Craftsman 917.271061 Owner's Manual page 55

TRACTOR
- - MODEL NUMBER 917.271061
KOHLER ENGINE-MODEL NUMBER CV15.5S, TYPE NUMBER 41596
IGNITION / ELECTRICAL
CRANKCASE
KEY PART
KEY PART NO. NO. DESCRIPTION
NO. NO. DESCRIPTION
1 12-086-14-SScrew, Hex Flange
M10x 1.5x46
2 12-468-03-SWasher, Plain 3/8
3 24-162-03-S Screen, Grass
4 25-684-47-S Bolt, shoulder (4)
5 12-157-03-S Spacer, Fan (4)
6 X-42-15-S Key
7 12-025-37-S Flywheel Assembly
8 12-155-09-S Connector
9 M-0548025-S Screw, Hex Cap
M5 x 0.8 x 25 (2)
10 M-0545010-S Screw, Hex Flange
M5 x 0.8 x 10 (2)
11 12-085-10-S Stator
12 12-132-02-S Spark Plug
13 X-728-1-S Clip, Cable
14 12-584-04-S Module ignition
15 M-0545020-S Screw, Hex Flange
M5 x 0.8 x 20 (2)
3
4
5
6
7
8
9
10
NOT ILLUSTRATED
-- 12-518-35-S Lead, White, Ground To Kill
(36", 18 Gauge, Fully
Insulated Push-on Tab and
Uninsulated Push-on Tab
Terminals)
- - 12-454-03-S Tie wire
OIL PAN / LUBRICATION
KEY PART
NO. NO. DESCRIPTION
1 12-038-01 -S Dipstick Assembly
(Includes Key Numbers 2
and 3)
2 25-755-13-S Kit, Oil Fill Cap (Includes
Key #3)
3 12-153-03-S O-Ring, Dipstick
4 12-153-02-S O-Ring, Upper Oil Fill Tube
5 12-123-04-S Tube, Oil Fill
6 M-645025-S Screw, Hex Flange
M6 x 1.0 x 25
7 12-153-01-S O-Ring, Lower Oil Fill Tube
8 25-162-07-S Screen, Oil Pick-up
9 12-096-03-S Cover, Oil Pick-up Screen
10 M-545016-S Screw, Hex Flange
M5x0.8 x 16
11 12-050-01-S Oil, Filter
12 25-462-09-S Valve Oil Pressure Relief
13 X-75-10-S Plug, square hd solid 3/8"
14 12-393-01-S Oil Pump Assembly
15 12-153-06-S O-Ring, Oil pump Cover
16 12-096-34-S Cover, Oil Pump
17 M-545016-S Screw, Hex Flange
M5 x 0.8 x 16 (3)
18 12-032-03-S (P.T.O. End)
t 9 24-086-16-S Screw, Hex. Flange
M6 X 1.25 X 45 (11)
20 24-086-17-S Screw, Hex. Flange
M8X 1.25X45
21 12-199-56-S Pan, Oil Assembly
(Includes 12, 14-17)
12-032-03-S Seal, Crankshaft
12-522-18-S Block, Cylinder (Use Short
Block)
12-445-02-S Strap, Lifting
M-0839025-S Screw, Hex Flange
M8x 1.25x25
12-380-03-S Dowel, Locatin ] (4)
12-755-49-S Kit, Camshaft, Includes
Key #7 & 8)
12-089-18-S Sprin 3, Actuating
12-422-08-S Shim Camshaft Blue
12-422-09-S Shim
12-422-10-S Shim
12-422-11-S Shim
12-422-12-S Shim
12-422-13-S Shim
12-422-07-S Shim
12-144-27-S Shaft
Camshaft Red (A.R.)
Camshaft Yellow (A.R.)
Camshaft Green (A.R.)
Camshaft Grey (A.R.)
Camshaft Black (A.R.)
Camshaft White (A.R.)
Balance
12-874-07-S Piston w/Ring Set Standard
12-874-68-S Piston wiRing Set .25"
Oversize
12-874-09-S Piston w/Ring Set .50"
Oversize
11 12-018-02-S Retainer, Piston Pin (2)
12 t2-108-07-S Ring Set, Standard
12-108-08-S Ring Set .25" Oversize
12-108-09-S Ring Set .50" Oversize
13 12-067-05-S Connecting Rod, Standard
12-067-06-S Connecting Rod .25" Oversize
14 12-380-01 -S Pin, Governor Regulating
15 12-043-05-S Gear, Governor Assembly
16 M-0631005-S Washer, Plain, 6mm
17 12-144-02-SShaft, Governor Gear
18 52-139-09-S Plug, Cup
1 9 12-755-64-S Kit, Shaft, Governor Cross,
with Clip (Includes Key #20
and 24)
20 12-144-24-S Shaft, Governor Cross
21 X-25-102-S Washer, Plain 1/4
22 12-032-01-S Seal, Governor Cross Shaft
23 SM-0631015-SWasher, Plain, 6ram
24 12-154-05-S Clip, Hitch Pin
STARTING SYSTEM
KEY PART
NO. NO. DESCRIPTION
1 M-0839070-S Screw, Hex Flange
M8 x 1.25 x 70 (2)
2 25-098-03-S Starter Assembly
(Includes Key Numbers 3
thru 8)
3 12-755-54-S Kit, Drive End
4 12-227-06-S Cap, Drive End
5 45-170-03-S Armature
7 12-227-11 -S End Cap, Commutator
8 12-086-25-S Screw, Hex Flange
1/4-20 x 4-5/8 (2)
NOTE: All component dimensions given in U.S.
inches 1 inch = 25.4 mm
55