Table of Contents
Advertisement
Quick Links
P/N 127029-01 Rev. C 05/2016
P127029-01
This book is valuable. In addition to instructing you on how to install and maintain your appliance, it also
contains information that will enable you to obtain replacement parts or accessory items when needed. Keep
it with your other important papers.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury
or property damage. Refer to this manual for correct installation and operational procedures. For as-
sistance or additional information consult a qualified installer, service agency or the gas supplier.
This fireplace is approved for use on an outdoor application provided that a certified gas log set approved under
the ANSI Z21.97 standard with a maximum input rate of 40,000 BTU's is used. An IHP hood must be installed
when using a vent-free log heater (see Parts, page 15).
DO NOT INSTALL THE APPLIANCE IN THIS FIREBOX, UNLESS THIS FIREBOX MEETS THE MINIMUM DIMEN-
SIONS REQUIRED FOR THE INSTALLATION.
WARNING: FOR USE ONLY WITH A LISTED, GAS-FIRED UNVENTED DECORATIVE ROOM HEATER NOT TO
EXCEED 40,000 BTU/H.
DO NOT BUILD A WOOD FIRE.
WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result
causing property damage, personal injury or death.
— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other
appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Leave the building immediately
• Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire department.
— Installation and service must be performed by a qualified installer, service agency or the gas supplier.
PFS
®
US
Report No. F09-130
SAVE THIS BOOK
Installation and Operation Instructions
Universal Outdoor Vent-Free Firebox
With Refractory Panels
Models
VRE4536RS
VRE4542RS
VRE4536WS
VRE4542WS
VRE4536RH
VRE4542RH
VRE4536WH
VRE4542WH
VRE4550RS
VRE4550WS
VRE4550RH
VRE4550WH
Advertisement
Table of Contents
Related Manuals for Superior Fireplaces VRE4536RS
Summary of Contents for Superior Fireplaces VRE4536RS
- Page 1 Installation and Operation Instructions Universal Outdoor Vent-Free Firebox With Refractory Panels Models VRE4536RS VRE4542RS VRE4550RS P/N 127029-01 Rev. C 05/2016 VRE4536WS VRE4542WS VRE4550WS ® VRE4536RH VRE4542RH VRE4550RH VRE4536WH VRE4542WH VRE4550WH Report No. F09-130 P127029-01 SAVE THIS BOOK This book is valuable. In addition to instructing you on how to install and maintain your appliance, it also contains information that will enable you to obtain replacement parts or accessory items when needed.
-
Page 2: Table Of Contents
Thank you for your purchase. We appreciate your TABLE OF CONTENTS business! Safety ..................... 2 Please carefully read and follow all instructions in this manual. Pay Local Codes ................... 3 special attention to all warnings and safety information. Product Features ................3 Following these safety, care, and operation instructions will help Requirements for the Commonwealth of Massachusetts.... -
Page 3: Local Codes
SAFETY Continued State of Massachusetts: The installation must be made by a licensed plumber or gas fitter in the Commonwealth of 1. Do not use this firebox as a wood burning fireplace. Use only Massachusetts. decorative unvented room heaters (log sets). 2. -
Page 4: Product Specifications
36" MODELS " 29" 19" " " (Ref.) " " " " 36" HEARTH " " 50" 30" " " " 7" " 36" " " " Figure 1 - 36" Models - VRE4536RS, VRE4536WS, VRE4536RH and VRE4536WH Superiorfireplaces.US.com 127029-01_C... - Page 5 PRODUCT SPECIFICATIONS continued 42" MODELS " " " 23" (Ref.) " " " " " 42" HEARTH " " 50" 30" " " 7" " " 42" " " 13" Figure 2 - 42" Models - VRE4542RS, VRE4542WS, VRE4542RH and VRE4542WH 127029-01_C Superiorfireplaces.US.com...
- Page 6 PRODUCT SPECIFICATIONS continued 50" MODELS " " " " 23" (Ref.) " " " 50" HEARTH " " 50" 30" " " " 7" " 50" " " 13" Figure 3 - 50" Models - VRE4550RS, VRE4550WS, VRE4550RH and VRE4550WH Superiorfireplaces.US.com 127029-01_C...
-
Page 7: Air For Combustion And Ventilation
AIR FOR COMBUSTION AND VENTILATION Confined and Unconfined Space WARNING: This firebox shall not be installed in a The National Fuel Gas Code, ANSI Z223.1/NFPA 54 defines a confined room or space unless the required volume of indoor space as a space whose volume is less than 50 cubic feet per 1,000 combustion air is provided by the method described Btu per hour (4.8 m per kw) of the aggregate input rating of all ap-... - Page 8 AIR FOR COMBUSTION AND VENTILATION continued The space in the example is a confined space because the actual Btu/ Ventilation Air From Outdoors Hr used is more than the maximum Btu/Hr the space can support. Provide extra fresh air by using ventilation grills or ducts. You must You must provide additional fresh air.
-
Page 9: Installation
INSTALLATION INSTALLATION CLEARANCES WARNING: A qualified service person must install firebox. Follow all local codes. WARNING: Maintain the minimum clearances. If you can, provide greater clearances from floor, ceil- WARNING: Never install firebox ing, and adjoining wall. • in a bedroom or bathroom* •... - Page 10 INSTALLATION continued Mantel Clearances for Built-In Installation BUILT-IN FIREBOX INSTALLATION If placing custom mantel above built-in firebox, you must meet Built-in installation of this firebox involves installing firebox into a the minimum allowable clearance between mantel shelf and top of framed-in enclosure.
- Page 11 INSTALLATION continued IMPORTANT: When finishing your firebox, combustible materials such 1. Assemble cabinet mantel as instructed. as wall board, gypsum board, sheet rock, drywall, plywood, etc. may 2. Install gas piping to firebox location. See Gas Line Installation on be butted up next to the sides and top of the firebox. Combustible page 11.
- Page 12 INSTALLATION Continued REFRACTORY PANEL INSTALLATION INSTALLING FIREPLACE HOOD AND SCREENS 1. Attach hood to firebox using screws provided (see Figure 14). IMPORTANT: Installation of brick should be done after 1. Slide round end of screen rod into rings at top of screen. Attach one push-on nut to end of rod before attaching last ring of screen.
- Page 13 INSTALLATION Continued GAS LINE INSTALLATION CAUTION: All gas piping and connections must be WARNING: A qualified service person must connect tested for leaks after the installation is completed. heater to gas supply. Follow all local codes. After ensuring that the gas valve is on, apply soap and water solution to all connections and joints.
-
Page 14: Parts
PARTS MODEL NO. CATALOG NO. VRE4536RS F0473 VRE4536WS F0474 VRE4536RH F0475 VRE4536WH F0476 VRE4542RS F0477 VRE4542WS F0478 VRE4542RH F0479 VRE4542WH F0480 VRE4550RS F0481 VRE4550WS F0482 VRE4550RH F0483 VRE4550WH F0484 15/16 15/16 Superiorfireplaces.US.com 127029-01_C... - Page 15 18 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP. Use of non-approved parts can result in poor performance and safety hazards. VRE4536RS VRE4542RS VRE4550RS VRE4536WS...
- Page 16 IMPORTANT: Installation of brick panels should be done after the fireplace is placed in a permanent location. LIFTING HAZARD SINGLE -PERSON LIFT COULD CAUSE INJURY. MODEL NO. CATALOG NO. VRE4536RS F0473 USE ASSISTANCE WHEN MOVING VRE4536WS F0474 OR LIFTING. VRE4536RH...
- Page 17 PARTS This list contains replaceable parts used in your firebox. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual. VRE4536RS VRE4536RH VRE4542RS VRE4542RH VRE4550RS VRE4550RH NO. CATALOG NO. DESCRIPTION (F0473) (F0475) (F0477) (F0479)
-
Page 18: Technical Service
TECHNICAL SERVICE REPLACEMENT PARTS Continued You may have further questions about installation, operation, or When ordering repair parts, always give the following information: troubleshooting. Please contact your IHP dealer for any questions 1. The model number of the fireplace. or concerns a. When contacting your dealer please have your model 2. -
Page 19: Warranty
Innovative Hearth Products Superior Brand Gas Fireplaces, Stoves and Inserts ® 20 Year Limited Warranty THE WARRANTY Innovative Hearth Products ("IHP") 20 Year Limited Warranty warrants your Superior Brand gas fi replace, Stove or Insert ("Product") to be free from defects in materials ®... - Page 20 Superiorfireplaces.US.com Record the following important information about your fireplace: Fireplace model number Fireplace serial number Date fireplace was Installed Type of gas fireplace uses Dealer name P127029-01 Innovative Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.
Need help?
Do you have a question about the VRE4536RS and is the answer not in the manual?
Questions and answers