Page 1
INSTRUCTION MANUAL FOLDABLE SAWHORSE MODEL NO: THBSH -- PRODUCT NO: 193833002 EN - ORIGINAL INSTRUCTIONS SAVE THESE INSTRUCTIONS ASSEMBLY REQUIRED FOR YOUR SAFETY Please read & understand this manual, paying attention to the safety instructions, before use. Incorrect use of the product could put the operator or machine in danger.
CONTENTS SPECIFICATIONS IMPORTANT INFORMATION GENERAL SAFETY INSTRUCTIONS SET UP & PREPARATION FOR OPERATION ASSEMBLY OPERATION MAINTENANCE & CLEANING SERVICE HINTS PARTS DIAGRAM & LIST WARRANTY Assembly is required – Two pairs of hands will make assembly easier. This product requires assembly before use. See the “Assembly” section for instructions. Please check that all parts required for the assembly of this spreader are included.
Weight 5.5kg Consistent with our policy of continuous improvement, The Handy reserves the right to change the design and configuration of any of its products without notice or obligation. Therefore, please treat the text and images in this manual for illustrative purposes only. They may in no case serve as a basis for any legal claim.
GENERAL SAFETY INSTRUCTIONS It is important that you read and understand the owner’s manual and labels affixed to the machine. Learn its application and limitations as well as the specific potential hazards. Retain these instructions for future reference. The operator is responsible for following the warnings & instructions in this manual and on the product.
Page 6
tool. Carrying cutting power tools with your finger on the switch or energizing power tools that have the switch on, invite accidents. d) Remove any adjusting key or wrench before turning the cutting power tool on. A wrench or a key left attached to a rotating part of the cutting power tool, may result in personal injury.
Page 7
PERSONAL SAFETY DANGER RISK OF SUFFOCATION Small parts can be easily swallowed. There is also a risk that polybags can suffocate toddlers. Keep all bystanders and animals away when you assemble the product. Dispose of the polybag responsibly. Know how to stop cutting machine quickly in an emergency. Only work in the daylight or when visibility is good.
SET UP & PREPARATION FOR OPERATION Remove the machine and contents from the carton. Be sure the carton is empty before discarding. If you require any assistance with regards to the contents or operation of your machine, please contact us: Tel: 01793 333212.
Page 9
ASSEMBLY The sawhorse is supplied with Nylock Nuts. They are designed using a nylon collar, with a slightly smaller diameter to the bolt. The insert deforms elastically over the threads of the screw/bolt, but threads are not cut into the nylon. The nylon insert locks the nut by applying a compressive force against the bolt. Initially, assemble with the fixings loosely tightened and then ensure that you completely tighten the construction, prior to use.
Page 10
Images may differ slightly from actual product. • Secure the shorter cross strut (80cm) to the left and middle leg assembly bottom fixing hole. • Use 2x M6x12 bolt, 4x M6 washer and 2x M6 nut. • Ensure the screw is located on the outside of the leg assembly.
Page 11
• Secure to the middle leg, using the 2nd hole from the floor, securing with M6x12 bolt, 2x M6 washer and M6 nut. • Ensure the screw is located on the outside of the leg assembly. • A washer should be placed either side of the hole.
Page 12
OPERATION WARNING The correct assembly of this item is essential, for both your personal safety and to guarantee product satisfaction. We cannot be held responsible for any accident resulting from improper or irresponsible use of this product. It is essential that this item is inspected before use and maintained in accordance with these instructions. Always make sure that all bolts are tight and secure before you attempt to use this item.
Page 13
(if applicable), failure to do so will invalidate the 2nd year of the warranty. Webb Dynamic, Heritage & Legacy, The Handy (All non-Petrol & Electric), Mowerland, Q-Garden a) 1 year from the original date of sale to the first domestic user.
Page 14
Disclaimer a) This warranty is only a remedy for defect of products. GJ Handy (Trading) Ltd will never warranty in terms of the merchantability or the fitness for a particular purpose. b) No person is authorised to make any warranties, representations or promises, expressed or implied, on behalf of GJ Handy (Trading) Ltd, or to modify the terms conditions or limitation of this warranty policy in any way.
Page 16
For spares or support of your handy product, please contact us: Tel: 01793 333212 Email: customerservice@handydistribution.co.uk Opening Hours Weekdays: February to October 8:00am - 5:00pm November to January 8:30am - 5:00pm (CLOSED WEEKENDS & BANK HOLIDAYS) To see our range of garden machinery & equipment visit: www.thehandy.co.uk Making gardening easier &...
Need help?
Do you have a question about the THBSH and is the answer not in the manual?
Questions and answers