Table of Contents
Advertisement
Quick Links
Owner's Instruction and Operation Manual
Model Number:
SWF1035
Report Number: 22-808
Certi ed to UL-391-2006 (R2019), Certi ed to:
CSA B366.1-11 (R2020), and CSA B415.1:22
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
SAFETY NOTICE: If this unit is not properly installed, a re may result. For your safety, follow
the installation instructions. Never use make-shift compromises during the installation of
this unit. Contact local building or re of cials about permits, restrictions and installation
requirements in your area.
CAUTION! Please read this entire manual before you install or use this unit. Failure to
follow instructions may result in property damage, bodily injury, or even death. Improper
Installation Will Void Your Warranty!
U.S. Environmental Protection Agency
Certi ed to comply with 2020 particulate
emission standards
© 2023 Breckwell Hearth, South Pittsburg, TN 37380
R
Save These Instructions In A Safe Place For Future Reference.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
Wood Only Central Furnace
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to
www.breckwell.com
853981C - 0406M
www.P65warnings.ca.gov
PH. 423-403-4031
Advertisement
Table of Contents
Related Manuals for Breckwell SWF1035
Summary of Contents for Breckwell SWF1035
- Page 1 State of California to cause cancer, birth defects, and/or other reproductive harm. For emission standards more information, go to www.P65warnings.ca.gov THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE. © 2023 Breckwell Hearth, South Pittsburg, TN 37380 www.breckwell.com PH. 423-403-4031...
- Page 2 INTRODUCTION This manual describes the installation and operation of the Breckwell, SWF1035 wood furnace. This furnace meets the 2020 U.S. Environmental Protection Agency’s emission limits for wood furnaces. Under speci c EPA test conditions this furnace has been shown to deliver heat at a rate of 15,997 – 53,042 BTU/hr. This furnace achieved a particulate emissions rate of 0.13 lb/mmBtu when tested to method CSA B415.1-10 (*and an overall ef ciency of 70%).
-
Page 3: Installation Checklist
-pro/ CUSTOMER SERVICE For customer service, please contact your Breckwell dealer or visit www.Breckwell.com COMMISSIONING CHECKLIST This checklist is to be completed in full by the quali ed person who installs this unit. Keep this page for future reference. -
Page 4: Tools And Materials
(see illustration for proper ber board arrangement). NOTE: The ceramic ber boards are silicone into place to prevent damage from shipping. Attempting to remove the ceramic ber board before operation could result in damage. © 2023 Breckwell Hearth... - Page 5 OUTSIDE VIEW OF THE UNIT Use two (2) 1/4-20 x 3/4 bolts and two (2) washers to secure the latch assembly to the unit. INSIDE VIEW OF THE UNIT © 2023 Breckwell Hearth...
- Page 6 Use the four (4) provided #10A x 1/2 screws to secure the front cover hood to the unit as shown. JUNCTION BOX & FAN CENTER Secure the junction box to the junction box bracket using the two (2) provided #10A x 1/2 screws as shown. © 2023 Breckwell Hearth...
- Page 7 Secure the lter box to the unit using a total of ten (10) #10 A x 1/2 HX screws, ve (5) on each side. HONEYWELL PROBE Install the Honeywell probe into the ducktwork above the unit. NOTE: The conduit is supplied at a predetermined length of approximately 3 feet © 2023 Breckwell Hearth...
-
Page 8: Air Filter Replacement
ASSEMBLY INSTRUCTIONS AIR FILTER REPLACEMENT Insert one 16 x 24 x 1 air lter (not included). © 2023 Breckwell Hearth... -
Page 9: Installation
CAUTION CAUTION: GASES THAT ARE DRIVEN FROM FRESH WOOD MUST BE BURNED OR THEY WILL ACCUMULATE AND EXPLODE. HOT SURFACES! KEEP CHILDREN AWAY. DO NOT TOUCH NEVER SMOTHER A FIRE WHEN ADDING FRESH WOOD. DURING OPERATION. © 2023 Breckwell Hearth... -
Page 10: Floor Protector
Ceiling H (First 6ft) CLEARANCES TO COMBUSTIBLES The installation of this furnace includes supplying electrical power, return air ductwork, and supply air ductwork. This furnace may be installed as a stand alone wood furnace Floor Protector © 2023 Breckwell Hearth... -
Page 11: Stand Alone Installation
Draft is the force which moves air from the appliance up through the chimney. The amount of draft in your chimney depends on the length of the chimney, local geography, nearby obstructions and other factors. Too much draft may cause excessive temperatures in the appliance. Inadequate © 2023 Breckwell Hearth... -
Page 12: Masonry Chimney
Make sure there are no cracks, loose mortar or other signs of deterioration and blockage. Have the chimney cleaned before the furnace is installed and operated. When connecting the furnace © 2023 Breckwell Hearth... -
Page 13: Chimney Connector
Seal the joints with furnace cement. chimney section on both sides with 24 gage minimum sheet The pipe must be short and straight. All sections installed metal supports. See that the supports are fastened securely © 2023 Breckwell Hearth... -
Page 14: Factory Built Chimney
Maintain proper clearance to the structure as recommended by the manufacturer. The chimney must be the required height above the roof or other obstructions for safety and proper draft operation. © 2023 Breckwell Hearth... -
Page 15: Operation
It is EXTREMELY hardwoods, as compared to softwoods or too green or © 2023 Breckwell Hearth... -
Page 16: Testing Your Wood
CAUTION: EFFICIENCIES DO NOT LEAVE APPLIANCE UNATTENDED WITH THE DOOR OPEN. Ef ciencies can be based on either the lower heating value © 2023 Breckwell Hearth... - Page 17 ON and its damper is closed, then longer burn time as this would allow the combustion fan pull the knob/loop on the front of the unit to prop open to remain OFF for longer periods. A higher thermostat the barometric dampers. © 2023 Breckwell Hearth...
- Page 18 Use the included moisture meter to ensure your wood has a 20% or less moisture content. © 2023 Breckwell Hearth...
-
Page 19: Maintenance
COMPLETE CHIMNEY INSPECTIONS AND CLEANING SHOULD BE CONDUCTED ANNUALLY; TYPICALLY, THIS TASK SHOULD BE PERFORMED PRIOR TO EACH HEATING SEASON. IF USING AN EXISTING CHIMNEY, IT MUST BE INSPECTED PRIOR TO THE INSTALLATION OF YOUR NEW WOOD STOVE. © 2023 Breckwell Hearth... - Page 20 CO monitors in areas having the potential to Operate the furnace at a high enough re to keep the generate CO. chimney warm, preventing this condensation. © 2023 Breckwell Hearth...
-
Page 21: How To Order Repair Parts
Other information that may be needed would be the part number and part description of the item(s) in question. Part numbers and descriptions can be found in the “Repair Parts” section of this manual. Once this information has been gathered you can contact your Breckwell dealer or visit www.Breckwell.com Model Information Model Number Dealer’s Name... -
Page 22: Electrical Installation
ELECTRICAL INSTALLATION © 2023 Breckwell Hearth... -
Page 23: Repair Parts
Contact your dealer or installer for parts and service. IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM THE APPLIANCE MANUFACTURER. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2023 Breckwell Hearth... - Page 24 Contact your dealer or installer for parts and service. IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM THE APPLIANCE MANUFACTURER. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2023 Breckwell Hearth...
-
Page 25: Service Record
Engineer Name: _________________________________ Engineer Name: _________________________________ License No.: _____________________________________ License No.: _____________________________________ Company: ______________________________________ Company: ______________________________________ Telephone No.: __________________________________ Telephone No.: __________________________________ Stove Inspected: Chimney Swept: Stove Inspected: Chimney Swept: Items Replaced: __________________________________ Items Replaced: __________________________________ © 2023 Breckwell Hearth... - Page 26 NOTES © 2023 Breckwell Hearth...
- Page 27 NOTES © 2023 Breckwell Hearth...
Need help?
Do you have a question about the SWF1035 and is the answer not in the manual?
Questions and answers