Table of Contents
Advertisement
Quick Links
MANUFACTURING
NUMBERS:
9700741
9700751
System Tested and Certified by NSF
International and WQA against NSF/ANSI
Standard 42 and 53 for the reduction of:
Standard No. 42: Aesthetic Effects
Nominal Particulate Reduction Class I
Standard No. 53: Health Effects
Cyst Reduction & Turbidity Reduction as
verified and substantiated by test data.
System Tested and Certified by WQA
against NSF/ANSI Standard 372
for lead-free compliance
P/N 1011079 Rev. J 01/14
VZN V SERIES
WATER FILTRATION
VZN-441V, VZN-441V-T5
Owner
A.J. Antunes & Co.
VZN-441V
Scan with mobile device or enter URL
for product and service information.
http://tiny.cc/ajaVZN441V
s Manual
'
Advertisement
Table of Contents
Related Manuals for A.J.Antunes vizion VZN V Series
Summary of Contents for A.J.Antunes vizion VZN V Series
- Page 1 MANUFACTURING NUMBERS: 9700741 9700751 VZN V SERIES WATER FILTRATION System Tested and Certified by NSF International and WQA against NSF/ANSI VZN-441V, VZN-441V-T5 Standard 42 and 53 for the reduction of: Standard No. 42: Aesthetic Effects Nominal Particulate Reduction Class I Standard No.
-
Page 2: Table Of Contents
VZN V SERIES TABLE OF CONTENTS Owner Information ...............2 System Inlet Connection ..........12 General................2 Filtered Water Permeate Outlet Connection ....12 Warranty Information ............2 Inlet Water Plumbing ............12 Service/Technical Assistance ..........3 Installing a Bypass ............13 Important Safety Information ..........4 Starting the Controller ............ -
Page 3: Service/Technical Assistance
VZN V SERIES OWNER INFORMATION (continued) Service/Technical Assistance Suggested replacement period for the Ultra Filter Cartridge is If you experience any problems with the installation or opera- approximately 3 years. tion of your system, contact A.J. Antunes & Co. at 1-630-784- 1000, or toll free in the United States at 1-800-253-2991. -
Page 4: Important Safety Information
VZN V SERIES IMPORTANT SAFETY INFORMATION In addition to the warnings and cautions in this manual, use The following warnings and cautions appear throughout this the following guidelines to safely operate the system: manual and should be carefully observed. • Read all instructions before using equipment. •... - Page 5 VZN V SERIES IMPORTANT SAFETY INFORMATION (continued) Protect from becoming dry CAUTION If the membrane dries out, irreversible damage to the Ultra This equipment is to be installed to comply with the Filter membrane may result. Protect the filter from becoming basic plumbing code of the Building Officials and Code dry by keeping it wet and sealed at all times.
-
Page 6: Specifications
VZN V SERIES SPECIFICATIONS Electrical Ratings Dimensions Model & Volts Watts Amps Hertz VZN-441V VZN-441V-T5 Mfg. No. VZN-441V 100–240 50/60 9700741 VZN-441V-T5 100–240 50/60 9700751 NOTE: Includes plug adaptors for US, Europe, Australia, and UK. Replacement Cartridges Replacement Part Number VZN-441V L-440 Ultra Filter 7000412... -
Page 7: Performance Data Sheet
VZN V SERIES PERFORMANCE DATA SHEET Performance Claims for Percent Reduction Filter Cartridge Capacities Substance Influent Reduction Minimum Maximum Operating Pressure 100 psig (690 kPa) Challenge Requirement Maximum Operating Temperature 100°F (38°C) Concentration Reduction Minimum Operating Temperature 40°F (4°C) cyst minimum 99.95% 99.95%... -
Page 8: Operation
VZN V SERIES OPERATION Overview The VZN system operates in two modes: System Flush • Normal Operation Mode Solenoid Valve (Automatic) • Flush Mode Rinse Ball Valve During Normal Operation Mode, water enters the Inlet and (Manual) flows through the Ultra Filter before exiting the Permeate Outlet as usable product water. -
Page 9: Installation
VZN V SERIES INSTALLATION Unpacking Equipment Setup 1. Open the large box. It should contain: GENERAL A. Plate-mounted VZN system with Ultra Filter When placing the system into service, pay attention to the Cartridge installed following guidelines: B. Padded envelope containing: •... -
Page 10: Mounting The System
VZN V SERIES INSTALLATION (continued) CAUTION Back Plate The system is (holes along bottom designed to hang from Due to its weight and size, the VZN system MUST be for additional the Mounting Bracket. mounted with the provided Mounting Bracket. Read mounting stability) the Mounting the System section before attempting to mount the VZN system. -
Page 11: Drain Valve Connection
VZN V SERIES INSTALLATION (continued) Drain Valve Connection The drain is for flushing particle buildup out of the Example Drain Valve Connection system during self cleaning. 1. Cut a length of tubing (not supplied) so it reaches the Secure Hose drain from the Drain Valve. -
Page 12: Rinse Valve Connection
VZN V SERIES INSTALLATION (continued) Rinse Valve Connection 1. Obtain a length of 3/4” garden hose long enough to reach from the Rinse Valve to the drain. 2. Install a gasket in the end of the hose (non-drain end). 3. Connect the hose to the Rinse Valve fitting. Use a back- up wrench on the fitting if required (Figure 5). -
Page 13: Installing A Bypass
VZN V SERIES INSTALLATION (continued) Rinsing the Ultra Filter Cartridge The Ultra Filter Cartridge comes pre-installed in the VZN system. The Ultra Filter Cartridge must be rinsed before the system is used to remove any air and protective solution. NOTE: Ultra Filter Cartridge must be rinsed to drain Outlet Ball Valve before use. -
Page 14: Sanitizing The System And Lines
VZN V SERIES INSTALLATION (continued) Sanitizing the System and Lines Rinsing the Carbon Element and TAC Cartridge The plumbing must be sanitized to eliminate possible contam- The Carbon Element and TAC Cartridge MUST be rinsed ination that may have occurred during the installation process. before using the system the first time and immediately after the Carbon Element or TAC Cartridge have been replaced. -
Page 15: Maintenance
VZN V SERIES MAINTENANCE Replacing the Ultra Filter Cartridge NOTE: Always install new Carbon Element and new Snap Ring TAC Cartridge Element after replacing the Ultra Filter Cartridge. 1. Turn off water to the system by closing the Inlet Ball End Cap Valve and Outlet Ball Valve. -
Page 16: Rinsing And Replacing The Carbon Element
VZN V SERIES MAINTENANCE (continued) Rinsing and Replacing the Carbon Element RED Pressure O-Ring NOTE: Remove the TAC Cartridge Element, if present, Relief Button and re-attach the TAC Housing before proceeding. Carbon Element 1. Turn off the water to the system by closing the Inlet Ball Head Valve and Outlet Ball Valve. -
Page 17: Rinsing And Replacing The Tac Cartridge (Vzn-441V-T5 Only)
VZN V SERIES MAINTENANCE (continued) Rinsing and Replacing the TAC Cartridge (VZN-441V-T5 ONLY) bon Element installed. 1. Turn off water to the system by closing the Inlet Ball Valve and then close the Outlet Ball Valve. 2. Press the FLUSH button to initiate the flush cycle. Repeat several times to ensure the permeate tank is empty. -
Page 18: Changing The Interval Setting
VZN V SERIES MAINTENANCE (continued) Changing the Interval Setting Resetting the Timer Program During the normal operation, the system will flush accord- CAUTION ing to the set interval. It is possible the system will flush at a Changing the flush interval may cause the Ultra Filter time of high water use. -
Page 19: Troubleshooting
VZN V SERIES TROUBLESHOOTING Problem Possible Cause Corrective Action The power cord is not plugged into the Plug power cord into the appropriate outlet. appropriate outlet or control box. The unit is plugged into a switched Plug the power cord into an unswitched outlet. Unit does not have power. -
Page 20: Replacement Parts
VZN V SERIES REPLACEMENT PARTS VZN-441V Systems P/N 1011079 Rev. J 01/14... - Page 21 VZN V SERIES REPLACEMENT PARTS (continued) VZN-441V-T5 Systems P/N 1011079 Rev. J 01/14...
- Page 22 VZN V SERIES REPLACEMENT PARTS (continued) Replacement Parts can be purchased from an authorized dealer. Contact A.J. Antunes & Co. at 1-630-754-1000 or toll free in the United States at 1-800-253-2991. VZN-441V Systems Item Part Description Qty. Item Part Description Qty.
-
Page 23: Notes
VZN V SERIES NOTES P/N 1011079 Rev. J 01/14... -
Page 24: Limited Warranty
LIMITED WARRANTY Equipment manufactured by A.J. Antunes & Co. has been constructed of the finest materials available and manu- factured to high quality standards. These units are warranted to be free from defects in materials and workman- ship for a period of two years from date of purchase under normal use and service, and when installed in accor- dance with manufacturer’s recommendations*.