Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Sony KF-42SX300
Summary of Contents for Sony KF-42SX300
- Page 1 KF-42SX300 RM-906 SERVICE MANUAL LE-4A CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KF-42SX300 KF-42SX300U RM-906 SCC-R01C-A RM-906 SCC-R03E-A KF-42SX300K RM-906 OIRT SCC-R02D-A KF-42SX300 RM-906 LCD PROJECTION TV - 1 -...
-
Page 2: Table Of Contents
THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE 4-3. Test Test Mode ........... PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN WARNING !! SUPPLEMENTS PUBLISHED BY SONY. -
Page 3: Caution
Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -... -
Page 4: Specifications
KF-42SX300 RM-906 y l l . s l < / . s l . s l . s l . s l n i l e i l . s l a j i . o i n i l... -
Page 5: Connectors
KF-42SX300 RM-906 21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms... - Page 6 KF-42SX300 RM-906 SECTION 1 SELF DIAGNOSIS FUNCTION LE-4A Self Diagnostic Software The identification of errors within the LE-4A chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.
-
Page 7: General
KF-42SX300 RM-906 SECTION 2 GENERAL – 7 –... - Page 8 KF-42SX300 RM-906 – 8 –...
- Page 9 KF-42SX300 RM-906 – 9 –...
- Page 10 KF-42SX300 RM-906 – 10 –...
- Page 11 KF-42SX300 RM-906 – 11 –...
- Page 12 KF-42SX300 RM-906 – 12 –...
- Page 13 KF-42SX300 RM-906 – 13 –...
- Page 14 KF-42SX300 RM-906 – 14 –...
- Page 15 KF-42SX300 RM-906 – 15 –...
- Page 16 KF-42SX300 RM-906 – 16 –...
- Page 17 KF-42SX300 RM-906 – 17 –...
- Page 18 KF-42SX300 RM-906 – 18 –...
- Page 19 KF-42SX300 RM-906 – 19 –...
- Page 20 KF-42SX300 RM-906 – 20 –...
-
Page 21: Disassembly
KF-42SX300 RM-906 SECTION 3 DISASSEMBLY 3-1. REAR COVER REMOVAL 3-2. CENTER PILLAR REMOVAL Rear cover Three screws (+BVTP 4x16) Three Center fasten tags pillar Two screws (+PSW 3x8) Two screws Eleven screws (+BVTP 4x16) (+BVTP 4x16) 3-3. SERVICE POSITION 3-4. CHASSIS, OPTICAL UNIT, DC FAN REMOVAL... -
Page 22: Power Block Removal
KF-42SX300 RM-906 3-5. POWER BLOCK REMOVAL 3-6. H1 BOARD REMOVAL Power supply block Screen mirror block assembly Screw Two screws (+BVTP 3x12) (+PWH 4x16) H1 button Two screws (+BVTP 4x16) H1 bracket cap Screw Connector H1 board H1 bracket (+BVTP 3x12) Two connectors 3-7. -
Page 23: A Board Removal
KF-42SX300 RM-906 3-9. A BOARD REMOVAL 3-10. G BOARD REMOVAL Nine connectors G bracket Two fasten tags Fasten tag 1 Two screws (+BVTP 4 X 16) Connector Two claws A board 3 G board 1 Screw (+BVTP 4 X 16) 3-11. -
Page 24: Front Cover Removal
KF-42SX300 RM-906 3-13. FRONT COVER REMOVAL 3-14. CONTROL PANEL REMOVAL 1 Two screws (+BVTP 4 X 16) 1 Four strikes 2 Control panel block assembly 2 Front cover L 1 Two screws (+BVTP 4 X 16) 2 Front cover R 1 Four strikes 3-15. -
Page 25: Mirror Cover Block Assembly Removal
KF-42SX300 RM-906 3-16. MIRROR COVER BLOCK ASSEMBLY REMOVAL Mirror cover block assembly 1 Six screws 1 Three screws (+BVTP 4 X 16) (+BVTP 4 X 16) 1 Seven screws (+BVTP 4 X 16) 3-17. CONTRAST SCREEN, DIFFUSION PLATE REMOVAL 2 Screen holder... -
Page 26: Woofer Block Assembly Removal
KF-42SX300 RM-906 3-18. WOOFER BLOCK ASSEMBLY REMOVAL 1 Two screws (+BVTP 4 X 16) 2 Woofer block assembly 3-19. SPEAKER REMOVAL 3-20. MIRROR REMOVAL 1 Two screws (+BVTP 4 X 16) 1 Two screws (+BVTP 4 X 16) 3 Speaker (13 X 7cm) -
Page 27: Electrical Adjustments
KF-42SX300 RM-906 SECTION 4 ELECTRICAL ADJUSTMENTS 4-1. Adjustments with Commander 4-1-2. Programming the Remote Commander for Operation in Service Mode Service adjustments to this model can be performed using the Press the VCR/TV/DVD button until the supplied remote Commander RM-906. - Page 28 KF-42SX300 RM-906 c t i t l i – 28 –...
-
Page 29: Operation Method For Adjustments
KF-42SX300 RM-906 4-1-5. Operation Method for Adjustments 4-3. TEST-TEST MODE Is available by programming the Remote Commander for operation in Service Mode [ As shown on Page 27 ] then pressing the VIDEO TV STANDBY VIDEO STANDBY button twice, OSD 'TT' appears. The functions describe below are available by selectingthe two numbers. -
Page 30: Block Diagram (1)
5-1. BLOCK DIAGRAMS (1) IC2000 IC4401 TUNER SOUND IC2400 IR/RECEIVER CN4404 TU1100 PROCESSOR AUDIO AMP WOOFER CN2400 SIRCS WOOFER SP TO WOOFER STBY 5V CN4302 IC2500 HEADPHONE R OUT TO A BOARD FM/AM AUDIO AMP CN2003 CN0001 KEY 2 HEADPHONE L OUT J4302 SPEAKERS TO A BOARD... -
Page 31: Block Diagram (2)
5-1. BLOCK DIAGRAMS (2) CN3400 R3404 MICRO, 3D COMB R3407 TO C BOARD R3411 CN3004 R3414 CN3401 IC0001 MICRO CONTROLLER TO C BOARD CN3004 & H SYNC CN3007 OCP-OVP P2.15 V SYNC OCP-FLAG F-OSD F-OSD BLANK/ P2.14 RS OUT EPG-MODE P2.11 XTAL 1 CN3402... -
Page 32: Block Diagram (3)
5-1. BLOCK DIAGRAMS (3) IC2501 SCANRATE, BACKEND, B DRIVE CN2551 DIGITAL GAMMA, LCD DRIVERS D-A 0 SID OUT Q2502 P SIG-OB P SIG-OB SID OUT Q2504 D-A 1 B-SIG 01 B-SIG 01 SIG-B6 SH OUT 1 D-A 2 B-SIG 02 B-SIG 02 SIG-B5 SH OUT 2... -
Page 33: Block Diagram (4)
5-1. BLOCK DIAGRAMS (4) 5-2. CIRCUIT BOARD LOCATION Reference Information RESISTOR : METAL FILM : SOLID FPRD : NON FLAMMABLE CARBON FUSE : NON FLAMMABLE FUSIBLE : NON FLAMMABLE METAL OXIDE : NON FLAMMABLE CEMENT : NON FLAMMABLE WIREWOUND CVM Board IC3800 S1 Board CN3801... -
Page 34: A Board Schematic Diagram
B-#SSLE4A<...>-A..-42SX300 150K 0.47 8.2K 0.47 5.6K 5.6K HP OUT 1/3 TUNER, AUDIO, REGULATORS TO J BOARD CN3804 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ A Board Schematic Diagram [ Tuner, Audio, Regulators ] Page 1/3 ~ - 34 -... - Page 35 B-#SSLE4A<...>-A..-42SX300 TO H1 BOARD CN4404 TO H2 BOARD BTF-EF411 CN4401 ~ A Board Schematic Diagram [ Tuner, Audio, Regulators ] Page 2/3 ~ - 35 -...
- Page 36 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL B-#SSLE4A<...>-A..-42SX300 ~ A Board Schematic Diagram [ Tuner, Audio, Regulators ] Page 3/3 ~ - 36 -...
-
Page 37: A Printed Wiring Board
~ A Printed Wiring Board Conductor Side ~ ~ A Board Semiconductor Location Table ~ ~ A Board Semiconductor Voltage Table ~ ~ A Board IC Voltage Table ~ - 37 -... -
Page 38: B Board Schematic Diagram
B-#SSLE4A<...>-B..-42SX300 COMB FILTER MEMORY 3D COMB FILTER CHROMA DECODER 1/3 MICRO, 3D COMB COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ B Board Schematic Diagram [ Micro, 3D Comb ] Page 1/3 ~ - 38 -... - Page 39 TO C BOARD CN3004 CN3004 & CN3007 B-#SSLE4A<...>-B..-42SX300 2.7K 8.2K 100K CN5201 ~ B Board Schematic Diagram [ Micro, 3D Comb ] Page 2/3 ~ - 39 -...
- Page 40 B-#SSLE4A<...>-42SX300 RESET M24C32-WMN6T(A) DEF 5V RESET CMOS SDRAM MICRO CONTROLLER M27V160-100K1-LE4001 ~ B Board Schematic Diagram [ Micro, 3D Comb ] Page 3/3 ~ - 40 -...
-
Page 41: B Printed Wiring Board
~ B Printed Wiring Board Conductor Side A ~ ~ B Board Semiconductor Location Table (A Side) ~ ~ B Printed Wiring Board Conductor Side B ~ ~ B Board Semiconductor Location Table (B Side) ~ - 41 -... -
Page 42: C Board Schematic Diagram
B-#SSLE4A<...>-C..-42SX300 1/4 SCANRATE, BACKEND, DIGITAL GAMMA, LCD DRIVERS DISPLAY PROCESSOR AND SCALER 12-STAGE BINARY COUNTER VOLTAGE DETECTOR 6.3V COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 1/4 ~ - 42 -... - Page 43 B-#SSLE4A<...>-C..-42SX300 OCTAL BUS BUFFER 12C DIGITAL TEMP SENSOR ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 2/4 ~ - 43 -...
- Page 44 B-#SSLE4A<...>-C..-42SX300 PICTURE TUBE (G) PICTURE TUBE (B) +5V REGULATOR PICTURE TUBE (R) COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 3/4 ~ - 44 -...
- Page 45 B-#SSLE4A<...>-C..-42SX300 ANALOG MUX/DEMUX COLOUR DECODER & SCANRATE CONVERTER TO J BOARD CN3806 & CN3807 ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 4/4 ~ - 45 -...
-
Page 46: C Printed Wiring Board
~ C Printed Wiring Board Conductor Side A ~ ~ C Board Location Table (A Side) ~ - 46 -... - Page 47 ~ C Board Location Table (B Side) ~ ~ C Printed Wiring Board Conductor Side B ~ - 47 -...
-
Page 48: J Board Schematic Diagram
J..-42SX300 R2808 470k SC1-OUT-R R3862 C3842 C3845 L3814 R2877 C2804 R2804 R2800 1/10W C2810 CN3808 0.022 D2830 R_PC CHIP R2851 UDZS-TE17-9.1B D2800 R2801 D3822 Q3856 UDZS-TE17-9.1B SC1-IN-R C3846 MSD601-RST1 UDZS-5.6B C2805 R2809 C2808 R3852 D2801 R3865 1000p 470k G_PC 2.2k R2802 C2801 UDZS-TE17-9.1B... -
Page 49: J Printed Wiring Board
~ J Printed Wiring Board Conductor Side A ~ ~ J Board Location Table (A Side) ~ ~ J Board IC Voltage Table ~ ~ J Board Location Table (B Side) ~ ~ J Printed Wiring Board Conductor Side B ~ - 49 -... -
Page 50: G Board Schematic Diagram
TO A BOARD CN6900 D1NL20U-TR B-#SSLE4A<...>-G..-42SX300 ~ G Board Schematic Diagram [ Power Supply ] ~ - 50 -... -
Page 51: G Printed Wiring Board
~ G Printed Wiring Board Conductor Side ~ ~ G Board IC Voltage Table ~ ~ G Board Semiconductor Voltage Table ~ ~ H1 Printed Wiring Board Conductor Side ~ ~ H2 Printed Wiring Board Conductor Side ~ ~ H3 Printed Wiring Board Conductor Side ~ ~ T Printed Wiring Board Conductor Side ~ Note : Portions of the circuit contained within... -
Page 52: H1 Schematic Diagram
~ H1 Board Schematic Diagram [ User Key, Sircs ] ~ ~ H2 Board Schematic Diagram [ LED Indicators ] ~ B-#SSLE4A<...>-H1.-42SX300 H2.-42SX300 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL R4404 R4405 1/10W 1/10W C4404 R4411 Q4403 2SC1623-L5L6 1/10W Q4405... -
Page 53: Semiconductors
5-4. SEMICONDUCTORS 1E3-TB CXD3804R-T6 PQ1CG2032FZ CATHODE D1N20R D1NS4 ERA11-08 UF4005PKG23 ANODE 1SS355TE-17 MA113-(TX) UDZ-TE-1713B UDZSTE-173.6B ANODE UDZSTE-179.1B CATHODE PST9143NL 2SA1023AK-T146-R 2SA1162-G D10SC4M 1 2 3 4 5 2SC1623-L5L6 D10SC6M 2SD2114K D10SC6MR DTA114EKA-T146 DTC114EK RD5.6M-B2 RD5.6M-B3 2SK2663 L7805CV/LSY STP5NK40Z(033Y) S-80743AL-47-S ST2310DHI S80727-SN-DQ-T1 BA033T LM75C1MX-5... - Page 54 MC74LVX8053 P-MQFP-128 MQFP144 PQ20VZ-U LM75 M27V160 L7800 SI8050S SI8033S - 54 -...
-
Page 55: Ic Block Diagrams
5-5 IC BLOCK DIAGRAMS A BOARD IC2500 TDA7269 A BOARD IC6201 BA033T REFERENCE VOLTAGE - 55 -... - Page 56 A BOARD IC2000 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC1601 MCZ3001D Remote DVLD Internal Driver Sel=34v ref 5v Reg. 10v 15v/8v Level Shift Vsense Control Logic Latch Centre Timer - 56 -...
-
Page 57: Exploded Views
KF-42SX300 SECTION 6 RM-906 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for service. routine service. Some delay should... -
Page 58: Cabinet Block
KF-42SX300 RM-906 6-2. CABINET BLOCK 7-685-658-79 SCREW +BVTP 3X12 TYPE 2 IT-3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK 4-098-512-01 DOOR, H3 *A-1405-811-A T BOARD COMPLETE 4-094-757-01 SPRING, PLATE A-1606-075-A LAMP BLOCK ASSY *A-1405-806-A H3 BOARD, COMPLETE 4-094-747-11 DOOR, LAMP... -
Page 59: Main Bracket Block
KF-42SX300 RM-906 6-3. MAIN BRACKET BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *4-096-934-11 BRACKET, MAIN 7-685-663-79 SCREW +BVTP 4X16 TYPE2 IT-3... -
Page 60: Picture Tube Block
KF-42SX300 RM-906 6-4. PICTURE TUBE BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK - 60 -... -
Page 61: Electrical Parts List
SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page B BOARD COMPLETE Parts List : ....................62 A BOARD COMPLETE Parts List : ....................67 J BOARD COMPLETE Parts List : ....................72 T BOARD COMPLETE Parts List : .................... - Page 62 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1053-581-A B Board Complete C3105 1-127-715-91 CERAMIC CHIP 0.22UF C3106 1-127-715-91 CERAMIC CHIP 0.22UF 1-785-449-12 SOCKET, IC C3107 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C3108 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V <...
- Page 63 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3324 1-164-156-11 CERAMIC CHIP 0.1UF C3836 1-164-156-11 CERAMIC CHIP 0.1UF C3402 1-126-947-11 ELECT 47UF 20.00% 35V C3837 1-164-156-11 CERAMIC CHIP 0.1UF C3403 1-164-156-11 CERAMIC CHIP 0.1UF C3838 1-164-156-11 CERAMIC CHIP 0.1UF C3405 1-164-156-11 CERAMIC CHIP 0.1UF C3839...
- Page 64 D1 B REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK CN3400 * 1-564-524-11 PLUG, CONNECTOR 9P L3801 1-414-928-21 INDUCTOR CN3401 * 1-764-643-21 PIN, CONNECTOR (SMD) 11P L3802 1-414-928-21 INDUCTOR CN3402 * 1-564-519-11 PLUG, CONNECTOR 4P L3803 1-414-928-21 INDUCTOR L3805 1-414-928-21 INDUCTOR <...
- Page 65 F4 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK JR3406 1-216-864-11 SHORT CHIP R0056 1-216-809-11 METAL CHIP 1/10W JR3408 1-216-864-11 SHORT CHIP R0057 1-216-809-11 METAL CHIP 1/10W JR3409 1-216-864-11 SHORT CHIP R0059 1-216-809-11 METAL CHIP 1/10W R0060 1-216-809-11 METAL CHIP 1/10W R0001 1-216-833-11...
- Page 66 D2 B REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3241 1-216-864-11 SHORT CHIP R3825 1-216-817-11 METAL CHIP 1/10W R3242 1-216-864-11 SHORT CHIP R3826 1-216-817-11 METAL CHIP 1/10W R3270 1-216-864-11 SHORT CHIP R3829 1-216-817-11 METAL CHIP 1/10W R3271 1-216-864-11 SHORT CHIP R3830 1-216-841-11 METAL CHIP...
- Page 67 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3894 1-216-817-11 METAL CHIP 1/10W RB0044 1-233-576-11 RES, CHIP NETWORK 100 (3216) R5501 1-216-821-11 METAL CHIP 1/10W RB0045 1-233-576-11 RES, CHIP NETWORK 100 (3216) R5502 1-216-809-11 METAL CHIP 1/10W RB0050 1-233-576-11 RES, CHIP NETWORK 100 (3216) R5504 1-216-809-11...
- Page 68 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2009 1-127-715-91 CERAMIC CHIP 0.22UF C2512 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C2010 1-127-715-91 CERAMIC CHIP 0.22UF C2513 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C2011 1-162-966-11 CERAMIC CHIP 0.0022UF 10.00% 50V C2514 1-107-715-11 ELECT 22UF...
- Page 69 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C6260 1-164-156-11 CERAMIC CHIP 0.1UF D6205 8-719-083-57 DIODE UDZSTE-173.6B C6262 1-126-933-11 ELECT 100UF 20.00% 16V D6206 8-719-081-97 DIODE MMDL914T1 C6263 1-164-156-11 CERAMIC CHIP 0.1UF D6207 8-719-081-97 DIODE MMDL914T1 C6264 1-164-156-11 CERAMIC CHIP 0.1UF D6208 8-719-081-97 DIODE MMDL914T1...
- Page 70 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK L2222 1-535-303-00 LEAD, JUMPER (5.0MM) Q6208 8-729-010-29 TRANSISTOR MSD601-RST1 L2400 1-416-857-11 INDUCTOR 65UH Q6209 8-729-120-28 TRANSISTOR 2SC1623-L5L6 L2401 1-535-303-00 LEAD, JUMPER (5.0MM) Q8001 8-729-010-29 TRANSISTOR MSD601-RST1 L2402 1-535-303-00 LEAD, JUMPER (5.0MM) Q8309 8-729-120-28 TRANSISTOR 2SC1623-L5L6 L2500...
- Page 71 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2017 1-216-809-11 METAL CHIP 1/10W R6218 1-216-833-11 METAL CHIP 1/10W R2018 1-216-809-11 METAL CHIP 1/10W R6221 1-216-834-11 METAL CHIP 1/10W R2019 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R6223 1-216-841-11 METAL CHIP 1/10W R2021 1-216-833-11 METAL CHIP...
- Page 72 H5 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8432 1-216-837-11 METAL CHIP 1/10W C2833 1-162-964-11 CERAMIC CHIP 0.001UF 10.00% 50V R8433 1-216-837-11 METAL CHIP 1/10W C2834 1-164-227-11 CERAMIC CHIP 0.022UF 10.00% 25V R8434 1-216-825-11 METAL CHIP 2.2K 5% 1/10W C2835 1-162-964-11...
- Page 73 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > D3815 8-719-069-55 DIODE UDZSTE-175.6B D3816 8-719-069-55 DIODE UDZSTE-175.6B CN3800 * 1-564-527-11 PLUG, CONNECTOR 12P D3817 8-719-069-55 DIODE UDZSTE-175.6B CN3801 1-695-549-11 SOCKET, PIN 21P D3818 8-719-069-55 DIODE UDZSTE-175.6B CN3802 1-695-549-11 SOCKET, PIN 21P D3819 8-719-069-55...
- Page 74 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK JR2818 1-216-295-91 SHORT CHIP R2853 1-216-864-11 SHORT CHIP JR3808 1-216-295-91 SHORT CHIP R2854 1-216-864-11 SHORT CHIP JR3809 1-216-295-91 SHORT CHIP R2855 1-216-864-11 SHORT CHIP JR3810 1-216-295-91 SHORT CHIP R2856 1-216-864-11 SHORT CHIP R2877 1-216-864-11 SHORT CHIP...
- Page 75 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1302-408-A G Board Complete R3856 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R3859 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R3861 1-216-864-11 SHORT CHIP 4-382-854-01 SCREW (M3X8), P, SW (+) R3862 1-216-841-11 METAL CHIP 1/10W R3863 1-216-841-11...
- Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1649 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V D1608 8-719-060-90 DIODE S2L60F C1650 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V D1609 8-719-063-73 DIODE D1NL20U-TR C1651 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V D1610 8-719-510-48 DIODE D1N20R C1652 1-126-964-11 ELECT...
- Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK L1603 1-412-523-41 INDUCTOR 6.8UH R1626 1-215-481-00 METAL 330K 1% 1/4W L1604 1-412-525-31 INDUCTOR 10UH R1627 1-215-859-00 METAL OXIDE L1607 1-412-525-31 INDUCTOR 10UH R1628 1-208-810-11 METAL CHIP 0.5% 1/10W L1608 1-412-525-31 INDUCTOR 10UH R1629 1-208-806-11 METAL CHIP...
- Page 78 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1405-807-A H1 Board Complete < THERMISTOR > TH1601 1-803-586-11 THERMISTOR, NTC < CAPACITOR > < VARISTOR > C4402 1-164-156-11 CERAMIC CHIP 0.1UF C4403 1-126-382-11 ELECT 100UF 20.00% 16V VD1602 £ 1-804-995-11 VARISTOR <...
- Page 79 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < TRANSISTOR > C2512 1-164-156-11 CERAMIC CHIP 0.1UF C2513 1-164-156-11 CERAMIC CHIP 0.1UF Q4401 8-729-027-43 TRANSISTOR DTC114EKA-T146 C2514 1-164-156-11 CERAMIC CHIP 0.1UF Q4402 8-729-027-23 TRANSISTOR DTA114EKA-T146 C2515 1-128-992-21 ELECT CHIP 47UF Q4403 8-729-120-28 TRANSISTOR 2SC1623-L5L6 C2516...
- Page 80 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2630 1-164-156-11 CERAMIC CHIP 0.1UF C3018 1-126-204-11 ELECT CHIP 47UF 20.00% 16V C2631 1-128-992-21 ELECT CHIP 47UF C3019 1-164-156-11 CERAMIC CHIP 0.1UF C2632 1-164-156-11 CERAMIC CHIP 0.1UF C3020 1-164-156-11 CERAMIC CHIP 0.1UF C2651 1-164-156-11 CERAMIC CHIP 0.1UF...
- Page 81 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3093 1-124-779-00 ELECT CHIP 10UF 20.00% 16V C3145 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V C3094 1-162-964-11 CERAMIC CHIP 0.001UF 10.00% 50V C4000 1-128-992-21 ELECT CHIP 47UF C3095 1-162-964-11 CERAMIC CHIP 0.001UF 10.00% 50V C4001 1-162-919-11 CERAMIC CHIP 22PF...
- Page 82 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C4078 1-124-779-00 ELECT CHIP 10UF 20.00% 16V FL3007 1-233-830-11 FERRITE 37UH C4079 1-124-779-00 ELECT CHIP 10UF 20.00% 16V FL3008 1-233-830-11 FERRITE 37UH C4080 1-164-156-11 CERAMIC CHIP 0.1UF C4086 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V <...
- Page 83 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK L3015 1-412-028-11 INDUCTOR 4.7UH Q4014 8-729-013-28 TRANSISTOR HN1B01FU-TE85R Q4015 8-729-013-28 TRANSISTOR HN1B01FU-TE85R L3016 1-412-029-11 INDUCTOR 10UH Q4016 8-729-422-33 TRANSISTOR 2SD601A-Q-TX L3017 1-412-029-11 INDUCTOR 10UH Q4017 8-729-422-33 TRANSISTOR 2SD601A-Q-TX L3018 1-412-029-11 INDUCTOR 10UH L3019 1-412-058-11 INDUCTOR...
- Page 84 J3 C REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2532 1-218-702-11 METAL CHIP 2.7K 0.5% 1/10W R2707 1-216-864-11 SHORT CHIP R2537 1-216-804-11 METAL CHIP 1/10W R2708 1-216-864-11 SHORT CHIP R2538 1-216-804-11 METAL CHIP 1/10W R2710 1-216-864-11 SHORT CHIP R2541 1-216-797-11 METAL CHIP 1/10W...
- Page 85 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3041 1-216-821-11 METAL CHIP 1/10W R3129 1-216-833-11 METAL CHIP 1/10W R3042 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R3130 1-216-833-11 METAL CHIP 1/10W R3043 1-216-864-11 SHORT CHIP R3131 1-216-833-11 METAL CHIP 1/10W R3044 1-216-864-11 SHORT CHIP R3132...
- Page 86 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R4023 1-216-809-11 METAL CHIP 1/10W RB2602 1-233-574-11 RES, CHIP NETWORK 10 (3216) R4024 1-216-814-11 METAL CHIP 1/10W RB2603 1-233-574-11 RES, CHIP NETWORK 10 (3216) R4025 1-216-814-11 METAL CHIP 1/10W RB2604 1-233-574-11 RES, CHIP NETWORK 10 (3216) R4026 1-216-864-11...
- Page 87 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK MISCELLANEOUS 1-825-580-11 LOUDSPEAKER (10CM) 1-544-857-11 SPEAKER (13X7CM) 8-598-535-20 FRONTEND BTF-EF411 1-419-965-11 COIL, CHOKE 27.0MMH £ 1-765-286-11 CORD, POWER 1-787-057-11 D.C. FAN 1-418-257-11 FAN UNIT, DC £ 1-468-798-13 POWER SUPPLY BLOCK ACCESSORIES AND PACKAGING MATERIALS *4-096-824-01 SHEET, POLYTHENE *4-096-825-01 TOP, COVER *4-096-826-01 BASE TRAY...
- Page 88 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.