SERVICE MANUAL LCD FLAT TELEVISION YA333 2005 LT-26X506 LT-32X506 /S/L BASIC CHASSIS TABLE OF CONTENTS PRECAUTION............... . . 1-3 SPECIFIC SERVICE INSTRUCTIONS .
Page 2
SPECIFICATION Contents Items LT-26X506 LT-32X506 Dimensions ( W × H × D ) 68.6 cm × 52.7 cm × 30.8 cm 82.0 cm × 60.4 cm × 30.8 cm (27-1/8" × 20-3/4" × 12-1/4") [Included stand] (32-3/8" × 23-7/8" × 12-1/4") [Included stand] 68.6 cm ×...
SECTION 1 PRECAUTION SAFETY PRECAUTIONS (1) The design of this product contains special hardware, (6) Isolation Check (Safety for Electrical Shock Hazard) many circuits and components specially for safety After re-assembling the product, always perform an purposes. For continued protection, no changes should be isolation check on the exposed metal parts of the cabinet made to the original design unless authorized in writing by (antenna terminals, video/audio input and output terminals,...
Page 4
INSTALLATION 1.2.1 HEAT DISSIPATION 1.2.3 INSTALLATION REQUIREMENTS If the heat dissipation vent behind this unit is blocked, cooling To ensure safety in an emergency such as an earthquake, and efficiency may deteriorate and temperature inside the unit will to prevent accidents, ensure that measures are taken to prevent rise.
Page 5
HANDLING LCD PANEL 1.3.1 PRECAUTIONS FOR TRANSPORTATION 1.3.2 OPTICAL FILTER (ON THE FRONT OF THE LCD PANEL) When transporting the unit, pressure exerted on the internal LCD (1) Avoid placing the unit under direct sunlight over a panel due to improper handling (such as tossing and dropping) prolonged period of time.
TV's front-firing speakers. VIDEO STATUS Expression of a favorite screen can be chosen by the VIDEO STATUS function. MAIN DIFFERENCE LIST Item LT-26X506/S LT-32X506/S LCD PANEL UNIT QLD0370-001 QLD0371-001 DIGITAL PWB QAL0754-001...
Page 7
2.3.1.2 PIXEL FAULT There are three pixel faults - bright fault , dark fault and flicker fault - that are respectively defined as follows. BRIGHT FAULT In this pixel fault, a cell that should not light originally is lighting on and off. For checking this pixel fault, input ALL BLACK SCREEN and find out the cell that is lighting on and off.
SECTION 3 DISASSEMBLY DISASSEMBLY PROCEDURE CAUTION AT DISASSEMBLY: • Make sure that the power cord is disconnected from the outlet. • Pay special attention not to break or damage the parts. • When removing each board, remove the connectors as required. Taking notes of the connecting points (connector numbers) makes service procedure manageable.
Page 9
STAND COVER BACK BRACKET JACK COVER STAND DIGITAL PWB POWER PWB SHIELD MAIN PWB REAR COVER POWER PWB POWER CORD TERMINAL BASE MAIN BASE INSULATOR TOP FRAME SPEAKER SPEAKER LCD PANEL UNIT LED PWB BOTTOM FRAME KEY PWB This exploded view shows the LT-26X506. FRONT PANEL LT-32X506 slightly differs from this exploded view, however it can be disassembled in the...
Page 10
MEMORY IC REPLACEMENT • This model uses the memory IC. • This memory IC stores data for proper operation of the video and drive circuits. • When replacing, be sure to use an IC containing this (initial value) data. 3.2.1 MEMORY IC REPLACEMENT PROCEDURE 1.
Page 11
3.2.3 SETTINGS OF FACTORY SHIPMENT 3.2.3.1 BUTTON OPERATION 3.2.3.2 REMOTE CONTROL DIRECT OPERATION Setting item Setting position Setting item Setting position POWER INPUT CHANNEL CABLE-02 CHANNEL CABLE-02 VOLUME VOLUME DISPLAY ASPECT NTSC PANORAMA HD / ATSC FULL SLEEP TIMER VIDEO STATUS DYNAMIC HYPER SURROUND 3.2.3.3...
Page 12
REPLACEMENT OF CHIP COMPONENT 3.3.1 CAUTIONS (1) Avoid heating for more than 3 seconds. (2) Do not rub the electrodes and the resist parts of the pattern. (3) When removing a chip part, melt the solder adequately. (4) Do not reuse a chip part after removing it. 3.3.2 SOLDERING IRON (1) Use a high insulation soldering iron with a thin pointed end of it.
SECTION 4 ADJUSTMENT ADJUSTMENT PREPARATION ADJUSTMENT ITEMS (1) There are 2 ways of adjusting this TV : One is with the VIDEO CIRCUIT REMOTE CONTROL UNIT and the other is the • WHITE BALANCE (HIGH LIGHT) adjustment conventional method using adjustment parts and components.
Page 14
4.5.3 DESCRIPTION STATUS DISPLAY 4.5.4 CHANGE AND MEMORY OF SETTING VALUE ADJUSTMENT MODE SELECTION OF SETTING ITEM • [CH+] / [CH-] key. SETTINGITEM No. SETTING ITEM SETTING VALUE (DATA) Change the setting items up/ down. CHANGE OF SETTING VALUE (DATA) •...
Page 15
INITIAL SETTING VALUES IN THE SERVICE MODE • Perform fine-tuning based on the "initial values" using the remote control when in the Service mode. • The "initial values" serve only as an indication rough standard and therefore the values with which optimal display can be achieved may be different from the default values.
ADJUSTMENT PROCEDURE 4.7.1 VIDEO CIRCUIT Measuring Item Test point Adjustment part Description instrument WHITE Remote [1.ADJUST] (1) Receive a NTSC 75% all white signal. BALANCE control unit S001: R DRIVE (Red drive) (2) Set "VIDEO STATUS" to "STANDARD". (HIGHLIGHT) S002: G DRIVE (Green drive) (3) Set "ASPECT"...
Page 17
Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY DISPLAY CATEGORY 12, 3-chome, Moriya-cho, Kanagawa-ku, Yokohama-city, Kanagawa-prefecture, 221-8528, Japan (No.YA333) Printed in Japan...
Page 19
LT-26X506 , LT-32X506 STANDARD CIRCUIT DIAGRAM NOTE ON USING CIRCUIT DIAGRAMS 1.SAFETY Type No indication : Ceramic capacitor The components identified by the symbol and shading are : Metalized mylar capacitor critical for safety. For continued safety replace safety ciritical : Polypropylene capacitor components only with manufactures recommended parts.
Page 20
CIRCUIT DIAGRAMS MAIN PWB CIRCUIT DIAGRAM ........................ 2-7 DIGITAL SIGNAL PWB CIRCUIT DIAGRAM ................... 2-17 POWER PWB CIRCUIT DIAGRAM [LT-26X506/S] ................... 2-25 POWER PWB CIRCUIT DIAGRAM [LT-32X506/S] ................... 2-31 LED BOARD PWB CIRCUIT DIAGRAM ....................2-37 KEY PWB CIRCUIT DIAGRAM ......................... 2-38 PATTERN DIAGRAMS MAIN PWB PWB PATTERN ........................
WIRING DIAGRAM LCD PANEL UNIT LCD PANEL UNIT CP1802 CP708 CP701 J207 CP705 CP1801 250V/5A POWER PWB KEY PWB POWER CORD MAIN PW CP706 LED PWB 2-3(No.YA333)
Page 22
DIGITAL SIGNAL PWB CP1012 LCD PANEL UNIT CP1008 CP1005 CP1009 CP1014 CW1002 CW703 CW501 CW502 CP602 CP601 TU401 U/V TUNER N PWB SPEAKER (R) SPEAKER (L) (No.YA333)2-4...
Page 26
MAIN PWB ASS'Y (1/5) QAL0753-001 (No.YA333)2-8...
Page 27
MAIN PWB CIRCUIT DIAGRAM (2/5) SHEET2 TO OPE KEY PWB ASS'Y J207 SHEET2 (SHEET17) SHEET1 SHEET2 SHEET2 SHEET5 SHEET2 SHEET5 SHEET2 SHEET1,2,4,5 TO DIGITAL 5V_SDA 5V_SCL 7 DIGITAL SIGNAL PWB ASS'Y(1/4) SHEET2 CP1005 (SHEET6) PGCLK PGEN AV-RST D-TIN SHEET2 HP-DET CCFL PNL-PWR D-DIMMER...
Page 28
TO LED LED PWB ASS'Y CP706 (SHEET16) MAIN PWB ASS'Y (2/5) QAL0753-001 FOR ENGINEERING ONLY FLASH WRITE BUS MONITOR SHEET5 SHEET5 SHEET5 SHEET1 PEX0 SHEET5 PEX7 PEX1 SHEET1 PEX6 PEX2 PEX5 PEX3 PEX4 (No.YA333)2-10...
Page 29
MAIN PWB CIRCUIT DIAGRAM (3/5) SHEET3 P12V TO POWER M5V0 STB5V SHEET2 TV-PWR STB-SW POWER PWB ASS'Y(3/3) (SHEET12,15) TO POWER SGND POWER PWB ASS'Y(3/3) (SHEET12,15) SGND MAIN PWB ASS'Y (3/5) QAL0753-001 2-11(No.YA333)
Page 30
TO DIGITAL P12V P5V0 P3V3 P3V3 LCD5V0 M5V0 DIGITAL SIGNAL PWB ASS'Y(1/4) CP1008 (SHEET6) P5V0 P30V Dr-C SW-C SW-E Comp P9V0 TU5V0 (No.YA333)2-12...
DIGITAL SIGNAL PWB CIRCUIT DIAGRAM (1/4) SHEET6 MAIN PWB ASS'Y(3/5) CW1002 PNL-PWR (SHEET3) C-IN C-IN MAIN PWB R-IN R-IN ASS'Y(5/5) SHEET7 G-IN G-IN CW502 B-IN B-IN YS-IN1 (SHEET5) YS-IN1 SHEET8 HD-IN SHEET7 VD-IN SHEET6 LVDS-PWR LVDS-PWR MAIN PWB CVBS CVBS ASS'Y(5/5) Y-IN SHEET7...
Page 36
SCB5 SCHS SCVS SCEN SCR6 TX0- TX0+ TX1- TX1+ TX2- TX2+ TXC- DS-PWR TXC+ TX3- TX3+ LVDS-OPTION NOTE : Refer to the part list for the part number of IC1019. DIGITAL SIGNAL PWB ASS'Y (1/4) QAL0754-001 [LT-26X506/S] QAL0755-001 [LT-32X506/S] (No.YA333)2-18...
VOLTAGE CHARTS <MAIN PWB> <DIGITAL SIGNAL PWB> <XXXXX> MODE MODE MODE MODE MODE MODE MODE MODE MODE MODE MODE DC ( V ) DC ( V ) DC ( V ) DC ( V ) DC ( V ) DC ( V ) DC ( V ) DC ( V ) DC ( V )
Page 76
Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY DISPLAY CATEGORY 12, 3-chome, Moriya-cho, Kanagawa-ku, Yokohama-city, Kanagawa-prefecture, 221-8528, Japan (No.YA333) Printed in Japan...
Page 77
PARTS LIST CAUTION The parts identified by the symbol are important for the safety . Whenever replacing these parts, be sure to use specified ones to secure the safety. The parts not indicated in this Parts List and those which are filled with lines --- in the Parts No. columns will not be supplied. P.W.
Page 78
USING P.W. BOARD & REMOTE CONTROL UNIT ....................3-2 EXPLODED VIEW PARTS LIST ..........................3-3 EXPLODED VIEW ............................... 3-4 PRINTED WIRING BOARD PARTS LIST [LT-26X506/S] ..................3-5 MAIN P.W. BOARD ASS'Y (QAL0753-001) ...................... 3-5 DIGITAL SIGNAL P.W. BOARD ASS'Y (QAL0754-001) ................... 3-8 POWER P.W.
Part No. Part Name Description Local LC12405-001A-A TERMINAL COVER CM48269-001-A NOM LABEL LC32830-001A-A RATING LABEL GQ20001-001A-A RATING LABEL LC12404-001A-A REAR COVER LT-26X506/S LC12439-001A-A REAR COVER LT-32X506/S QYSBSF4012ZA TAP SCREW M4 x 12mm(x8) LC42063-001A SCREW LC42063-001A SCREW (x2) LC42296-001B-C STAND ASSY...
EXPLODED VIEW 109B 109A BACK BRACKET POWER PWB SHIELD MAIN BASE INSULATOR TOP FRAME BOTTOM FRAME This exploded view shows the LT-26X506. LT-32X506 has almost similar parts locations. 3-4(No.YA333)
PRINTED WIRING BOARD PARTS LIST [LT-26X506 MAIN P.W. BOARD ASS'Y (QAL0753-001) Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal C408 QETL1CM-107 E CAPACITOR 100uF 16V M C409 QETL1HM-106 E CAPACITOR 10uF 50V M IC401 AN5832SA C410 QETL1HM-106...
Page 82
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal C625 QETL1CM-476 E CAPACITOR 47uF 16V M R402 NRSA63J-221X MG RESISTOR 220Ω 1/16W J C626 QETL1HM-106 E CAPACITOR 10uF 50V M R403 NRSA63J-101X MG RESISTOR 100Ω 1/16W J C627 QETL1HM-106 E CAPACITOR...
Page 83
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal R624 NRSA63J-152X MG RESISTOR 1.5kΩ 1/16W J R785 NRSA63J-392X MG RESISTOR 3.9kΩ 1/16W J R625 CFS1/4CT52A472J MG RESISTOR 4.7kΩ 1/4W J R786 NRSA63J-471X MG RESISTOR 470Ω 1/16W J R626 CFS1/4CT52A472J MG RESISTOR...
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal J505 YKC21-5855N JACK AUDIO IN C1010 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K CFS1/4CT52A220J MG RESISTOR 22Ω 1/4W J C1011 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K JP501 NRSA63J-0R0X MG RESISTOR 0Ω...
Page 85
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal C1131 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K C1288 MVA16VC22MD55 E CAPACITOR 22uF 16V M C1132 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K C1289 MVA16VC22MD55 E CAPACITOR 22uF 16V M C1133 C1608JF1H104ZT C CAPACITOR...
Page 86
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal R1064 NRSA63J-101X MG RESISTOR 100Ω 1/16W J R1190 NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J R1065 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R1191 NRSA63J-100X MG RESISTOR 10Ω 1/16W J R1066 NRSA63J-101X MG RESISTOR...
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal T2007-IC222J C RESISTOR 2.2KΩ J T2901-JC008A FERRITE BEAD T2007-JC470J C RESISTOR 47Ω J T2901-JC008A FERRITE BEAD T2007-IC103J C RESISTOR 10KΩ J T2901-IC009A FERRITE BEAD T2007-IC102J C RESISTOR 1KΩ...
PRINTED WIRING BOARD PARTS LIST [LT-32X506 MAIN P.W. BOARD ASS'Y (QAL0753-001) Ref No. Part No. Part Name DescriptionLocal REFER TO PARTS LIST IN PAGE 3-5 FOR THIS P.W. BOARD. C1027 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K C1028 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K C1029 C1608JF1H104ZT...
Page 90
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal C1144 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K C1304 MVA10VC47ME55 E CAPACITOR 47uF 10V M C1145 C1608JF1H104ZT C CAPACITOR 0.1uF 50V K C1305 MVA10VC47ME55 E CAPACITOR 47uF 10V M C1146 C1608JF1H104ZT C CAPACITOR...
Page 91
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal R1077 NRSA63J-680X MG RESISTOR 68Ω 1/16W J R1215 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J R1078 NRSA63J-680X MG RESISTOR 68Ω 1/16W J R1216 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R1079 NRSA63J-680X MG RESISTOR...
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal CW1020 WFG05A195 CONNECTOR T2203-FC104E C CAPACITOR 0.1uF 50V K FB1001 NQR0155-003X FERRITE CORE T2203-FC104E C CAPACITOR 0.1uF 50V K FB1005 NQR0155-003X FERRITE CORE T2201-PB103A C CAPACITOR 0.01uF 1KV Z FB1006 NQR0155-003X...
Ref No. Part No. Part Name DescriptionLocal Ref No. Part No. Part Name DescriptionLocal T2007-IC103J C RESISTOR 10KΩ J T2007-IC273J C RESISTOR 27KΩ J TV49-00005A CHOKE BAR 5.5uH T2003-ET220A MF RESISTOR 22Ω 3W J TV09-00004A CHOKE BAR 5.0uH T2007-JC122J C RESISTOR 1.2KΩ...
PACKING PACKING PARTS LIST Ref.No. Part No. Part Name Description Local LC10181-047A-A PACKING CASE LT-26X506/S LC10181-048A-A PACKING CASE LT-32X506/S LC12417-001A-A CUSION ASSY 4pcs in 1set LT-26X506/S LC12421-001A-A CUSION ASSY 4pcs in 1set LT-32X506/S GG30097-003A-H POLY BAG LCT1831-001A-A INST SHEET English/French/Spanish...