Page 1
ropins Installation Guide and Users Manual...
Page 2
By registering your appliance, you will have easy and accurate access to: • Technical Support ZLINE is fueled by a passion for innovation; A relentless pursuit of bringing the highest end • Warranty Service luxury designs and professional features into everyone’s homes. Because we continually strive •...
Page 3
COVERAGE WHAT IS NOT COVERED ZLINE Kitchen and Bath range products will be warrantied for one year from the Installation or start-up, damages or problems caused by improper installation or original purchase date for the original purchaser of the product. This warranty covers use.
TABLE OF CONTENTS IMPORTANT SAFETY INSTRUCTIONS IMPORTANT SAFETY INSTRUCTIONS An air curtain or other overhead range/cooktop hood, which operates by blowing downward airflow onto the range, shall not be WARNING WARRANTY AND SERVICE used/installed in conjunction with this gas range. PRODUCT DIMENSIONS •...
• Do not store or use gasoline or any other flammable substances in the vicinity of Replacement parts are available from ZLINE. Call 1-614-777-5004. this or any other appliance. • NEVER use this appliance as space heater to heat or warm the room. Doing so 30“...
BEFORE INSTALLATION BEFORE INSTALLATION • This appliance shall only be installed by an authorized professional. ROOM VENTILATION • The appliance shall be installed in accordance with the standards of the country An exhaust fan may be used with the appliance; in each case it shall be installed where it will be installed.
INSTALLATION INSTALLATION INSTALLATION ADJACENT TO KITCHEN CABINETS ATTACHING THE DROPIN For the best look, the worktop should be level with the cabinet countertop. To prevent liquids from accidentally leaking into the underlying storage space, the appliance is equipped with a special gasket. To apply this gasket, carefully follow the instructions in Fig.
INSTALLATION INSTALLATION The appliance shall be connected to a single phase electric line rated at 1 10-120Vac GAS CONNECTION and 60Hz frequency. The true voltage in most homes is usually between these values. • All gas connections must comply with national and local codes. The gas supply line (service) must be the same size or greater than the inlet line of the appliance.
Page 9
INSTALLATION INSTALLATION MANUAL SHUT-OFF VALVE PRESSURE REGULATOR • This valve is not shipped with the appliance and must be provided by the Since service pressure may fluctuate with local demand, every gas cooking installer. appliance must be equipped with a pressure regulator on the incoming service line •...
INSTALLATION INSTALLATION GAS CONVERSION PROCEDURE STEP 1: PRESSURE REGULATOR The gas conversion procedure for this range includes: The pressure regulator supplied with the appliance is a convertible type pressure 1. Pressure Regulator regulator for use with Natural Gas at a nominal outlet pressure of 4˝ w.c. or LP gas 2.
Page 11
INSTALLATION INSTALLATION STEP 3: FLAME ADJUSTMENT STEP 2: SURFACE BURNERS Light one burner at a time and set it to the MINIMUM position (small flame). To replace the nozzles of the surface burners, lift up the burners and unscrew the 2.
INSTALLATION INSTALLATION INSTALLATION CHECKLIST ROOM VENTILATION Is the range mounted on its legs? The use of a gas cooking appliance generates heat and humidity in the room where 2. Is the back guard securely connected? it is installed. Proper ventilation in the room is needed. Make sure the kitchen is 3.
Page 13
OPERATION OPERATION SURFACE BURNER OPERATION - ELECTRIC IGNITION Be sure to set all worktop/oven/broiler burner controls to the OFF position after each use of the appliance. To activate the electric ignition, simply turn the control knob counter-clockwise to maximum power, then press the knob in to start the flow of gas and the ignition spark. The spark will be released at the metal tip of the white ceramic pin located on the side of the burner.
MAINTENANCE AND CLEANING TROUBLESHOOTING CLEANING YOUR RANGE RANGE PROBLEM POSSIBLE CAUSE AND/OR REMEDY During cleaning operation, never move the appliance from its original Igniters are not sparking Rangetop is not connected to electrical power. installation position. Never use abrasive cleaners! Scratches on the stainless Check power circuit breaker, wiring, and fuses.
Page 15
Installation Guide and User Manual 2.0.0 1-614-777-5004 contact@zlinekitchen.com www.zlinekitchen.com...