Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Aladdin DH07
Summary of Contents for Aladdin DH07
- Page 1 ® P.O. Box 2978, Hendersonville, TN 37077-2978 1-800-888-8018 or 615-537-3600 Fax 1-888-812-9956 www.aladdintemprite.com DH07,DH08 CONVECTED AIR DISH HEATERS (9" Dishware) DH07 shown INSTALLATION, OPERATION & MAINTENANCE MANUAL Manual P/N 92448 Rev. O 06/27/2016...
- Page 2 Copyright © 1998 Aladdin Temp-Rite Changes may be made to the information in this document without notification.
-
Page 3: Table Of Contents
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) CONTENTS I. MODELS 4 II. RECEIVING INSPECTIONS 5 III. INSTALLATION IV. ELECTRICAL 6 V. START-UP VI. CLEANING 8 VII. TROUBLESHOOTING 9 VIII. PARTS LIST/DIAGRAMS 10 IX. PREVENTATIVE MAINTENANCE X. SERVICE 15... -
Page 4: Models
(9" Dishware) I. MODELS The Aladdin Convected Air Dish Heaters are available in two capacities. These units are designed specifically for use with a wide variety of 9” china and Alacite® dishware only. (Not recommended for any type of pellet bases.) The Aladdin Convected Air Dish Heaters are mobile, modularly designed products which are able to be used independently or in conjunction with other units in a tray line arrangement. -
Page 5: Receiving Inspections
Refer to the table on page 7 to adjust the DH07 or DH08 to dispense either 9" china or Alacite® dishes. (The heaters are factory preset for china dispensing) Adjustments should be done as part of the initial equipment set-up or when a change of dinnerware occurs. -
Page 6: Electrical
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) B. If you are dispensing Alacite® dishes a spring adjustment will be required, proceed as follows. Lift elevating mechanism assembly up and out of stainless steel cabinet. Set it on the floor. Disconnect but do not remove any unnecessary springs from the elevator carrier and replace mechanism back into the heater. -
Page 7: Start-Up
! CAUTION ! No type of pellet base should be heated in these dish heaters. Failure to observe this warning could result in damage to bases or risk of fire. Round Plates Style Dimensions Aladdin Sales Springs Total Capacity codes Required DH07... -
Page 8: Cleaning
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) C. POWER Set the power switch to the "ON" position. The power switch will light up when the unit is on. Keep the cover closed completely to insure proper and efficient heating. -
Page 9: Troubleshooting
! WARNING ! Do not steam or pressure clean or hose down the cabinet. This could damage the equipment and possibly cause an electrical shock to the operator. ! WARNING ! Repairs to be done by qualified service personnel only. VII. -
Page 10: Parts List/Diagrams
NOTES: *Corner Bumpers are used in place of wrap around bumpers on units manufactured after August 1999. ♠ For the SN and above DH07 F16431 and DH08 E16218 ♣ For SN prior to DH07 F16431 and DH08 E16218 FOR PARTS & SERVICE CALL 1 (800) 888-5426... - Page 11 DH07 EXPLODED VIEW DRAWING Corner Bumpers are used in place of wrap around bumpers on units manufactured after August 1999. FOR PARTS & SERVICE CALL 1 (800) 888-5426...
- Page 12 DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) DH08 EXPLODED VIEW DRAWING Corner Bumpers are used in place of wrap around bumpers on units manufactured after August 1999. FOR PARTS & SERVICE CALL 1 (800) 888-5426...
- Page 13 ELEVATOR ASSEMBLY EXPLODED VIEW DRAWING FOR PARTS & SERVICE CALL 1 (800) 888-5426...
-
Page 14: Preventative Maintenance
DH07 / DH08 CONVECTED AIR DISH HEATERS (9" Dishware) WIRING DIAGRAM IX. PREVENTATIVE MAINTENANCE CASTERS Check casters for freedom of movement and proper brake retention. Maintain casters free of debris. (mop strings, paper plastic, hair nets, etc.) Clean or replace as required. -
Page 15: Service
X. SERVICE In the event service is required on your Aladdin DH07 / DH08 Series Plate Heaters please call: ALADDIN TEMP-RITE SERVICE DEPARTMENT 1-800-888-5426 XI. WARRANTY ALADDIN TEMP-RITE ® EQUIPMENT LIMITED WARRANTY Effective August 1, 2005 Aladdin Temp-Rite (“ATR”) warrants to the original purchaser that the equipment listed below shall be free from defects in material and ®... - Page 16 250 East Main Street, Hendersonville, TN 37075 1-800-888-8018 ● www.aladdintemprite.com ● info@aladdin-atr.com...
Need help?
Do you have a question about the DH07 and is the answer not in the manual?
Questions and answers