dellonda DG96 Manual

Thank you for purchasing a Dellonda product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear protective
instruction gloves during
assembly
manual
1. SAFETY
Read the installation, operating and maintenance instructions thoroughly before installing or using this equipment.
9
If there is a smell of gas: shut off the gas to the appliance, extinguish any open flames. If odour continues contact gas supplier.
9
DO NOT store or use petrol or other flammable substances inside the housing of the heater.
8
DO NOT store or use petrol or other flammable liquids or gases in the vicinity of the heater.
8
DO NOT store a gas cylinder that is not connected for use in the vicinity of this or any other appliance.
8
WARNING! DO NOT use indoors. For use outdoors or in amply ventilated areas.
‰
An amply ventilated area is one that has a minimum of 25% of the surface area open, see fig.1.
(The surface area is the sum of the wall surface.)
WARNING! Not intended to be installed in recreational vehicles and/or boats.
‰
WARNING! Improper installation, adjustment, alteration, service or maintenance can
‰
cause injury or property damage.
Installation and repair must be carried out by a qualified person.
9
DO NOT attempt to alter in any way.
8
This product must be installed and the gas cylinder stored in accordance with the local regulations in force.
9
DO NOT obstruct the ventilation holes of the cylinder housing.
8
DO NOT move/transport the appliance when in operation. Shut off the gas cylinder or the regulator before moving.
8
DO NOT move/transport the heater until it has cooled down.
8
Use only the type of gas and the type of cylinder specified by the manufacturer.
9
The LP cylinder used with the patio heater must meet the following size requirements:
diameter 31.8cm x height 58cm, 15kg maximum capacity.
Protect the product from strong wind to prevent tilting.
9
Only use on level ground capable of withstanding the weight of the heater.
9
DO NOT remove the injector (it is not removable). It is forbidden to convert the appliance from one gas pressure to another gas
8
pressure.
DO NOT connect the gas cylinder directly to the appliance without a regulator. Use only the type of gas specified in the instructions.
8
The whole gas system (hose, regulator, pilot or burner) should be inspected for leaks or damage before use and at least annually, by a
9
suitably qualified person.
All leak testing should be done with a soap solution. Never use an open flame to check for leaks, refer to section 6.2.
9
DO NOT use the heater until all connections have been leak tested.
8
Turn off the gas immediately if a gas smell is detected. Turn cylinder valve OFF. If the leak is at the hose/regulator connection tighten
9
the connection and perform another leak test. If bubbles continue appearing contact your supplier. If the leak is at the regulator/
cylinder connection disconnect from cylinder, reconnect and perform another leak check. If soap bubbles are still seen, cylinder valve
is defective. Return cylinder to its place of purchase.
Keep the ventilation opening of the cylinder enclosure free and clear of debris.
9
DO NOT paint the radiant screen, control panel or top canopy reflector.
8
Control compartment, burner and circulation air passageways of the heater must be kept clean.
9
Turn off gas whilst not in use.
9
LP regulator/hose assembly must be protected from accidental damage.
9
Any guard removed for servicing/maintenance must be replaced before operation.
9
Keeps adults and children away from the high temperature surface to avoid burns of ignition of clothing.
9
Children should be carefully supervised when in the vicinity of the heater.
9
DO NOT hang clothing or other flammable materials on the heater or place them near the heater.
8
2. INTRODUCTION
Innovative design of Radiant Gas Tower Patio Heater. This traditional freestanding patio heater produces a pleasant, heated working/relaxing
environment and is ideal for both commercial and domestic settings including open workshops, boat yards, patios, forecourts, gardens and
terraces. The burner head is positioned approximately 2.1m off the ground and the metal reflector directs radiation downwards and outwards.
Variable heat output controls make it fully adjustable. The unit features a fully enclosed gas cylinder chamber and safety tip-over switch.
Supplied with wheels for easy manoeuvrability, regulator and hose assembly for use with propane patio gas bottles and is available in black or
stainless steel. This product should only be used in a well ventilated area. Maximum Gas Bottle Size (W x H): Ø325 x 700mm. Some assembly is
required.
DELLONDA FREESTANDING GAS OUTDOOR
GARDEN PATIO HEATER COMMERCIAL
DOMESTIC 13KW
DG96, DG97
MODEL NO:
Original Language Version
fig.1
DG96, DG97 Issue:1 24/12/20