Page 1
60001 Rev 60001-20080222 10006 Santa Fe Springs Road Santa Fe Springs, CA 90670 USA Made in China Owner’s Manual and Operating Instructions 389 cc OHV Electric Start GASOLINE ENGINE...
Table of Contents Introduction ........1 Troubleshooting ......17 Replacement Engine ......... 1 Warranty ........18 Accessories ..........1 Warranty Qualifications ......18 This Booklet ..........1 Repair/Replacement Warranty ....18 Manual Conventions ......2 Do not return the unit to the place of ...
Champion Power Equipment manufactures Congratulations on your purchase of a and sells accessories designed to help you Champion Power Equipment engine. CPE get the most from your purchase. To find out designs and builds engines to strict more, please visit our web site at specifications.
NOTE If you have questions regarding your engine, we WARNING can help. Please call our help line at 1-877 338- 0999. WARNING indicates a potentially hazardous could situation which, if not avoided, result in death or serious injury. Rev 60001-20080222...
Traumatic amputation or severe laceration can result. Keep hands and feet away from rotating parts. Tie up long hair and remove jewelry. Operate equipment with guards in place. DO NOT wear loose-fitting clothing, dangling drawstrings or items that could become caught. Rev 60001-20080222...
Page 7
Equipment sparks, smokes or emits flames Disconnect the spark plug wire. Equipment vibrates excessively When storing the engine: Store away from sparks, open flames, pilot lights, heat and other sources of ignition. Rev 60001-20080222...
“On” position to supply fuel to the engine. (11) Oil Filler Cap – Check and fill engine oil level. (6) Starter Grip – rubber comfort grip for recoil starter. (12) Muffler – Full-size muffler for sound abatement Rev 60001-20080222...
The engine is equipped with a low-oil-shutoff and the will stop when the oil level in the crankcase falls below the threshold level. NOTE Check oil often during the break-in period. Refer to the Maintenance section for recommended service intervals. Rev 60001-20080222...
3. Turn the fuel valve to the “On” position. 3. Turn the fuel valve to the “Off” position. 4. Move the choke lever to the “Choke” position. 5. Turn the key in the electronic ignition 6. As engine warms up, move the choke lever to “Run”. Rev 60001-20080222...
Remove the oil drain plug with a 15 mm socket and extension. 2. Allow the oil to drain completely. 3. Replace the drain plug. 4. Remove oil fill cap/dipstick to add oil. 5. Add 1.16 qt (1.1L) of oil and replace oil fill cap/dipstick. Rev 60001-20080222...
Use a soft bristle brush to remove dirt and oil. To be performed by knowledgeable, Use an air compressor (25 PSI) to clear dirt experienced owners or Champion Power and debris from the engine. Equipment certified service dealers Adjustments The air-fuel mixture is not adjustable. CPE...
6. Remove the spark plug and pour about ½ follow these guidelines. ounce of oil into the cylinder. Crank the engine slowly to distribute the oil and lubricate the cylinder. Reattach the spark Engine Storage plug 1. Allow the engine to cool completely before storage. Rev 60001-20080222...
Silencer Nose ST188F-1090004 Air Clean Element ST188F-1090003-A Air Clean Cover Nut ST188F-1090001 Air Clean Cover ST188F-1110002 Governor Rod ST188F-1110001 Throttle Return Spring ST188F-1080200 Control Assembly ST188F-1110006 Governor Arm ST160F-1110004 Governor Arm Bolt ST188F-1110004 Governor Spring ST188F-1110003 Cover Arm Shaft Rev 60001-20080222...
Page 18
Valve Oil ST188F-1040007 Valve Spring ST188F-1040002 IN , Valve Spring Retainer ST188F-1040008 Ex , Valve Spring Retainer ST188F-1040009 Valve Rotator GB41-86 Nut M8 ST188F-1100100-CPE Muffler Packing(No Asbestos) 139FMD-1003102 Drain Plug Washer 139FMD-1003101 Drain Plug Bolt ST188F-1040012 Valve Lifter Rev 60001-20080222...
Fill fuel tank Low oil level Fill crankcase to the proper level. Place engine on a flat, level surface Engine cannot supply enough power Insufficient ventilation Check for air restriction. Move to a or overheating well ventilated area Rev 60001-20080222...
Wear items such as filter elements, o-rings, etc. Warranty Qualifications Accessory parts such as starting batteries, and Champion Power Equipment (CPE) will register storage covers. this warranty upon receipt of your Warranty Failures due to acts of God and other force Registration Card and a copy of your sales receipt majeure events beyond the manufacturer’s...