Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Summary of Contents for OFF GRID TRAILERS EXPEDITION 2.0
- Page 1 TRAILER OWNERS MANUAL...
-
Page 2: Table Of Contents
OGT team’s passion for design, quality, authenticity, and DOOR OPERATION MAINTENANCE craftsmanship are only matched by their love of the outdoors - a love that guides everything we do at Off Grid Trailers. Our TOWING YOUR TRAILER off-road teardrop trailers are inspired by overlanding and off grid camping-they’re designed for engaging with nature,... -
Page 3: Quick Set-Up Guide
QUICK SET-UP GUIDE ITEMS REQUIRED (not supplied) • For Standard coupler: 2” hitch ball and ball mount • For Max Coupler: 2” receiver with ball mount 1” shank hole • Tow vehicle 7 pin wiring & brake controller • Trailer license plate & registration (or trailer transport permit) •... -
Page 4: Hooking Up The Trailer
HOOKING UP THE TRAILER When loading your trailer, store heavy gear first, keeping it on or close to the camper floor. Distribute items to keep the loaded trailers tongue weight within 12-15% of the loaded trailer weight. Only store light items on high shelves. Distribute weight to obtain even side-to-side balance of the loaded vehicle. -
Page 5: Door Operation Maintenance
HOOKING UP THE TRAILER DOOR OPERATION & MAINTENANCE Expedition and Pando Models: Your Off Grid Trailer is equipped The 7-pin trailer harness provides connection to your vehicles with RV grade side entry doors. Depending on model purchased turn signals, brake lights, running lights, brake control as well you may have either of the following versions below. - Page 6 DOOR OPERATION & MAINTENANCE APPENDIX PLUMBING Fig 2.1 Pando Door Fig 2.2 Pando Door...
- Page 7 NOTE: Location of equipment manual. The drain cock is located near the freshwater tank. EXPEDITION 2.0 31 GAL described in this section varies between trailer models, refer to...
- Page 8 PLUMBING APPENDIX Fig 3.1 Expedition & Pando Fig 3.6 Switchback Water Fill Fig 3.2 Expedition & Pando Fig 3.7 switchback water tank drain valve access panel Fig 3.8 Switchback valve access panel (open) STANDARD Fig 3.3 Switchback OPTIONAL Fig 3.9 Pando water tank drains MAIN HOT WATER DRAIN PLUG...
-
Page 9: Electrical System
ELECTRICAL SYSTEM (where equipped) Ref. Fig 5.1, 5.2, 5.3, 5.4, 5.5, 5.6 SHORE POWER CHARGING To charge via shore power, simply plug a standard 15-amp power cord into the exterior mounted shore power port and plug in electrical power source. NOTE: The base unit is NOT equipped with an on board solar charge controller. -
Page 10: Propane System
• Never fill with natural gas. • Remove tanks from camper before filling. • Never fill to more than 80% capacity. EXPEDITION 2.0 • DO NOT tow the trailer with wall mounted tanks in position. • Always perform a trailer walkaround inspecting for propane... - Page 11 ELECTRICAL APPENDIX Fig 5.3 Switchback Rear Switch Panel Fig 5.1 Interior - Expedition and Pando main elec panel Fig 5.2 Switchback Front switches Fig 5.4 Electrical...
-
Page 12: Appliance Operating Instructions
Trailers unit you own, please refer to the individual component manufacturer’s warranty/manual for specific operating instructions (included in your Off Grid Trailers warranty pouch). For the Propex HS2211 unit, access to the heater reset switch is located on the interior of the side mounted aluminum box. - Page 13 Trailers unit you own, please refer to the individual component Propex Approved Service Centre / Technician. manufacturer’s warranty/manual for specific operating instructions and winterizing (included in your Off Grid Trailers warranty/manual pouch). GAS LOCKOUTS Gas lockouts must be cleared by turning the selector knob from...
-
Page 14: Safety Tips
Since models may vary depending on the type of Off Grid Trailers unit you own, please refer to the individual component Temperature Indicator manufacturer’s warranty/manual for specific operating Increase Temperature instructions (included in your Off Grid Trailers warranty pouch). Burner LED Decrease Temperature Reset Button SAFETY TIPS... - Page 15 Since models may vary depending on the type of Off Grid Trailers unit you own, please refer to the individual component manufacturer’s warranty/manual for specific operating instructions (included in your Off Grid Trailers warranty pouch). Use guy ropes to stake and secure your awning to the ground at all times.
- Page 16 FRAME, SUSPENSION, Fig 8.8 Pando Tent Up Fig 8.9 Pando Shower BRAKE, BEARINGS, WHEELS & Fig 8.10 Pando Shower & Tent TIRES Fig 8.6 Top plug shore power Fig 8.7 TV Lower plug solar ready...
-
Page 17: Frame, Suspension, Brake, Bearings, Wheels & Tires
If damage or cracks are found or suspected have warranty/manual for specific operating and maintenance the trailer inspected and repaired by a qualified RV technician. instructions (included in your Off Grid Trailers warranty pouch). SUSPENSION The brake system on your trailer is controlled by a brake... - Page 18 FRAME, SUSPENSION, BRAKE, BEARINGS, WHEELS & TIRES WHEELS & TIRES APPENDIX Off road travel increases the chance of wheel and tire damage; frequently check you trailer tires and wheels for damage, especially if traveling off road. Note that wheel/tires over 33 inches may cause interference in an overloaded trailer.
-
Page 19: Winterizing
For additional support reference support.offgridtrailers.com IMPORTANT Hot water heater located outside the unit, may vary depending NOTE: on the type of Off Grid Trailers unit you own. The Hot water heater heat exchanger is the most prone to freezing. -
Page 20: General Maintenance
GENERAL MAINTENANCE INTERIOR MAINTENANCE TIPS • All Off Grid Trailers have been designed to be compatible with mild cleaning agents, so each unit’s appearance and quality can be maintained. • All the cushions used in the manufacturing process are foam backed and therefore can be professionally cleaned. - Page 21 MAINTENANCE NOTES MAINTENANCE SCHEDULE DATE MAINTENANCE PERFORMED NOTES...
- Page 22 MAINTENANCE NOTES MAINTENANCE NOTES DATE MAINTENANCE PERFORMED NOTES DATE MAINTENANCE PERFORMED NOTES...
- Page 23 (10) days after the discovery of such defects and must contain a notice through an appointment. written description of the defect and the Vehicle Identification Number Off Grid Trailers LP. reserves the right to change any components used in production at their discretion. of the Trailer.
-
Page 24: Trailer Image Appendix
Off Grid Trailers LP. APPENDIX If you are in the area, warranty and special repairs can also be done at Off Grid Trailers LP facility but remember to call ahead for an appointment so as not to inconvenience you or our production staff. - Page 25 EXPEDITION 2.0 PANDO 2.0 WATER HEATER / OPTIONAL FURNACE MAIN FUSE/ POWER SHUT OFF WATER HEATER / OPTIONAL FURNACE MAIN FUSE/ POWER SHUT OFF FUSE BOX INVERTER FUSE BOX INVERTER WATER FILL BATTERIES CHARGER / CHARGER PORT BATTERIES CHARGER / CHARGER PORT...
- Page 26 SWITCHBACK SWITCHBACK MAIN FUSE/ POWER SHUT OFF MAIN FUSE/ POWER SHUT OFF FUSE BOX FUSE BOX INVERTER INVERTER HOT WATER HOT WATER DEMAND DEMAND SYSTEM SYSTEM 20lb 20lb PROPANE TANK PROPANE TANK OPTIONAL SIDE GALLEY KITCHEN REAR OPTIONAL GALLEY KITCHEN SLIDE OUT FRIDGE SLIDE OUT FRIDGE...
- Page 27 OFFGRIDTRAILERS.COM | (800) 786-3211...
Need help?
Do you have a question about the EXPEDITION 2.0 and is the answer not in the manual?
Questions and answers
Hi, Can you tell me how the tongue weight of a 2022 Expedition 2.0 is determined & published to be "290 lbs"?? I put a scale under the point where the trailer pins to my Jeep, on the Max Coupler, and put all the tongue weight on it, it reads closer to "400 lbs". This is w/ the trailer completely unloaded and w/ the spare tire removed from the front mount. That is a pretty big discrepancy. Maybe w/ the water tank full, (which it wasn't when I weighted it), it puts more weight on the back of the trailer, balancing it better, and lifting some off the tongue?? Thanks in advance.
The tongue weight of the 2022 OFF GRID TRAILERS Expedition 2.0, published as 290 lbs, is determined based on the trailer's design and load distribution. It is specified on the trailer certification label, which is located on the left side of the trailer on the A-frame/tongue. This label provides key weight ratings, including tongue weight.
This answer is automatically generated