New Holland Boomer 30 Service Manual page 13

Decisive awareness of the most basic safety rule is normally sufficient to avoid many serious accident.
WARNING
Unexpected machine movement!
Disengage power, shut down the tractor, and be sure that all moving parts have stopped before ser-
vicing, adjusting, cleaning, or unclogging the equipment.
Failure to comply could result in death or serious injury.
WARNING
Pressurized system!
Never attempt to drain fluids or remove filters when the engine is running. Turn off the engine and
relieve all pressure from pressurized systems before servicing the machine.
Failure to comply could result in death or serious injury.
SAFETY REQUIREMENTS FOR FLUID POWER SYSTEMS AND COMPONENTS - HY-
DRAULICS (EUROPEAN STANDARD PR EM 982)
Flexible hose assemblies must not be constructed from hoses which have been previously used as part of a hose
assembly.
Do not weld hydraulic piping.
When flexible hoses or piping are damaged, replace them immediately.
It is forbidden to modify a hydraulic accumulator by machining, welding or any other means.
Before removing hydraulic accumulators for servicing, the liquid pressure in the accumulators must be reduced to
zero.
Pressure check on hydraulic accumulators shall be carried out by method recommended by the accumulator manu-
facturer.
Care must be taken not to exceed the maximum allowable pressure of the accumulator. After any check or adjustment
there must be no leakage of gas.
SAFETY RULES
A careful operator is the best operator. Most accidents
can be avoided by observing certain precautions. To
help prevent accidents, read and take the following
precautions before operating this tractor.
should be operated only by those who are responsible
and instructed to do so.
THE TRACTOR
1. Read the Operator's Manual carefully before using the tractor. Lack of operating knowledge can lead to accidents.
2. Use an approved roll bar and seat belt for safe operation. Overturning a tractor without a roll bar can result in
death or injury. If your tractor is not equipped with a roll bar and seat belt, see your NEW HOLLAND Dealer.
3. Always use the seat belt. The only instance when the seat belt should not be used is if the roll bar has been
removed from the tractor or folding ROPS is in down position.
4. If a front end loader is to be installed, always use a FOPS (Falling Object Protective Structure) canopy to avoid
injury from falling objects.
5. Use the handholds and step plates when getting on and off the tractor to prevent falls. Keep steps and platform
cleared of mud and debris.
6. Do not permit anyone but the operator to ride on the tractor. There is no safe place for extra riders.
7. Keep all safety decals clean of dirt and grime, and replace all missing, illegible, or damaged safety decals. See
the list of decals in the Decal section of this manual.
SERVICING THE TRACTOR
1. The cooling system operates under pressure which is controlled by the radiator cap. It is dangerous to remove
the cap while the system is hot. Always turn the cap slowly to the first stop and allow pressure to escape before
removing the cap entirely.
INTRODUCTION
Equipment
-84373326 07/01/2011
8
W0924A
W0905A