Advertisement
Quick Links
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the appliance
and immediately call your gas supplier or fire
department.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance. An LP-cylinder not connected for use shall
not be stored in the vicinity of this or any other
appliance.
WARNING:
DANGER
Improper installation, adjustment, alteration, service
or maintenance can cause property damage, injury or
death. Read the installation, operation and
maintenance instructions thoroughly before installing
or servicing this equipment.
1
Owner's
PATIO HEATER
DANGER
WARNING
For Outdoor Use Only
CARBON MONOXIDE HAZARD
This appliance can produce
carbon monoxide which has
no odor. Using it in an enclosed
space can kill you. Never use this
appliance in an enclosed space
such as a camper, tent, car or
home.
WARNING
Manual
OUTDOOR
MODEL #
ZCV-2650 SS
ZCV-2650 SV
ZCV-2650 AB
Advertisement
Related Manuals for Garden Sun Heater ZCV-2650 SS
Summary of Contents for Garden Sun Heater ZCV-2650 SS
- Page 1 Owner’s Manual OUTDOOR PATIO HEATER MODEL # ZCV-2650 SS ZCV-2650 SV ZCV-2650 AB DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department.
-
Page 2: Package Contents
PACKAGE CONTENTS QUANTITY Reflector Head Assembly Cylinder Housing Post Gas Hose Support Bracket Base Wheel Assembly Regulator... -
Page 3: Safety Information
HARDWARE CONTENTS (shown actual size) Stainless Flange steel bolt Qty. 2 Bolt Qty. 9 Qty. 4 Qty. 14 Bolt Qty. 13 Qty. 3 Bolt Qty. Qty. 2 Wrench Wing nut Qty. 1 Bolt Reflector Qty. 3 (not actual spacer size) Qty . - Page 4 SAFETY INFORMATION DANGER DANGER • EXPLOSION - FIRE HAZARD • CARBON MONOXIDE HAZARD • Keep solid combustibles, such as building materials, • This heater is a combustion appliance. All paper or cardboard, a safe distance away from the combustion appliances produce carbon monoxide heater as recommended by the instructions.
- Page 5 SAFETY INFORMATION WARNING WARNING California Proposition 65 • This product is fueled by propane gas. Propane gas Combustion by-products produced when using is invisible, odorless, and flammable. An odorant is this product contain chemicals known to the State normally added to help detect leaks and can be of California to cause cancer, birth defects, and described as a “rotten egg”...
- Page 6 ASSEMBLY INSTRUCTIONS 1. Assemble the wheel bracket to the base with 4pcs STEP 1 M6X12 bolt (CC) and 4pcs M6 nut (JJ). (see step 1). Assemble the other bracket in the same way. Assemble the wheel to the bracket with 1pc M8X45 bolt (DD), 1pc 8 Washer (GG) and M8 Nut (II) (see step 2).
- Page 7 ASSEMBLY INSTRUCTIONS 4. Load Cylinder Housing onto Post. Slide Cylinder Housing down. 5. Attach reflector spacers (LL) and Ø8 washers(GG) to the top of head assembly (C). Tighten the reflector spacers (LL). Unscrew stainless steel bolts (DD) from head assembly (C). Hardware Used Reflector spacer Stainless Steel Bolt...
- Page 8 ASSEMBLY INSTRUCTIONS 7 . Support heater. Slide three washers washer 8 (GG) over threaded end of spacer. Locate reflector assembly on 3 spacers. Install three washers 8 on spacers and securely tighten wing nuts (KK) but do not overtighten. Hardware Used Wing nut 8 .
- Page 9 ASSEMBLY INSTRUCTIONS A dented, rusted or damaged propane cylinder may be hazardous and should be checked by your cylinder supplier. Never use a propane cylinder with a damaged valve connection. The propane cylinder must be constructed and marked in accordance with the specifications for LP gas cylinders of the U.S.
- Page 10 OPERATION INSTRUCTIONS Leak Check WARNING • Perform all leak tests outdoors. • Extinguish all open flames. • NEVER leak test when smoking. • Do not use the heater until all connections have been leak tested and do not leak. Hose / Regulator Regulator / Cylinder connection connection...
- Page 11 OPERATION INSTRUCTIONS DANGER Caution: Do not attempt to operate until you have read and understand all General Safety Information in this manual and all assembly is complete and leak checks have been performed. Note: This heater is equipped with a pilot light that allows for safer startups and shutdowns. Pilot must be lit before main burner can be started.
- Page 12 OPERATION INSTRUCTIONS 5. Push and release the igniter button until pilot flame is visible through viewing hole. 6. Once the pilot is lit, continue to depress the control knob for 30 seconds. 7. If the pilot does not stay lit, repeat steps 4 to 6. 8.
- Page 13 OPERATION INSTRUCTIONS WARNING FOR YOUR SAFETY Be careful when attempting to manually ignite this heater. Holding in the control know for more than 10 seconds before igniting the gas will cause a ball of flame upon ignition. When heater is ON: Emitter screen will become bright red due to intense heat.
-
Page 14: Care And Maintenance
OPERATION INSTRUCTIONS 9. Heater is away from gasoline or other flammable liquids or vapors. 10. Heater is away from windows, air intake openings, sprinklers and other water sources. 11. Heater is at least 24 in. on top and at least 36 in. on sides from combustible materials. 12. - Page 15 CARE AND MAINTENANCE Gas odor with extreme yellow tipping of flame. Heater does NOT reach the desired temperature. Heater glow is excessively uneven. Heater makes popping noises. Spiders and insects can nest in burner or orifices. This dangerous condition can damage heater and render it unsafe for use.
-
Page 16: Troubleshooting
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Cylinder valve is closed Open valve Clean or replace orifice or Blockage in orifice or pilot tube pilot tube Open gas line and bleed it Pilot won’t light Air in gas line (pressing control knob in) for not more than 1 - 2 minutes or until you smell gas Low gas pressure with cylinder valve...