TRUE FOOD SERVICE EQUIPMENT, INC. 2001 East Terra Lane • P.O. Box 970 • O’Fallon, Missouri 63366 (636)-240-2400 • FAX (636)272-2408 • INT’L FAX (636)272-7546 • (800)325-6152 Parts Department (800)424-TRUE • Parts Department FAX# (636)272-9471 TABLE OF CONTENTS Safety Information...
Page 2
True Food Service Equipment, Inc. True Food Service Equipment, Inc..www.truemfg.com ..www.truemfg.com ...
You have selected one of the finest commercial refrigeration units made. It is manufactured under strict quality controls with only the best quality materials available. Your TRUE unit when properly maintained will give you many Use this appliance for its intended purpose as described in...
Leave the shelves in place so that children may not easily climb inside. USE OF EXTENSION CORDS TRUE will not warranty any equipment that has been connected to an extension cord..www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc.
This provides the best performance and also pre- vents overloading building wiring circuits which USE OF ADAPTER PLUGS TRUE will not warranty any equipment that has been connected to an adapter plug..www.truemfg.com ..www.truemfg.com ... SAFETY INFORMATION...
... www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc. Before you start to install your True unit, carefully inspect it for freight damage. If damage is discov- ered, immediately file a claim with the delivery freight carrier.
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS Wire Gauge for 2% Voltage Drop in Supply Circuits 115 Volt Amps Wire Gauge for 2% Voltage Drop in Supply Circuits 230 Volt Amps ...
Thread castor into the underside of cabinet frame rail. Thread leg into cabinet bottom frame rail..www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc. C. Carefully upright cabinet. Removing skid from bottom of cabinet.
Page 9
(100°F+, 38°C+), you may want to install an exhaust fan. Warning Warranty is void if ventilation is insufficient. B. Proper leveling of your True cooler is critical to operating success (for non-mobile models). Effective condensate removal and door operation will be effected by leveling.
These slotted holes slide over three thumb screws located in the front of the cabinet near the floor (See Image 1)..www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc.
True dealer or recommended service agent. D. Good air flow in your True unit is critical. Be careful to load product so that it neither presses against the back wall, nor comes within four inches of the evaporator housing (Interior Top).
Please see pages 14-15 on shelving diagrams for your specific model. PILASTER INSTALLATION & OPERATION True TR,TA, and TG cabinets are available with four different shelving / tray slide options. Type Kit #1. Angle Type Tray Slide Type Kit #2.
Page 13
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS PILASTER INSTALL/OPERATION CONTINUED... Installation Procedures (Pilasters): Install slotted thumb screws into threaded holes along the inside wall of the cabinet. Slide pilasters into position behind the slotted screws.
Page 14
Shelf Shelf Clip Image 1 ... www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLING SHELF STANDARDS IN HEATED CABINETS: (See Image 2) A. When installing shelf standards make sure the numbers on the standards are facing up. These numbers help with installing shelf clips at a level height.
Page 15
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS 18 3/16" 2 1/8" CRITICAL PILASTER E 890080 24 5/8" PILASTER B 890077 TA/TG/TR2RPT-2S-2S #1 TRAY SLIDE PART #890070 18 3/16" 2 1/8"...
Page 16
18 1/4" (TYP) CRITICAL BACK GUARD 890304 PILASTER I 890303 TA/TG/TR2DT-2S FREEZER SIDE #1 TRAY SLIDE PART #890070 True Food Service Equipment, Inc. True Food Service Equipment, Inc. 18 3/8" 3 5/8" CRITICAL (TYP) BACK GUARD 890141 PILASTER G 890140 TA/TG/TR1DT-2HS...
All refriger- ation equipment operating below 30°F will accumulate frost on the evaporator coil and will require routine defrost. Your True equipment has been designed for three defrost periods (6:00 a.m., 2:00 p.m. and 10:00 p.m.). If you decide to deviate from these defrost time settings please follow the procedures for adjustment below.
(See Image 1) Single Door Freezer unit (Brush Provided) ... www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc. Three Door Freezer unit Three Door Freezer unit (Rainshield Removal/top (Rainshield Removal / bottom...
5. When finished be sure to replace the rainshield. The rainshield protects the condenser. 6. Reconnect the electrical power to the unit. If you have any questions, please call True Manufacturing at 636-240-2400 or 800-325-6152 and ask for the Service Department. Service Department Availability Monday-Friday 7:30 a.m. to 5:30p.m.
... www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc. ___________ STEP 4 ___________ For high elevation installations, it may be necessary to "warm-up" the set points.
True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING Stainless Steel Equipment Care and Cleaning CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel surfaces.
(See Image 1). Interior Light Interior Light ... www.truemfg.com ..www.truemfg.com ... True Food Service Equipment, Inc. True Food Service Equipment, Inc. IDL (INTEGRATED DOOR LIGHTING): Squeeze the plastic lampshield together and pull away from the door (See Image 3).
TRUE and upon proper installation and start-up in accordance with the instruction packet supplied with each TRUE unit. TRUE’s obligation under this warranty is limited to a period of one (1) year from the date of original installation or 15 months after shipment date from TRUE, whichever occurs first.
Need help?
Do you have a question about the TR1RRI-1S and is the answer not in the manual?
Questions and answers