Page 1
Tel: ++385-31-856-637 Tel/fax: ++385-31-856-139 Mob: 098-788-319 www.rtv-horvat-dj.hr COLOR TELEVISION RECEIVER COLOR TELEVISION RECEIVER Chassis : KS3A(P) (REV. 2) Model : CS29A5HT8X/BWT CS29A5HT8X/NWT CS29A5HT8X/VWT CZ21A8VW8X/ELS CONTENTS Precautions Reference Information Specifications Alignment and Adjustments Troubleshooting Exploded Views and Parts List Electrical Parts List...
The current measured should not exceed 0.5 milliamp. Reverse the power- plug prongs in the AC outlet and repeat the test. Samsung Electronics DEVICE UNDER TEST TEST ALL EXPOSED METAL...
Page 3
) or ( Use replacement components that have the same ratings, especially for flame resistance and dielectric strength specifications. A replacement part that does not have the same safety characteristics as the original might create shock, fire or other hazards. Samsung Electronics...
Make sure that the portion around the serviced part has not been damaged. Samsung Electronics 5. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks).
Page 5
9. Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together, or lifting a foot from a carpeted floor can generate enough static electricity to damage an ESD. Samsung Electronics...
Henry Hertz Hour Inches Per Second Kilowatt-hour Kilogram Kilohertz Kilohm Kilometer km/h Kilometer Per Hour Kilovolt Kilovolt-ampere Kilowatt Liter Megahertz Samsung Electronics Table 2-1 Abbreviations µA µF µH µm µs µW Reference Information Megavolt Megawatt Megohm Meter Microampere Microfarad Microhenry...
Page 7
Test Point Transistor Transistor Logic Television Ultra High Frequency Underwriters Laboratories Ultraviolet Variable-Capacitance Diode Voltage Controlled Oscillator VCXO Voltage Controlled Crystal Oscillator Very High Frequency Video Intermediate Frequency Variable Resistor Video Tape Recorder VTVM Vacuum Tube Voltmeter Transistor Samsung Electronics...
Page 9
TR-Power (TILT) KSD2073-H2 KA4558 OP-AMP (TILT) KA4558 OP-AMP 2SC4636RB TR-Power Video Switching IC with Adder Output TEA6425 High-end Picture-In Picture IC SDA9489X 3.3V Regulator EZ1086CM REMARK Refer to Table 2-3-6 Refer to Table 2-3-7 Option Option Option Option Samsung Electronics...
Page 10
SPEC TCLS3101PD09A(S) CS with LNA Function TCPS3001PD09D(S) TCPS3001PD09E(S) Note TCPS3001PD09A(S) is out-of-date, TCPS3001PD09D(S) which is up-to-date has the same function. Table 2-3-5 2’nd TUNER (TU02S) SPEC TCPS3000PC09B(S) Samsung Electronics FUNCTION FUNCTION FUNCTION FUNCTION FUNCTION Reference Information REMARK REMARK REMARK REMARK...
Page 11
Reference Information Table 2-3-6 TRANS SPEC 29” FUJ-29B001 FUH-29A001B 21” Table 2-3-7 TRANS FLYBACK (FBT) SPEC AA26-00046A 29” 21” AA26-00044C FUNCTION FUNCTION REMARK REMARK Samsung Electronics...
3. Adjust the Brightness and contrast controls to both extremes. Ensure that the high voltage does not exceed 32 KV under any conditions. Samsung Electronics 5. Avoid overload. Excessive signal from a sweep generator might overload the front-end of the TV. When inserting signal markers, do not allow the marker generator to distort test results.
Page 15
For example, when the value of “Red Cutoff” is 127, change the value to 128 and restore the value to 127. If you do not follow this procedure, the picture may be abnormal. For example, when the TV set is on, the picture becames brighter gradually. Samsung Electronics Alignment and Adjustments...
Page 16
7. Adjust CA-100 so that the final adjustment value can be fixed. 8. Use the Channel Up/Down ( / ) buttons to move the cursor on the adjustment modes. 9. Use the Volume +/- buttons to change the adjustment value. Samsung Electronics...
Page 17
- After the Service adjustment is completed, Do not select “Reset” in the service mode menu. (After above procedure is done, power is on initially and the “Plug and Play” will be operated.) Samsung Electronics MENU FACTORY These hexa digits are check sum value which depends on the MICOM.
Page 18
Adjust PIP Tinit Adjust PIP Vertical Position (Main Picture is PAL) Adjust PIP Vertical Position (Main Picture is NTSC) Adjust PIP Horizontal Position Adjust PIP Green Cutoff Level Fixed Value Remark Not to be adjusted Not to be adjusted Samsung Electronics...
Page 19
4-8-2(B) SCREEN CHANGE (I2C BUS GEOMETRIC ADJUSTMENT) V Shift V Slope H EW H Parabola H Corner Samsung Electronics Alignment and Adjustments V Amp V SC H Trapizium H Symmetry H Shift...
Page 20
Adjust Tint Adjust Beam Control Limit Refer to Note 3 Adjust OSD/TTX Contrast Refer to Table 1 BCL GAIN Def. Low Light High Light Low Light High Light Not to be adjusted SECAM Def. Samsung Electronics Fixed Value Remark NTSC...
Page 21
Note 4. Soft Limit & Hard Limit Output Part 1 Part 2 Slope 1 [0...15] tilt 1 [0...511] tilt 2 [0...511] Samsung Electronics Initial Function Value Black Stretch Threshold Black Stretch Tilt Position Black Stretch Amount Luma Peaking Filter Coring...
Page 22
Not used this mode for KS3A Chassis Fixed Value Remark OSD Language Depending on IC601 Refer to Note 5 S:S-VHS, D:DVD When PIP is “2-Tuner”, set to “ON” Without “TV/VIDEO” key in the front panel, set to “On” IC601 Samsung Electronics...
Page 23
H 16:9 Parabola TTX H Shift -30 ~ 30 BG/DK/I/M Mono Sound System V Slice Level 0 ~ 3 Melody Volumn 0 ~ 20 Samsung Electronics CS29A6PF8X/HAC Initial Vaue Arab Arab V-Dolby 2 RCA + S 2-Tuner Farsi 85 DC 5E...
Page 24
Stand-By LED Time LED 4-12 Tilt N.C. Power Sound Mute N.C. N.C. PX. Y PX. Y VDD 3.3V VDD 2.5V CORE OSD-B OSD-G OSD-R VDD 2.5V X-TAL Out X-TAL In MICOM Reset N.C. N.C. VDD 3.3V N.C. Relay Samsung Electronics...
Page 25
SC2-ID Key1 H-Sync V-Sync Key3 Key2 X-Ray IR-In STD-LED TIM-LED Samsung Electronics IN/OUT ACTIVE H/L Alignment and Adjustments DESCRIPTION EEPROM Write Protection EEPROM Serial Data Line EEPROM Serial Clock Line Disable Micom IIC Peripheral IC Serial Data Line Peripheral IC Serial Clock Line...
Page 26
OSD/TTX Output (Red) OSD/TTX Output (Green) OSD/TTX Output (Blue) Fast Blank/Half Contrast Output When The Caption Function Adopted, Used. Not Used (Programmed Gound Level) Sound Amp Mute Picture On/Off Control Not Used (Programmed Gound Level) Tilt Control Output Samsung Electronics...
Page 27
Abnormal Check MICOM IIC #5, #6 Check Level Shifter Q909, Q910 Output(If 2N7000 Output has the DC Component over 0.7V, it is broken) Abnormal Normal Check Abnormal Replace MICOM Q909, Q910 IIC #2, #3 Normal Check Replace IC902 EEPROM EEPROM(IC902) IC802, IC803 Normal Check IC201S...
Page 28
Normal Check Normal Abnormal CRT PCB RK, BK, GK Check Check Abnormal HIC202, HIC203, Heater Voltage HIC204 Output Normal Check CRT and FBT Normal Check CRT and FBT Check 200V, 16.5V Line No Picture, but sound is in normal operation Turn the VR of FBT, higher screen voltage and Check the Deflection Abnormal...
5-3 No Sound Normal Check the Speaker Wire Connection Samsung Electronics No Sound, but Picture is in normal operation Check the CN602 Connection and Signal Normal Check IC602 #7 (If the pin is in low state, Sound is mute) Normal...
Page 48
Schematic Diagrams 10-2 MAIN 2 TP12 TP11 10-2 TP13 TP14 TP25 TP15 Samsung Electronics TP11 TP12 TP13 TP14 TP15 TP25 : Power Line : Signal Line...
Page 49
10-3 MAIN3 TP23 TP17 TP16 TP18 TP19 Samsung Electronics TP22 TP21 TP20 TP24 RTV servis Horvat Tel: ++385-31-856-637 Tel/fax: ++385-31-856-139 Mob: 098-788-319 www.rtv-horvat-dj.hr Schematic Diagrams TP22 TP16 TP23 TP17 TP24 TP18 TP19 TP20 TP21 : Power Line : Signal Line...
Page 50
Schematic Diagrams 10-4 MAIN 4 TP26 TP27 TP28 TP29 TP30 10-4 TP33 TP32 TP31 TP32 TP26 TP33 TP27 TP35 TP34 TP28 TP35 TP29 TP34 TP30 TP31 : Power Line : Signal Line Samsung Electronics...
Page 51
Schematic Diagrams 10-5 PIP : Power Line Samsung Electronics 10-5...
Page 52
Schematic Diagrams 10-6 CRT, SIDE AV, VIDEO SWITCH 10-6 SIDE AV VIDEO SWITCH : Power Line : Signal Line Samsung Electronics...
Page 53
10-7 DOUBLE FOCUS, CONTROL DOUBLE FOCUS Samsung Electronics CONTROL RTV servis Horvat Tel: ++385-31-856-637 Tel/fax: ++385-31-856-139 Mob: 098-788-319 www.rtv-horvat-dj.hr Schematic Diagrams : Power Line 10-7...