Subscribe to Our Youtube Channel
Related Manuals for Twin Eagles TETG30-CN
Summary of Contents for Twin Eagles TETG30-CN
- Page 1 TWIN EAGLES TEPPANYAKI GRIDDLE INSTALLATION, USE, & CARE MANUAL MODEL: TETG30-C P/N: 24256L 05/21...
- Page 2 AGLES Teppanyaki Griddle. In addition to its Unique Style, Superb Performance and High Quality, this appliance is built with pride in the U.S.A. Twin Eagles is committed to making outdoor cooking products you’ll be proud to own for years. This manual gives you easy to follow instructions for installing, operating and maintaining your AGLES Teppanyaki Griddle.
- Page 3 IMPORTANT SAFETY INFORMATION WARNING! Read this manual carefully and completely before using your appliance to ensure proper operation, proper installation, proper servicing and to reduce the risk of fire, burn hazard and/ or other injury. AVERTISSEMENT! Lire ce manuel avec soin et en entier avant l’utilisation de votre barbecue afin d’en assurer un fonctionnement, une installation et un entretien adéquats et réduire le risque d’incendie, de brûlures et d’autres blessures.
- Page 4 The replacement hose assembly shall be specified but the manufacturer. 10. The pressure regulator and hose assembly supplied with the Twin Eagles Teppanyaki Griddle must be used. Replacement pressure regulators and hose assemblies must be those specified by Twin Eagles.
-
Page 5: Table Of Contents
TABLE OF CONTENTS GETTING STARTED………………………………………………………………………………………… GAS REQUIREMENTS o GAS REQUIREMENTS………………………………………………………………………………… o LP GAS HOOK-UP……………………………………………………………………………………… o GAS REGULATOR CHECK / CONVERSION…………………………………………………………. o NATURAL GAS INSTALLATION…………………………………………………………………… o LEAK TEST…………………………………………….……………………………………………… LOCATING THE GRIDDLE o LOCATING THE GRIDDLE………………………………………………………………………… o CLEARANCE TO COMBUSTIBLE CONSTRUCTION……………………………………………… o CLEARANCE TO NON-COMBUSTIBLE CONSTRUCTION………………………………………… o CUT-OUT DIMENSIONS……………………………………………………………………………... -
Page 6: Getting Started
Natural Gas or NG If the Teppanyaki Griddle is factory built for natural gas, the regulator supplied is set for 4” water column. No not use any replacement regulator other than that specified by Twin Eagles. Shipment This Teppanyaki Griddle is inspected before leaving the factory. The shipping carrier assumes full responsibility for the safe delivery of the appliance. -
Page 7: Gas Requirements
GAS REQUIREMENTS Each appliance is set and tested at the factory for the type of gas supply to be used. Identify the type of gas, either natural gas or LP gas, and make sure that the marking on the rating/serial plate matches the gas being supplied to the griddle. -
Page 8: Lp Gas Hook-Up
LP GAS HOOK-UP ” flare end of the hose Install the factory-supplied hose and regulator assembly as shown. Connect the to the manifold coupling using a ¾” open wrench. Do not apply pipe sealant to the ” flare connection. Connect the regulator to the LP cylinder hand tighten it, do not use a wrench. Check for leaks using soapy water solution. -
Page 9: Gas Regulator Check / Conversion
GAS REGULATOR CHECK / CONVERSION If the Teppanyaki Griddle is factory built for natural gas, the regulator supplied is set for 4” water column. The regulator is convertible to 10 in wc (2.49 kPa) for system LP application. Do not use with a 20-lb LP cylinder. -
Page 10: Natural Gas Installation
NATURAL GAS INSTALLATION A typical natural gas installation is shown below. Make sure that the factory-supplied regulator is used and installed with the arrow mark on the regulator pointing towards the Teppanyaki Griddle. Use only pipe sealants that are approved for use with natural and LP gases. An installer-supplied gas shutoff valve must be installed in an accessible location. -
Page 11: Leak Test
• Check to ensure that flexible hoses do not have any cuts and wear that may affect the safety before each use. Only the factory supplied hose and regulator must be used. Use only replacement regulator and hose assemblies specified by Twin Eagles. LEAK TEST 1) Prepare a leak testing solution of sudsy water by mixing in a spray bottle with half liquid soap and half water. -
Page 12: Locating The Griddle
LOCATING THE GRIDDLE When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas supply lines as short as possible. Locate the griddle only in a well ventilated area. For free standing configurations allow 12”... -
Page 13: Cut-Out Dimensions
WARNING: The Teppanyaki Griddle must be installed in a NON-COMBUSTIBLE ENCLOSURE ONLY. Twin Eagles Teppanyaki Griddle is ETL – approved for residential installation. Cutout must include a 4” (10.2cm) x 4” (10.2cm) opening for a side or bottom gas connection in two locations. The openings are indicated by the square, dashed cut outs in the diagram above. -
Page 14: Operating Instructions
OPERATING INSTRUCTIONS Lighting Instructions 1. Remove the cover from the Teppanyaki Griddle. 2. Ensure the Gas supply valve is closed and the burner knob is set to the OFF position. 3. Open the valve on the gas supply. 4. Press in switch on the right marked with the symbol to turn on the griddle. -
Page 15: Cleaning And Maintenance
TWIN EAGLES products have been tested in saline solutions, highly chlorinated solutions and have been tested against exposure to highly acidic foods. The test results proved the type 304 stainless steel can withstand exposure over prolonged periods of time. -
Page 16: Grease Tray / Flue Cover
WARNING: It is recommended that your TWIN EAGLES products be kept dry and covered when not in use. This is even more important when long-term storage is intended. -
Page 17: Spider And Insect Warning
Spider and Insect Warning Spiders and other insects can nest in the burners and orifices of this and any other outdoor products, which causes the gas to flow from the front of the burner. This can create a dangerous condition that can cause a fire behind the valve panel, damaging the Teppanyaki Griddle and making it unsafe to operate. -
Page 18: Electrical Requirements
ELECTRICAL REQUIREMENTS This TWIN EAGLES product is provided with electrical components, proper handling and care is needed to maintain the quality of your TWIN EAGLES product. 1. To protect against shock, do not immerse cord or plug in water or other liquid;... -
Page 19: Exploded View
EXPLODED VIEW... -
Page 20: Replacement Parts List
TEPPANYAKI GRIDDLE PLATE ASSEMBLY S20960WY FLUE COVER WELDED ASSEMBLY S16472 IGNITER, HOT SURFACE, GRIDDLE BURNER, “U” S/S 0.75 WALL THK S13301 S13203 TWIN EAGLES LOGO S14160 BARREL CLIP S16404 LPV-60 POWER SUPPLY S15110-46 ORIFICE, #46 NG S15110-55 ORIFICE, #55 LP... -
Page 21: Limited Product Warranty
In the event of any warranty replacement, all removal, replacement, installation and shipping costs are the responsibility of the owner. If the unit is located in a remote area where Twin Eagles factory authorized service is not available, you may be required to bring the unit to a Twin Eagles authorized service location at your own cost and expense. - Page 22 THIS PAGE IS INTENTIONALLY LEFT BLANK...
- Page 23 HOW TO OBTAIN SERVICE For service, please contact your TWIN EAGLES dealer or call TWIN EAGLES direct at (800) 789-2206 or (562) 802-3488 or fax (562) 802-3391 Mailing address: Twin Eagles, Inc. 13259 East 166 Street Cerritos, CA 90703 Visit us at www.twineaglesgrills.com...
- Page 24 Here Place Postage Here ATTN: Warranty Department 13259 East 166 Street Cerritos, CA 90703 Fax no. (562) 802-3391...
Need help?
Do you have a question about the TETG30-CN and is the answer not in the manual?
Questions and answers