Table of Contents
Advertisement
TABLE OF CONTENTS
Product Record Information . . . . . . . . . . . . . . 1
Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . 2
Preparing to use your Charcoal Grill . . . . . . . . 3
Grilling Guide - Gas Grill . . . . . . . . . . . . . . . . . 4
Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . .6
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . 9
Parts List. . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Parts Diagram. . . . . . . . . . . . . . . . . . . . . . . . .29
Assembly Steps . . . . . . . . . . . . . . . . . . . . 30-45
Troubleshooting. . . . . . . . . . . . . . . . . . . . . 46-47
Registration Card . . . . . . . . . . . . . . . . . . . . . . 55
Safety Symbols
The symbols and boxes shown below explain what each
heading means. Read and follow all of the messages found
throughout the manual.
CAUTION
CAUTION: Indicates a potentially hazardous situation
or unsafe practice which, if not avoided, may result in
minor or moderate injury.
WARNING
WARNING: Indicates a potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
DANGER
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
DANGER
If you smell gas:
1. Shut off gas to the appliance
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of
this or any other appliance.
THIS GRILL IS FOR OUTDOOR
USE ONLY.
WARNING
Failure to follow all manufacturer's instructions could
result in serious personal injury and/or property
damage.
CAUTION
For residential use only. Do not use for
commercial cooking.
CAUTION
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
CAUTION
Some parts may contain sharp edges. Wear
protective gloves if necessary.
WARNING
CALIFORNIA PROPOSITION 65
1. Combustible by-products produced when using
this product contains chemicals known to the State
of California to cause cancer, birth defects, or other
reproductive harm.
2. This product contains chemicals, including lead
and lead compounds, known to the State of
California to cause cancer, birth defects or other
reproductive harm.
Wash your hands after handling this product.
WARNING
Do not attempt to repair or alter the
hose/valve/regulator for any "assumed" defect.
Any modification to this assembly will void your
warranty and create the risk of a gas leak and fire.
Use only authorized replacement parts supplied by
manufacturer.
WARNING
Most surfaces on this unit are hot when in use. Use
extreme caution. Keep others away from unit Always
wear protective clothing to prevent injury.
Keep children and pets away.
Do not move this unit during operation.
Never substitute gasoline, kerosene or alcohol for
charcoal starter. In some states, the use of charcoal
starter is prohibited by law. In this case, paraffin-based
starter cubes can be substituted for charcoal starter.
Never use charcoal starter fluid with an electric starter.
WARNING
After a charcoal fire appears extinguished,
unconsumed embers can retain heat for up to 24
hours, and if exposed to fresh air, can burst into
flame unexpectedly. Any such embers outside the
firebox of the grill pose a fire hazard and can ignite
combustible surfaces such as wooden decks.
2
CAUTION
Grease Fires
• Putting out grease fires by closing the lid is
not possible. Grills are well ventilated for
safety reasons.
• Do not use water on a grease fire. Personal injury
may result. If a grease fire develops, turn knobs
and LP tank off.
• If grill has not been regularly cleaned, a grease fire
can occur that may damage the product. Pay close
attention while preheating or burning off food
residue to insure that a grease fire does not
develop. Follow instructions on General Grill
Cleaning and Cleaning The Burner Assembly to
prevent grease fires.
•
The best way to prevent grease fires is
regular cleaning of the grill.
CAUTION
Using pots larger than 6 quarts in capacity could
exceed weight limit of the side burner shelf or side
shelf, resulting in failure of grill cart components.
DANGER
• NEVER store a spare LP cylinder under or near
the appliance or in an enclosed area.
• Never fill a cylinder beyond 80% full.
•
An over filled or improperly stored cylinder is a
hazard due to possible gas release from the safety
relief valve. This could cause an intense fire with
risk of property damage, serious injury or death.
•
If you see, smell or hear gas escaping,
immediately get away from the LP
cylinder/appliance and call your fire department.
CAUTION
THIS UNIT IS HEAVY! DO NOT attempt to
assemble without a helper.
Advertisement
Chapters
Table of Contents
