors that protect the
spring coating from damage, which can invalidate the vehicle manufacturer's guarantee. Safety yokes carefully shaped to stop the
spring bowing while under compression.
3. SPECIFICATION
Model no's .... ..................................................RE229.V4, RE239.V2, RE249.V2 and RE259
Capacity......................................................................................................................2500kg
Max. jaw opening........................................................................................................265mm
Drive.............................................................................................................................21mm
4. CONTENTS
Contents Compressor
RE229.V4 Yes
RE239.V2 Yes
RE249.V2 Yes
RE259 No
© Jack Sealey Limited
2500KG PROFESSIONAL COIL SPRING
COMPRESSOR SET LH/RH
MODEL NO:
Wear protective
Warning!
gloves
crushing of
hands
Gold yoke
Ø80-105mm
Yes
No
Yes
No
Original Language Version
RE229.V4, RE239.V2, RE249.V2, RE259
DO NOT let coil
windings touch
Handed Black yokes Handed
Ø105-140mm
R/H Yes R/H
N/A Yes L/H
R/H Yes R/H + L/H
N/A Yes L/H
RE229.V4, RE239.V2, RE249.V2, RE259 Issue:1 05/10/22
Silver yokes Handed
Ø145-190mm
Yes R/H
Yes L/H
Yes R/H + L/H
Yes L/H