Parts List - CAC / BDP 40MKCF Installation Instructions Manual

NOTE is used to highlight suggestions which will result in enhanced
installation, reliability, or operation.
WARNING
!
ELECTRICAL SHOCK HAZARD
Failure to follow this warning could result in personal
injury or death.
Before installing, modifying, or servicing system, main
electrical disconnect switch must be in the OFF
position. There may be more than 1 disconnect switch.
Lock out and tag switch with a suitable warning label.
CAUTION
!
ENVIRONMENTAL HAZARD
Failure to follow this caution may result in environmental
pollution.
Remove and recycle all components or materials (i.e. oil,
refrigerant, etc.) before unit final disposal.
INSTALLATION
IMPORTANT: Effective January 1, 2015, all split systems and
packaged air conditioners must be installed pursuant to applicable
regional efficiency standards issued by the Department of Energy.
CAUTION
!
CUT HAZARD
Failure to follow this caution may result in personal injury.
Sheet metal parts have sharp edges or burrs, Use care and wear
appropriate protective clothing and gloves when handling
parts.
CAUTION
!
PERSONAL INJURY AND EQUIPMENT DAMAGE
HAZARD
Failure to follow this caution may result in personal injury
and / or equipment damage.
DO NOT operate the unit without a filter or with grille
removed.
These instructions cover the installation and the start- -up of the
systems listed in Table 1.
Table 1 – Matched Systems
NOMINAL
SYSTEM
CAPACITY OUTDOOR UNIT
TYPE
kBTU/Hr
18 24AHA418A003
24 24AHA424A003
30 24AHA430A003
Cooling
Only
34 24AHA436A003/5/6
48 24AHA448A003/5/6
54 24AHA460A003/5/6
30 25HHA430A003
Heat
36 25HHA436A003/5/6
Pump
48 25HHA448A003/5/6
INDOOR UNIT
124ANS018000 40MKCB18F--- ---3
124ANS024000 40MKCB34F--- ---3
124ANS030000 40MKCB34F--- ---3
124ANS036000 40MKCB34F--- ---3
124ANS048000 40MKCB54F--- ---3
124ANS060000 40MKCB54F--- ---3
224ANS030000 40MKQB36C--- ---3
224ANS036000 40MKQB36C--- ---3
224ANS048000 40MKQB48C--- ---3

PARTS LIST

TXV Kit
The under ceiling/floor console type unit and horizontal discharge unit
(24AHA/124ANS and 25HHA4/224ANS) installation would not be
complete without the addition of the TXV kit. This can be found in
the packaging of the indoor unit. If you do not have this kit, order the
kit and install the outdoor and indoor units when this is available.
Below are figures that show how the kit looks and where it is included
within the indoor unit packaging.
Fig. 2 - - TXV Kit
TXV kit inside carton box
Fig. 3 - - TXV Kit (inside indoor unit's packaging)
Indoor Unit
The following items are included with the indoor unit:
Table 2 – Indoor Units Parts List
NAME OF PART QTY.
Owner's Manual
Warranty card
Installation instructions
Clamp filter
Remote Controller
Remote Controller Holder
Tapped Screw
Battery
Strain Relief Bracket
Screws
2
Liquid pipe
Gas pipe
Refrigerant
flow direction
A150289
A150297
USAGE
1 Guide for the homeowner
1 Warranty information
1 Guide to install the unit
For conforming to EMC standards
2
on connecting wires
1 Controls the indoor unit
Holds the remote controller on
1
the wall
Used to fix the remote controller
2
holder
2 Powers the remote controller
To affix strain relief to hold wires
1
in place
4 To affix strain relief bracket