Samsung PCL545RX/XAA Service Manual page 95

Loc. No. Code No. Description ; Specification
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 AA62-30013E HEAT-SINK,ES;-,A6063 EXTR,-,-,30(21) T02
..2 RZ120 2008-001097 R-FUSIBLE(S);33OHM,5%,1/2W,AC,BK,2.5X6.5
..2 0202-000187 SOLDER-WIRE FLUX;-,RS60S,D1.2,63Sn/37Pb
..2 AA99-20080N ASSY-PCB SUB,AUTO; AA95-00714A ,V
...3 CNZ102 3711-002642 CONNECTOR-HEADER;BOX,3P,1R,2.5MM,STRAIGH
...3 CNZ103 3711-002642 CONNECTOR-HEADER;BOX,3P,1R,2.5MM,STRAIGH
...3 CNZ104 3711-002642 CONNECTOR-HEADER;BOX,3P,1R,2.5MM,STRAIGH
...3 CZ101 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5
...3 CZ102 2401-001157 C-AL;33uF,20%,160V,GP,TP,12.5x20,5
...3 CZ103 2201-000516 C-CERAMIC,DISC;4.7nF,+100-0%,500V,Y5U,TP
...3 CZ104 2201-000193 C-CERAMIC,DISC;0.01nF,0.25pF,50V,NP0,TP,
...3 CZ105 2201-000516 C-CERAMIC,DISC;4.7nF,+100-0%,500V,Y5U,TP
...3 CZ106 2201-000193 C-CERAMIC,DISC;0.01nF,0.25pF,50V,NP0,TP,
...3 CZ107 2401-001513 C-AL;47uF,20%,16V,WT,TP,5x11,5
...3 CZ108 2401-001220 C-AL;4.7uF,20%,160V,GP,TP,8x11.5,5
...3 CZ109 2401-001220 C-AL;4.7uF,20%,160V,GP,TP,8x11.5,5
...3 CZ110 2201-000604 C-CERAMIC,DISC;0.056nF,+100-0%,500V,SL,T
...3 CZ111 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5
...3 CZ112 2401-000832 C-AL;220uF,20%,25V,GP,TP,8x11.5,5
...3 DZ101 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,T
...3 DZ102 0401-000005 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,
...3 DZ103 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,T
...3 DZ104 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,T
...3 DZ105 0401-000005 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,
...3 DZ106 0401-000005 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,
...3 LZ101 2701-000002 INDUCTOR-AXIAL;100uH,10%,4.2x9.8mm
...3 QZ103 0501-000283 TR-SMALL SIGNAL;KSA539,PNP,400mW,TO-92,T
...3 QZ104 0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,T
...3 QZ105 0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,T
...3 QZ106 0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,T
...3 RFZ101 2008-001086 R-FUSIBLE(S);3.3ohm,5%,2W,AG,TP,3.9x12mm
...3 RZ101 2001-000241 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M
...3 RZ102 2001-000221 R-CARBON;1.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
...3 RZ103 2003-000713 R-METAL OXIDE(S);47ohm,5%,2W,AF,TP,4x12m
...3 RZ104 2001-001100 R-CARBON(S);2.7OHM,5%,1/2W,AA,TP,2.4X6.4
...3 RZ105 2001-001139 R-CARBON(S);39KOHM,5%,1/2W,AA,TP,2.4X6.4
...3 RZ106 2001-001139 R-CARBON(S);39KOHM,5%,1/2W,AA,TP,2.4X6.4
...3 RZ107 2001-000331 R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM
...3 RZ108 2001-000241 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M
...3 RZ109 2001-000221 R-CARBON;1.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
...3 RZ110 2001-001100 R-CARBON(S);2.7OHM,5%,1/2W,AA,TP,2.4X6.4
...3 RZ111 2003-000713 R-METAL OXIDE(S);47ohm,5%,2W,AF,TP,4x12m
...3 RZ112 2003-002157 R-METAL OXIDE;220OHM,5%,2W,AG,TP,6X16MM
...3 RZ113 2003-002157 R-METAL OXIDE;220OHM,5%,2W,AG,TP,6X16MM
...3 RZ114 2003-000532 R-METAL OXIDE(S);18ohm,5%,2W,AF,TP,4x12m
...3 RZ115 2001-000832 R-CARBON;510OHM,5%,1/8W,AA,TP,1.8X3.2MM
...3 RZ116 2001-000331 R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM
...3 RZ117 2001-000258 R-CARBON;1.8KOHM,5%,1/8W,AA,TP,1.8X3.2M
...3 RZ118 2001-000258 R-CARBON;1.8KOHM,5%,1/8W,AA,TP,1.8X3.2M
...3 RZ119 2001-000554 R-CARBON;270OHM,5%,1/8W,AA,TP,1.8X3.2MM
...3 RZ121 2001-000666 R-CARBON;33OHM,5%,1/8W,AA,TP,1.8X3.2MM
...3 RZ122 2001-000019 R-CARBON(S);10OHM,5%,1/2W,AA,TP,2.4X6.4M
...3 RZ123 2003-002157 R-METAL OXIDE;220OHM,5%,2W,AG,TP,6X16MM
..2 3301-001201 CORE-FERRITE;AE,21x11x32mm,1500,280G
..2 6003-001023 SCREW-TAPTITE;RWH,+,B,M3,L10,ZPC(YEL),SW
..2 AA33-00008A MAGNET CONVERGENCE;JH92LTU-36A,7inchPRT,
ASSY-PCB,SUB
1 *AA95-00705A ASSY-PCB,SUB;,PCL545R,P54A
..2 C432 2306-000267 C-FILM,MPPF;8.2nF,5%,1.6KV,TP,28.5x18.5x
..2 C438 2306-000267 C-FILM,MPPF;8.2nF,5%,1.6KV,TP,28.5x18.5x
..2 C445 2401-001622 C-AL;6.8uF,20%,50V,BP,TP,16x25mm,7.
..2 C481 2401-002235 C-AL;10uF,20%,16V,GP,TP,5x11mm,5mm
..2 C491 2306-000322 C-FILM,MPPF;12nF,5%,1.6KV,TP,29x20.5x13,
..2 C876 2401-000787 C-AL;220uF,20%,160V,GP,TP,16x31.5mm
..2 CN202 AA39-00116A LEAD CONNECTOR-ASSY;,12P,YBNH250-12,3515
..2 CN801 AA39-00180A LEAD CONNECTOR ASSY;,14P,YBNH250-14,3515
..2 CN802 3711-003974 CONNECTOR-HEADER;BOX,12P,1R,2.5mm,STRAIG
..2 CN803 3711-003974 CONNECTOR-HEADER;BOX,12P,1R,2.5mm,STRAIG
..2 CNW801 AA39-20061G LEAD CONNECTOR-ASSY;,3P,YFH800-03,S,100M
..2 CNZ02 AA39-00115A LEAD CONNECTOR-ASSY;,10P,YBNH250-10,3515
..2 CR430S 2301-001343 C-FILM,MPPF;3.9nF,5%,2kV,TP,29x9.5x16mm,
Samsung Electronics
Remark Loc. No. Code No.
..2 CR431S 2301-001343 C-FILM,MPPF;3.9nF,5%,2kV,TP,29x9.5x16mm,
..2 CR436S 2306-000235 C-FILM,MPPF;560nF,5%,400V,TP,26*22.5*14,
..2 CR471S 2301-001091 C-FILM,MPPF;470nF,5%,400V,TP,26x21.5x14.
..2 CR473S 2306-000322 C-FILM,MPPF;12nF,5%,1.6KV,TP,29x20.5x13,
S.N.A ..2 CR474S 2306-000326 C-FILM,MPPF;4.7nF,5%,1.6KV,TP,28.5x16x9m
..2 CS803 2401-003370 C-AL;47uF,20%,450V,GP,BK,16X35.5,7.
..2 CY811S 2201-000446 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,15x
..2 CY812S 2201-000446 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,15x
..2 D464 0402-000236 DIODE-RECTIFIER;GI824,400V,5A,-,TP
..2 D811S 0402-000102 DIODE-BRIDGE;D2SB60,600V,1.5A,-
..2 IC301 AA96-50406A ASSY-H/S;-,-,AA62-30180K,LA7845,-
...3 0205-000129 GREASE-SILICON;SC102,JAPAN
...3 1204-000517 IC-VERTIVAL DEF.;LA7845,SIP,7P,-,PLASTIC
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 AA62-30180K HEAT SINK-ES;-,A6063 EXTR,-,WHT,50/13,-,
..2 IC421 1203-000165 IC-POSI.ADJUST REG.;78R12,TO-220,3P,-,-,
..2 IC430 1203-000162 IC-POSI.ADJUST REG.;317,TO-220,3P,-,PLAS
..2 IC431 1201-000191 IC-OP AMP;4558,DIP,8P,300MIL,DUAL,20V/mV
..2 IC471 1203-000610 IC-PWM CONTROLLER;494,DIP,16P,300MIL,PLA
..2 ICS801 AA13-00024A IC-HYBRID;-,TNY253P,-,8PIN,-,-
..2 ICS807 AA96-00111P ASSY H/S;-,MAIN,AA62-30013L,KA278RA05,F
...3 1203-001978 IC-VOLTAGE REGULATOR;KA278RA05,TO-220F,4
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 AA62-30013L HEATSINK-ES;-,-,-,-,44/22,-,WHT,-,-,-,-
..2 ICZ103 AA96-00034A ASSY-H/S;-,CONVERGENCE,AA62-30173D,STK3
...3 0205-000129 GREASE-SILICON;SC102,JAPAN
...3 1201-001225 IC-VIDEO AMP;392,SIP,22P,-,TRIPLE,-,PLAS
...3 6003-001021 SCREW-TAPTITE;RH,+,B,M3,L15,ZPC(YEL),SWR
...3 AA62-30173D HEAT SINK-ES;-,-,T1.0,WHITE,SCREW-HOLE(2
..2 ICZ104 AA96-00034A ASSY-H/S;-,CONVERGENCE,AA62-30173D,STK3
..2 L432 AA27-00095A COIL HORIZ. WIDTH;-,600uH,YL9N 15x27.5 C
..2 L434 AA27-00174A COILHORIZ.WIDTH;600UH,600UH,SB-5SOS6X20,
..2 L435 AA27-10001C COIL-CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
..2 L482 3301-000374 CORE-FERRITE BEAD;AA,3.5x1.0x9.0mm,-,-
..2 L494 3301-000374 CORE-FERRITE BEAD;AA,3.5x1.0x9.0mm,-,-
..2 L854 AA27-10001C COIL-CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
..2 L860 AA27-10001C COIL-CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
..2 L862 AA27-10001C COIL-CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
..2 L872 AA27-10001C COIL-CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
..2 L874 AA27-10002L COIL-CHOKE;-,24UH,K,-,2A,-,24UH-K,10X10M
..2 LC431S AA27-30003M COIL-LINEARLITY;-,5uH,OWA14x15,USRC0.1x6
..2 PC811S 0604-001032 PHOTO-COUPLER;TR,170-260%,300mW,DIP-4,ST
..2 PCB AA41-00340B PCB-SUB;PCL545R,CEM-1,1L,B,1.6T,330X24
..2 Q353 0502-000442 TR-POWER;2SC4636RB,NPN,2W,TO-220,ST,10-
..2 Q431 AA96-00033E ASSY H/S;-,H-OUT,AA62-30173C,2SC5446, F
...3 AA02-00007A MICA;DPM-04,MICA,22x29x0.15mm
...3 AA62-30173C HEAT SINK-ES;-,-,T1.0,WHITE,SCREW-HOLE(2
...3 AA60-30001A WASHER-PLATE;M3,ID3.5,15X8.5,T1.0,-,SBHG
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 0502-001175 TR-POWER;2SC5446,NPN,200000mW,TO-3PL,BK
...3 0402-001296 DIODE-RECTIFIER;FMP-3FU,1.5KV,5A,TO-3PF,
...3 0205-000129 GREASE-SILICON;SC102,JAPAN
..2 Q433 AA96-50407A ASSY-H/S;-,-,AA62-30154G,KSD73Y,-
...3 0205-000129 GREASE-SILICON;SC102,JAPAN
...3 0502-000298 TR-POWER;KSD73,NPN,30000mW,TO-220,TP,12
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 AA62-30154G HEAT SINK-ES;-,A6063 EXTR,-,WHT,50/16,-,
..2 Q441 AA96-50383F ASSY-H/S;-,-,AA62-30180D,2SD921,-
...3 0205-000129 GREASE-SILICON;SC102,JAPAN
...3 0502-001104 TR-POWER;2SD921,NPN,80W,TO-3P,BK,700-
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 AA62-30180D HEAT SINK-ES;-,A6063 EXTR.,2,WHT,50mm,-,
..2 Q473 AA96-00037A ASSY-H/S;-,-,AA62-30181N,2SC4125, IRFS6
...3 0502-001100 TR-POWER;2SC4125,NPN,70W,TO-3PML,BK,8-
...3 AA62-30181N HEAT-SINK,ES;-,-,T1.0,WHITE,SCREW-HOLE(2
...3 AA60-30001A WASHER-PLATE;M3,ID3.5,15X8.5,T1.0,-,SBHG
...3 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
...3 0505-001202 FET-SILICON;IRFS640A,N,200V,9.8A,0.18ohm
...3 0205-000129 GREASE-SILICON;SC102,JAPAN
..2 RL811S 3501-001053 RELAY-POWER;5Vdc,530mW,10A,1FormA,15mS,5
..2 RL812S 3501-001040 RELAY-POWER;12VDC,500mW,10A,1FormA,15mS,
..2 T431 AA26-50001U TRANS-HORIZ.DRIVE;-,28mH,105uH,4uH,ER28x
..2 T432 AA26-00012A TRANS-DUMMY;-,1.3MH,EER4445,110V/7.6V/21
..2 T433 AA26-00011A TRANS-DUMMY;-,3.5MH,EE2834,-,BK
..2 T444S AA26-00100A TRANS FBT;FFA97513L,CT29A7DR,0.3mH,-,-,-
..2 T461 AA26-50001V TRANS-HORIZ.DRIVE;-,6.0mH,113uH,4uH,EI19
..2 T481 AA26-00091A TRANS-HV-STORAGE;4mH,-,14P,830uH,180V,10
Electrical Parts List
Description ; Specification Remark
7-23