Table of Contents
Advertisement
DO'S
AND
Listed below are a few of the "DO'S AND DO NOT'S" which pertain to both the operation and upkeep of your
Orchard-Rite
Tree Shaker.
®
DO
READ AND UNDERSTAND THIS OWNER'S MANUAL BEFORE OPERATING THE TREE SHAKER.
DO
FOLLOW THE MAINTENANCE SCHEDULE CAREFULLY.
DO
CHANGE AND/OR ROTATE THE TREE SHAKER PADS FREQUENTLY TO MINIMIZE HEAT IN THE PADS AND SLINGS.
DO
ALLOW OIL IN THE ENGINE AND HYDRAULICS TO WARM BEFORE OPERATING THE TREE SHAKER.
DO
STOP AND LOOK BEFORE BACKING UP.
DO
OBSERVE THE TREE BEFORE, DURING AND AFTER SHAKING FOR SIGNS OF BARKING OR OTHER DAMAGE.
DO NOT
CONTINUE TO OPERATE THE SHAKER IF MULTIPLE TREES ARE DAMAGED. CONTACT YOUR LOCAL SERVICE REP.
DO NOT
GREASE THE SLINGS. THIS TREE SHAKER IS EQUIPPED WITH AN AUTOMATIC LIQUID SLING
LUBRICATING AND COOLING SYSTEM.
DO NOT
USE GREASE ON ANY OF THE WEAR PLATES.
DO NOT
SKIP THE DAILY OR SCHEDULED MAINTENANCE ROUTINE.
DO NOT
SET CLAMP PRESSURE ABOVE 1500 PSI OR BELOW 1200 PSI.
DO NOT
OPERATE THE TREE SHAKER IF THE MAIN PRESSURE IS ABOVE 4200 PSI.
DO NOT
OPERATE THE TREE SHAKER IF FLUID LEVELS ARE LOW.
DO NOT
ENGAGE THE PARKING BRAKE WHILE THE TREE SHAKER IS IN MOTION.
DO NOT
RUN THE TREE SHAKER HEAD AT HIGH RPM WHEN NOT ATTACHED TO A TREE.
DO NOT
OPERATE THE TREE SHAKER WITHOUT ALL DOORS AND COVERS SECURLEY IN PLACE.
DO NOT
ATTEMPT TO MANEUVER THE TREE SHAKER HEAD OR MACHINE WHILE CLAMPED TO A TREE.
DO NOT
PUSH OR TOW THE TREE SHAKER.
DO NOT
WELD ON THE WHEEL RIMS
ORCHARD-RITE®, MONOBOOM™, and WETHEAD® are trademarks of Orchard-Rite Ltd. Inc. All Rights Reserved.
DO NOT'S
OF OPERATION AND MAINTENANCE
.
©2020 Pacific Distributing, Inc. SH.MON.OwnersManual.1908.v2.0
9
Advertisement
Table of Contents
