Table of Contents
Advertisement
2
2
)
INSTALLATION OF THE CHARGER
(1)
Place for installation
Install the charger at a place with good ventilation, no excessive temperature, low humidity and
little dust.
(2)
For the primary of the transformer, use the taps corresponding to the power voltage difference. For
example, 218V(measured value)-220V(primary).
(3)
Confirm the earth line of charging cable wire and make sure the earth line connects the earth of
building.
3)
ORDINARY CHARGE
(1)
The procedure for charging is as follows:
Remove the key of vehicle.
Confirm the convert switch at ordinary charge position.
Connect the battery connector and the charging connector.
Make sure the pilot lamp lights.
(2)
The procedure after completion of charging is as follows:
Ensure that the full charge lamp lights on.
Disconnect the battery connector from the charge connector.
(3)
The procedure for stopping charging halfway is as follows :
Push the manual stop button.
Disconnect the battery connector from the charge connector.
4
4
)
EQUALIZING CHARGE
(1)
Continual repetition of ordinary charge will create a certain amount of performance difference
among the cells. For this reason, the battery is slightly overcharged from time to time to equalize
the performance among the cells, that is, given equalizing charge.
Equalizing charge should be given in the following cases:
A battery that is subject to daily repetition of charge and discharge. For the battery, equalizing
charge should be performed once a month.
When discharged over the designated capacity.
When recharge had been delayed after discharge.
When a short-circuit has occurred.
Equalizing charge is performed in the same way as in ordinary charge. However, place the
ordinary/equalizing charge convert switch on the equalizing charge position.
Excessive equalizing charge may shorten the life of the battery.
5)
SUPPLEMENTARY CHARGE
If one day operation cannot be completed with single charge, rest period should be utilized to
charge and it is performed in almost the same way as ordinary charge.
6)
NOTICES
When installing the charger confirm the input voltage and use the tops corresponding to the
poser voltage in the area.
Charge the battery immediately after use and once a month even in storage.
Take care not to let the battery specific gravity lower in winter time especially.
During charging, if electrolyte temperature of the battery in above 50
During charging, as an inflammable gas is generated out of the battery, particular care should
taken for fire and ventilation.
4-2
stop charging.
Advertisement
Table of Contents
