1. General information For reasons of clarity, this operating manual does not contain all the detailed information and can not cover every concei- vable case of adjustment, operation or maintenance. Should you require further information or problems occur that are not listed in the operating instructions, please contact our customer service with confidence.
2.2. Technical regulations to be observed: • DIN 1986 drainage systems for buildings and properties, part 30. 100 • DIN EN 752 drainage systems outside of buildings. Part 1-7 • DIN EN 1825 separator systems for grease, part 2 • Draft DIN 4040, part 100 •...
To assert warranty claims, the products must be properly connected and operated and used in accordance with the data sheets. A prerequisite is a fully completed operating diary, which can be requested from Walpol in the event of a warranty claim.
A grease trap is used wherever greasy wastewater is to be expected. The grease separator separates fats, oils and sludge from the wastewater. 5.2. Specifications of the grease separator Type WNG-1 - For drawings and details, see licneces from page 11 Sludge trap 10 Liter...
6.1. Additional maintenance Check the lip seal every week for damage and replace if necessary. We generally recommend replacing the seal after a maximum of 3 years. Use only original replacement seals from Walpol Instructions for replacing seals: Pull off / remove old seal...
If damage occurs within the guarantee period, the cause of which is doubtful and for which you would like to assert guaran- tee claims, we ask you to notify WALPOL immediately and to await further instructions. Until the cause has been clarified or we have approved it, the separator system must be left in the state in which it was left due to the damage.
Page 9
Unless otherwise requirde by ordinances and other requirements, cleaning and maintenance must be carried out in accor- dance with the operating instructions. Maintenance must be carried out by qualified professionals. Operation log Grease separator type WNG-1/2/3 Commissioning company: Date: Emptying /...
The designated grease separator systems are intended for the separation of solid and liquid organic fats / oils from waste- water by gravity to protect drainage systems. The following notified bodies were involved DIBt – Berlin: Bauaufsichtliche Zulassung Z-54.6-340 (WNG-1/2/3) Applied standards and technical specifications: DIN 4040-100 DIN EN 10204...
Licences Note Below the original certificate in german. For further information please contact WALPOL. 30.08.2021 II 33-1.54.6-10/01-6 Z-54.6-340 30. August 2021 1. Juli 2026 WALPOL GmbH Benzstraße 13 45891 Gelsenkirchen Fettabscheider aus Edelstahl für bewegliche Spüleinrichtungen Der oben genannte Regelungsgegenstand wird hiermit allgemein bauaufsichtlich zugelassen/genehmigt.