Daikin RCS Series Installation And Maintenance Manual page 32

Select Yes or No. If not applicable to the type of unit, select N/A.
I. INITIAL CHECK
A . Is any shipping damage visible? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
B. Tightened all setscrews? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
C . Have the shipping spacers been removed from the compressor springs and have the neoprene
spacers been installed on each compressor mounting bolt? . . . . . . . . . . . . . . . . . . . . . . . . . Yes
D . Electrical service corresponds to unit nameplate? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
E. Is the main disconnect adequately fused and are fuses installed? . . . . . . . . . . . . . . . . . . . . . . Yes
F . Are crankcase heaters operating, and have they been operating 24 hours prior to start-up? . . . . . . . . . Yes
G . Are all electrical power connections tight? (Check compressor electrical box.) . . . . . . . . . . . . . . . . Yes
H . Has the fi eld piping been piped per ASHRAE recommendations? . . . . . . . . . . . . . . . . . . . . . . . Yes
II. START-UP COMPRESSOR OPERATION
A . Has each circuit been fi eld leak tested?
Circuit #1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
Circuit #2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
B. Refrigerant charge per circuit: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Circuit 1 ________
C . Are compressors rotating in the right direction? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
D . Do condenser fans rotate in the right direction? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
E. Ambient temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _____________°F
F . Compressor lockout timers function? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
G . FanTrol functions: . . . . . . . . . . . . . . . . . . . . . TC12 _____________
H . Does unit start up and perform per sequence of operation? . . . . . . . . . . . . . . . . . . . . . . . . . Yes
III. PERFORMANCE DATA
A . Compressor voltage across each phase: . . . . . . . L1–2_____________ V
B. Compressor amperage of fully loaded compressor . Compressor #1 — Phase 1________
C . Low pressure cut-out: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Circuit 1 __________ psig
Low pressure cut-in: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Circuit 1 __________ psig
D . High pressure cut-out: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Circuit 1 __________ psig
E. Discharge pressure, one compressor: . . . . . . . . . . . . . . . . . . . . . Circuit 1 __________ psig
Discharge pressure, fully loaded, 2–3 compressors: . . . . . . . . . . . . . Circuit 1 __________ psig
13F-4155 (02/16)
IM 962-4 • AIR-COOLED SPLIT SYSTEM CONDENSERS
RCS Equipment Warranty Registration Form (continued)
Volts _____________ Hertz _____________ Phase _____________
L2–3 _____________ V
Compressor #2 — Phase 1________
Compressor #3 — Phase 1________
Compressor #4 — Phase 1________
Compressor #5 — Phase 1________
Compressor #6 — Phase 1________
32
Warranty Registration Form
Circuit 2 ________
TC13 _____________ TC14 _____________
L1–3 _____________ V
Phase 2 ________ Phase 3 _______
Phase 2 ________ Phase 3 _______
Phase 2 ________ Phase 3 _______
Phase 2 ________ Phase 3 _______
Phase 2 ________ Phase 3 _______
Phase 2 ________ Phase 3 _______
Circuit 2 __________ psig
Circuit 2 __________ psig
Circuit 2 __________ psig
Circuit 2 __________ psig
Circuit 2 __________ psig
www.DaikinApplied.com
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
2