Subscribe to Our Youtube Channel
Related Manuals for Aladdin DH07
Summary of Contents for Aladdin DH07
- Page 1 DH07, DH07A / DH08, DH08A CONVECTED AIR DISH HEATERS (9" Dishware) DH07 shown INSTALLATION, OPERATION & MAINTENANCE MANUAL Manual P/N 92448 Rev. G 04/02/2009...
- Page 2 Copyright © 1998 Aladdin Temp-Rite Changes may be made to the information in this document without notification.
-
Page 3: Table Of Contents
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) CONTENTS MODELS II. RECEIVING INSPECTIONS III. INSTALLATION IV. ELECTRICAL START-UP VI. CLEANING VII. TROUBLESHOOTING VIII. PARTS LIST / DIAGRAMS IX. PREVENTATIVE MAINTENANCE X. SERVICE XI. WARRANTY... -
Page 4: Models
9” china and Alacite® dishware only. (Not recommended for any type of pellet bases.) The Aladdin Convected Air Dish Heaters are mobile, modularly designed products which are able to be used indepen- dently or in conjunction with other units in a tray line arrangement. -
Page 5: Installation
By adding or removing springs, the proper dispensing height can be obtained. Refer to the table on page 7 to adjust the DH07 or DH08 to dispense ei- ther 9" china or Alacite® dishes. (The heaters are factory preset for china dispensing) Adjustments should be... -
Page 6: Electrical
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) B. If you are dispensing Alacite® dishes a spring adjustment will be required, proceed as follows. Lift elevating mechanism assembly up and out of stainless steel cabinet. Set it on the floor. Disconnect but do not remove any unnecessary springs from the elevator carrier and replace mechanism back into the heater. -
Page 7: Start-Up
No type of pellet base should be heated in these dish heaters. Failure to observe this warning could result in damage to bases or risk of fire. Round Plates Style Dimensions Aladdin Springs Total Capacity Part #s Required DH07 DH08 China 9" Diameter J300 9" Diameter J361 9" Diameter J461 9" Diameter J561 Alacite®... -
Page 8: Cleaning
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) C. POWER Set the power switch to the "ON" position. The power switch will light up when the unit is on. Keep the cover closed completely to insure proper and efficient heating. -
Page 9: Troubleshooting
3. Clean out any debris inside the cabinet and wipe the cabinet down with a damp cloth. 4. Place the elevator mechanisms back inside the cabinet and clean the outside of the cabinet with a mild, non- abrasive soap or detergent in a warm water solution. A commercial stainless steel cleaner can also be used for this procedure. -
Page 10: Parts List/Diagrams
Heating element-240V ("A" Models 92511 only) Push/Pull handle for units before 92501 March 2009 Fan Blade, 5/16" bore 92512 Rear louvered panel DH07 92502 Caster 5" swivel 92515 Rear louvered panel DH08 92503 Caster 5" swivel with brake 92516 Cord-10 foot length... - Page 11 DH07 / DH07A EXPLODED VIEW DRAWING Corner Bumpers are used in place of wrap around bumpers on units manu- factured after August 1999.
- Page 12 DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) DH08 / DH08A EXPLODED VIEW DRAWING Corner Bumpers are used in place of wrap around bumpers on units manu- factured after August 1999.
- Page 13 ELEVATOR ASSEMBLY EXPLODED VIEW DRAWING...
-
Page 14: Preventative Maintenance
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) WIRING DIAGRAM IX. PREVENTATIVE MAINTENANCE CASTERS 1. Check casters for freedom of movement and proper brake retention. 2. Maintain casters free of debris. (mop strings, paper plastic, hair nets, etc.) 3. Clean or replace as required. -
Page 15: Service
Effective August 1, 1996 Aladdin Temp-Rite ("ATR") warrants to the original purchaser that the equipment listed below shall be free from defects in material and workmanship under normal use for the applicable warranty term set forth below. ATR's obligation under this warranty is limited to the repair or replacement, at the sole option of ATR, of any part which upon inspection and examination by ATR or its authorized agent is found to be defective.
Need help?
Do you have a question about the DH07 and is the answer not in the manual?
Questions and answers