TROUBLESHOOTBNG
POUNTS
,,,,,
PROBLEM
CAUSE
CORRECTION
Will not start
Herd to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
1
Out of fuel
2
Engine not "CHOKED"
properly
3
Engine flooded
4
Bad spark plug
5
Dirty air filter
6
Dirty fuel filter
7
Waterin
fuel
8
Loose or damaged wiring
9
Carburetor
out of adjustment
10
Engine vatves out of adjustment
1
Dirty air filter
2
Bad sparkplug
3
Weak or dead battery
4
Dirty fuel filter
5
Stale or dirty fuel
6
Loose or damaged wiring
7
Carburetor
out of adjustment
8
Engine valves out of adjustment
1
Clutch/brake
pedal not depressed
2
Attachment
clutch Is engaged
3,
Spark plug wire is disconnected
4
Weak or dead battery
5
Blown fus_
6
Corroded battery terminals
7
Loose or dama_; : wiring
8
Feuity Ignition swa_
9
Faulty solenoid or starter
10
Faulty operator presence switch(as)
1
Weak or dead battery
2
Corroded battery terminals
3
Loose or damaged wiring
4
Faulty solenoid or starter
1
Cutting too much grass/too fast
2,
Throttie in "CHOKE" position,
3
Build-up of grass, leaves and trash under mower
4
Dirty air filter
5
Low oll leve!/dirty oli
6
Faulty spark plug
7
Dirty fuel filter
8
Stale or dirty fuei
9
Water in fuel
10
Spark plug wire Ioo_e
11
Dirty engine air :_•
'fins
12
Dlrty/clogge0
n J_er
13
Loose or damaged wiring
14
Carburetor
out of adjustment
15
Engine valves out of adjustment
1
Worn, bent or loose blade
2
Bent blade mandrel
3
Loose/damaged
part(s)
1
FIll fuel tank
2
See TO START ENGINE tn operation section
3
Wait several minutes before attempting to start
4
Replace spark plug
5
Clean/replace
air _ter
6,
Replace fuel filter
7
Drain fuel tank and carburetor, refill tank with fresh
gasoiine and replace fuel filter
8
Check all wiring
9
Contact Sears Service Department
10
Contact Sears Service Department
I
Clean/replace
air filter
2
Replace spark plug
3
Recharge or replace battery
4
Replace fuel filter
5
Drain fuel tank and refill with fresh gasoline
6
Check all wiring
7
Contact Sears Service Department
8
Contact Sears Service Department
1
Depress Clutch/brake
peda_
2
Disengage
attachment
clutch
3
Connect wire to spark pIug
4
Recharge or replace battery
5
Replace fuse
6
Clean battery terminals
7
Check allwlrlng
8
Check/replace
Ignition switch
9
Check/replace
solenoid or starter
10
Contact Sears Service Department
1
Recharge or replace battery
2
Clean battery terminals
3
Check aH wiring
4
Check/replace
solenoid or starter
1
Set In "Higher Cut" position/reduce
speed
2
Adjust throttte controt
3
Clean underside of mower housing
4
Clean/replace
air filter
5
Check oil level/change
oil
6
Clean and regap or change spark plug
7
Replace fuel filter
8
Drain fuel tank and refiti with fresh gasoline
9
Drain fuel tank and carburetor,
refill tank with fresh
gasoline and replace fuel filter
10
Connect and tighten spark plug wire
11
Clean engine air screen/fins
12
Clean/repIace
muffler
13
Check all wiring
14
Contact Sears Service Department
15
Contact Sears Service Department
Replace blade
Tighten blade bolt
2
Replace blade mandrel
3
Tighten loose part(s)
Replace damaged parts
27