Page 1
OPERATOR’S and MAINTENANCE OPERATOR’S and MAINTENANCE MANUAL Part Number 159-0074-000 Open Cab Manufactured/Control Kit Installed January 2021 January 2021 and after...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Table of Contents GENERAL INFORMATION ........................... 9 PRELIMINARY INFORMATION ......................10 1.1.1 DOCUMENT IDENTIFICATION ....................10 1.1.2 SYMBOLS USED IN THE MANUAL .................... 10 1.1.3...
Page 4
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com SAFETY ..............................21 INTENDED USE OF THE MACHINE....................22 PROHIBITED USE ..........................22 LIMITS OF USE ..........................23 GENERAL REGULATIONS FOR USE ....................
Snorkel. All violations are punishable by law. 1.1.4 VALIDITY This manual covers agricultural and industrial public works vehicles type: SR5719 STAGE V and reflects the state of the art at the time of their release on the market. Snorkel constantly strives to perfect all of its machines. The manufacturer therefore reserves the right to make the changes it deems necessary without prior notice.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 1.1.5 THE IMPORTANCE OF THE MANUAL The various information contained in the manual contains some very important points regarding the safety devices and the procedures to perform particular operations without causing harm to persons or damage to property.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com SPECIALIST PERSONNEL Specifically trained personnel who are authorised by the Manufacturer and have particular knowledge of the machine and can therefore safely perform all or some of the following operations: ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 1.4 OPERATOR TRAINING 1.4.1 DRIVING ABILITY The vehicle must only be used by qualified and authorised personnel; the minimum training requirements are: ...
The plates of all main components not manufactured and/or produced by Snorkel (e.g. pumps, axles, etc.) are directly applied on the components themselves, at the points where the respective manufacturers have originally placed them.
1.6 NOISE Machines in the SR5719 OPEN CAB family are fitted with a YANMAR 52 kW STAGE V engine. The sound power level emitted in the environment, measured according to the methods and procedures provided for by Directive 2000/14/EC - noise emission in the environment of machines and equipment for outdoor use - is reported below: Calculated sound power: 92.8 dB...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 1.8.6 HYDRAULIC SERVICES SYSTEM The system consists of the following parts: Gear pump with displacement of 25 cm ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 1.8.11 DRIVER’S CAB Fixed to the frame by means of vibration-damping mounts, distinguished by: Anatomic seat adjustable to the weight and height of the driver fitted with a height-adjustable headrest, tilting armrests and a safety belt The driver’s cab is type-approved in accordance with the provisions of ISO 3449: 2005 level II (FOPS), ISO...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.1 INTENDED USE OF THE MACHINE The telescopic handlers are self-propelled wheeled machines with a single driver’s seat and single operator, intended for use on flat or moderately uneven surfaces, with the limits of use specified below.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.3 LIMITS OF USE The machine is designed and built to work in temperatures ranging between -20°C and +40°C.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.4 GENERAL REGULATIONS FOR USE When transporting a load, keep the accessory at a maximum height of 300mm from the ground.
Page 25
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Always work in conditions with suitable lighting; the standard machine lighting system is not adequate for lighting the work area with poor visibility (evening or night-time).
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.6 MANEUVERING ON UNEVEN GROUND When maneuvering on uneven ground, it is important to remember that contact between the wheels and the surface is conditioned by the depth of any holes or obstacles found along the path.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.8 MANEUVERING ON TERRAIN WITH A LONGITUDINAL SLOPE Proceed and brake gently on longitudinal slopes. If it is necessary to perform movements without load, it is possible to place the accessory facing downstream.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.10 PREPARING TO DRIVE 2.10.1 ACCESS TO THE DRIVER’S CAB Always keep your back facing outwards when getting in and out of the driver’s cab, using the cab upright (1) as a support...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.10.2 ADJUSTING THE DRIVER'S SEAT The lever on the left of the driver’s seat (subsequently indicated as G) frees the backrest, which is pushed forward by a spring situated inside the seat itself.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.10.3 TILTING THE SEAT By pushing the lever (G) all the way, the backrest can be moved forward to access the rear compartment where all the accompanying accessories are housed, the machine handbook and various installed devices.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Never attempt to get down from the machine if you realise it is about to roll over. You are safe inside the cab;...
If a decal is affixed on a part that is replaced, a similar decal must be affixed to the new part. To order replacements for damaged, illegible and/or removed decals from Snorkel, it is necessary to indicate the code of each decal present on the decal, or if not present, the one shown below with the relative description.
Page 33
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Adhesive with yellow background and black writing and red prohibition symbol. Meaning: do not climb on. Adhesive with yellow background and black writing.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.12 LOAD DIAGRAM The load diagram shown is purely indicative as each machine will have it’s own type, specific to each model.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com For each weight category identified, the height and the angle to which it can be lifted can be identified in the diagram or conversely, given a height and an angle, the maximum weight that can be handled can be determined.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.13 ANTI-TILT SYSTEM The anti-tipping system installed standard on the machine allows the operator to work in absolute safety.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.14 TRANSPORTING THE MACHINE 2.14.1 LOADING AND UNLOADING WITH RAMPS The ramps must not be slippery and must be adequate to support the weight of the machine; this is indicated on the CE plate or in this manual.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.15 GENERAL SAFETY WARNINGS Do not tamper or remove the plates and safety devices installed on the machine.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.16 CHECKING ENGINE START UP Before starting the motor, check that the battery connection has been activated from the battery switch housed in the front left part of the machine.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.17 MOVEMENT IN REVERSE DRIVE When the machine moves in reverse or when the control lever is set to the “R” position, an acoustic signal will be automatically emitted to warn people immediately nearby of the potential danger posed by the machine itself.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.18.1 FUEL QUALITY (DIESEL) It is advisable to use only Diesel fuels normally available on the market with a sulphur content less than 0.5%.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.21.1 DRIVING ABILITY The vehicle must only be used by qualified and authorised personnel; the minimum training requisites are: ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.22 ROAD CIRCULATION To circulate on the road, the machine must comply with the road traffic code of the country of operation.For the necessary information, contact your dealer.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.22.4 PARKING Always check the compactness and resistance of the ground on which the wheels are rested. With the machine at a standstill, activate the parking brake switch before leaving the driver’s seat.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2.1 DESCRIPTION OF THE CONTROLS i. CONTROL LEVERS ON THE STEERING COLUMN 1. LEFT LEVER OF THE STEERING WHEEL (STALK) To enable the forward gear of the machine (F) the lever must be pulled toward the steering wheel and then pushed forward.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2. LEVER ON THE RIGHT OF THE STEERING WHEEL Work lights control (optional Road Lights if included) Turn the lever by gripping the knurled part until the desired symbol of the rotated part matches the horizontal line of the fixed part.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com b. DESCRIPTION OF THE RIGHT FRONT DASHBOARD i. ON BOARD COMPUTER All information relating to the status of the machine, the functions active at a certain time, the diagnostic...
Page 49
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com LEDS KEY: Alternator LED Engine oil low pressure LED Spark plugs LED Front axle alignment LED Rear axle alignment LED...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com MAIN SCREEN List of icons: 1. Forward mode indicator (from left steering wheel lever , or from joystick 2.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2. MACHINE FORWARD MOVEMENT AND STREET MODE If the steering selector (see "Steering" section) is set to "front steering" a screen will be displayed through which it possible to choose whether or not to switch to STREET MODE: if the OK button is pressed the boom will be disabled and the direction of travel (FNR) will be set to stalk.
Page 52
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com If the travel direction was selected from the joystick (see “FNR mode” section), before switching to street mode, passing to the crab or integral steering method, the following screen will appear. This screen remains visible for about 15 seconds.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 3. LMC SWITCH OFF In LMC Switch Off mode, the anti-tipping system is disabled, therefore it is possible to work with the telescopic boom even with the rear axle lifted or in general outside the zones allowed by the load diagram.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com MENU PAGE The “menu” page displays all the pages where the operator can access and view certain information.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com LANGUAGE PAGE The desired “language” can be selected from the language page. Press the UP button to go to the next language.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com CONFIGURATION PAGE The “display” page allows you to adjust the brightness of the display and the back- lighting of the dials, the hands and the buttons.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com SOFTWARE VERSION / UNITS PAGE In the "sw version / Units" page the operator is able to identify the code and software version installed on the machine's control units, should it be requested by customer service.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 9. DIESEL REGENERATION PAGE In the “Diesel regeneration” page it is possible to determine whether regeneration of the particulate filter is not necessary, necessary or urgently necessary.
Page 60
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com In this case, regeneration of the particulate filter is urgently needed. This screen appears on the display even without consulting the “DIESEL REGENERATION” page. In this situation, failure to carry out regeneration will cause serious problems affecting the engine and which may compromise its operation;...
Page 61
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com starts flashing intermittently. Once the light turns on, confirm by pressing the OK key for 1 second. The light remains lit (fixed) during regeneration.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com ENGINE ERRORS PAGE The “engine errors” page indicates the error codes detected by the electronic self- diagnostic system of the engine List of icons/data: 1.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com VEHICLE ERRORS PAGE In the "vehicle errors" page, the error codes detected by the electronic self-diagnosis system of the machine's control units are shown.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com INPUTS PAGE All the analogue and digital inputs detected by the electronic control system of the machine are shown on the "inputs"...
Page 65
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com “Digital inputs” page: List of icons/data: 1. Forward drive with selector on steering digital input 2. Reverse drive with selector on steering digital input 3.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com FNR MODE The "FNR mode" page allows selection of the mode of advancement: whether via stalk or joystick (see "Joystick"...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com CONSTANT FLOW (OPTIONAL) The “constant flow” is an optional function for specific applications in which it is helpful to have a fixed oil flow (based on the Diesel engine speed) on the hydraulic services at the top of the telescopic boom.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com WINCH ACTIVATION (OPTIONAL) If the machine is equipped with the optional winch, from this page it is possible to activate or deactivate the winch itself.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com SAFETY WARNINGS The computer on board can inform the operator about the conditions in which safety is compromised.
Page 70
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com If the reversible fan function is activated manually by the operator, or starts automatically (see “Reversible fan” paragraph), the following warning is displayed:...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com ii. RIGHT FRONT DASHBOARD Button 1: Trailer brake or front axle locking differential button (optional if present) Button 2: Boom Electric Outlet Control (optional if present)
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com iv. SECOND RIGHT SIDE DASHBOARD The following are found inside this dashboard: 1. Parking brake activation/deactivation button 2. Diesel engine ignition – START 3.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com v. TOP RIGHT SIDE DASHBOARD To the right of the operator, up above, there is a third dashboard. An image is shown below.
Page 74
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Stopping the machine suddenly can cause the load being transported to fall Sudden braking can cause physical trauma caused by the safety belt that should be fastened.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com vii. JOYSTICK The joystick, to the right of the driver's seat, allows you to perform all hydraulic movements of the telescopic boom and the accessory holder at its tip.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com viii. FLOATING BOOM FUNCTION (OPTIONAL) The machine can be equipped with the floating boom function (optional). This function allows the hydraulic oil to be completely drained from the lifting cylinder and therefore to “free”...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com x. REVERSIBLE FAN FUNCTION (OPTIONAL) The “Reversible fan” is a function that allows the radiator surface to be kept clean and efficient. The function works by inverting the direction of the cooling fan blades and therefore inverting the cooling flow.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com a. POWER ON Turn the ignition key selector (1) clockwise from position 0 (engine off) to position 1.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com The machine is at a stop when the engine runs at minimum.Gradually press the gas pedal to start driving.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com d. ACCESSORY COUPLING AND RELEASE The hooking methods described below are valid for all accessories compatible with the machine.
Page 83
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Tilt the accessory carrier backwards so that the main structure of the accessory rests against the accessory carrier.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com The telescopic boom is equipped with an AUX hydraulic line with proportional control, used to control a hydraulic function of the accessories.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com ii. HOW TO DRAW A LOAD FROM ABOVE Slowly move the machine forward, lifting the forks so that they're positioned on the vertical of the point where the load must be picked up.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com i. TRANSPORTING THE LOAD Make sure you have selected the suitable steering mode Fully retract the boom ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com g. WHAT TO DO AND NOT DO It is forbidden to tow masses with the boom (extended or retracted).
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com h. HOW TO VERIFY THAT THE ANTI-TIP DEVICE WORKS CORRECTLY Proceed as follows to verify that the anti-tip device works correctly: ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com i. TOWING THE MACHINE The machine’s hydrostatic transmission is constantly engaged as is the traction on all four wheels.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com ii. TOWING FOR SHORT DISTANCES (PUMP 40 BOSCH REXROTH) Attention: these operations can be only be carried out with the engine off and the wheels blocked by means of wedges to prevent the machine from making uncontrolled movements.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com a. GENERAL INFORMATION Park the machine on level ground. The work area must be clean and dry.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com b. THERMAL RISK i. JETS OF HOT FLUIDS After switching the engine off, its mass remains hot for a period of time depending on the ambient temperature.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com d. EXHAUST GAS The engine exhaust gases are toxic and may cause damage to human health. If it is necessary to work in closed environments, make sure there is sufficient ventilation and equip the machine with suitable purifiers.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com h. MAINTENANCE WITH THE ENGINE OFF Perform maintenance with the engine off as follows: Lower the telescopic boom ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com MAINTENANCE PROGRAM The following table lists all necessary maintenance operations and their frequency in order to maintain the efficiency of the machine.
Page 97
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com CHECK FREQUENCY OF SCHEDULED MAINTENANCE 250 HOURS EVERY EVERY EVERY EVERY EVERY GROUP TYPE OF CHECK FIRST 1000...
Page 98
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com CHECK FREQUENCY OF SCHEDULED MAINTENANCE EVER EVER EVER EVER EVER 250 HOURS GROUP TYPE OF CHECK FIRST DAILY...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com l. ENGINE i. CHECKING AND TOPPING UP THE ENGINE LUBRICATING OIL LEVEL Proceed only with the engine turned off. Smoking and open flames are prohibited. Attention, in case of hot lubricating oil, burn hazard.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com ii. CHECK THE COOLING LIQUID LEVEL Proceed only with the engine turned off and at very low temperature to avoid burns. Make sure that with the engine cold, the liquid level in the expansion tank is above the minimum (LOW).
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com iii. COOLANT LIQUID REPLACEMENT The coolant needs to be replaced every 2,000 operating hours or every two years (regardless of the routine maintenance interval).
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com iv. OIL CHANGE AND OIL FILTER REPLACEMENT The engine oil, in a new engine, is quickly contaminated by residue of the internal parts during run-in. It is very important that the first oil change be carried out in accordance with the maintenance schedule.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 4. Screw the new filter onto the support by hand until it is in contact with the seal, then tighten (20 Nm torque) 5.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 2. Adjust the belt tension if necessary. Loosen the adjustment/fixing screw of the alternator ([1] figure 2) and using a lever ([3] figure 2), move the alternator ([2] figure 2) until obtaining the desired tension.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com The drainage procedure is as follows: 1. Place a suitable container under the water separator to collect the water and contaminants.
Page 106
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 7. Install the new element on the body (9) (figure 5). 8. Place the floating ring inside the sump.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com viii. DRAINING OF WATER FROM THE FUEL TANK/EMPTYING THE FUEL TANK This operation must only be performed by qualified personnel.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com ix. CHECKING THE INTEGRITY OF THE DRAIN PIPE/S Visually check that the exhaust gas system is not blocked or damaged. Make sure there is no possibility for hazardous fumes inside the machine.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com m. HEAT EXCHANGER Each day, the operator must check that the air intake surfaces of the radiators are free of impurities (dust, sludge, straw, etc.).
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com n. CHECKING THE HYDRAULIC OIL LEVEL The hydraulic oil level in the tank in the rear left part must be periodically checked.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com p. VISUAL INSPECTION FOR OIL LEAKS IN THE HYDRAULIC SYSTEM The operator must periodically perform a visual inspection of the hydraulic system to check for any leaks.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com r. CLEANING OR REPLACING THE OIL TANK VENT CARTRIDGE The maintenance plan includes cleaning the tank vent cartridge every 250 hours and replacing it after 1500 hours.
Page 114
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Disassemble the various components (sponge, cartridge and support) Wash the cartridge and sponge components with gasoline or trichlorethylene ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com s. REPLACING THE HYDROSTATIC PUMP OIL CARTRIDGE/FILTER This operation must be carried out by qualified personnel. Proceed as follows to replace the hydrostatic pump oil cartridge/filter: ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com CLEANING AND REPLACING THE ENGINE AIR FILTER CARTRIDGE To clean the air filter (replacement every 500 hours), proceed as follows: ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com u. GREASING – LUBRICATION In points 1 indicated in the image, there are grease fittings to lubricate the zones subject to sliding. The different grease fittings are indicated by special adhesives.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com v. LUBRICANT/LIQUID CHARACTERISTICS i. ENGINE OIL Use lubricants compatible with the following service categories: API: CJ-4 ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com iv. REDUCER OIL 603 Use the following lubricants: SAE80W90 (API GL4-GL5) Quantity of oil: 0.7 litres. v. GREASE Lubricate with the following type of grease: ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com w. AXLES This operation must be carried out by qualified personnel. Refer to the following to replace or check the oil level: Fill cap 2.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com x. TORQUE OF THE SCREWS AND GREASING THE CARDAN SHAFT CROSS Lubricate the spiders at the two ends of the central drive shaft. Check the torque of the bolts connecting the cardan shaft and axles.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com y. CHECKING OF PNEUMATIC PRESSURE AND OF NUT TIGHTENING Periodically check the torque of the nuts (1) on the four wheels and the tire pressure. For the correct tightening torque, see Table 1.
Page 123
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Inflation can pose some risk and it is best to use a gun fitted with an extension pipe so as to be positioned at a safe distance and protected from a possible explosion.
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com z. INSPECTING, CHARGING AND REPLACING THE BATTERY The battery is the component allowing the machine's electrical system to operate. Its poor operation may cause problems both during machine start-up and use.
Page 125
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Charging If a flat battery needs to be re-invigorated after extended non- use, involuntary discharge or due to malfunctions in the...
Page 126
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Replacement If the battery must be replaced due to a malfunction or end of service life, it is advisable to contact an authorised workshop.
Page 127
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Sectioning (BATTERY ISOLATOR) Before working on any part of the electrical system, the power supply must be disconnected using the battery cut-off switch (see figure) on the side of the battery compartment.
Page 129
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com The cards are located in the lower left part of the driver's cab. To access, loosen the three screws that secure the protection panel Both the fuse card (1) and the relay card (2) are located inside the compartment.
Page 130
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com Fuses key FUSE SIZE FUNCTION SAUER MC24 CONTROL UNIT SUPPLY CONTROL UNIT OUTPUT1 SUPPLY KEY TO 1 CAB...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com bb. LIST OF TRANSMISSION ERRORS Below is a list of the possible transmission errors. In case of an error, one of the following descriptions will...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com cc. LIST OF ENGINE ERRORS Following is the list of possible errors of the control unit of the Yanmar 52 kW...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com a. REQUEST FOR THE ELECTRICAL WIRING DIAGRAM Request the wiring diagram by contacting the assistance service and/or the Manufacturer, indicating the...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com a. REQUEST FOR HYDRAULIC SYSTEM DIAGRAM Request the hydraulic diagram by contacting the assistance service and/or the Manufacturer, indicating the...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com a. IMPLEMENTED SCHEDULED MAINTENANCE COUPONS Fill in the tables below after each scheduled maintenance operation. It is necessary to indicate: ...
Page 145
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 146
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 147
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 148
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 149
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 150
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 151
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 152
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Page 153
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com TYPE OF INTERVENTION EXECUTOR First name______________________________________ First intervention Surname___________________________________ 500 1000 Company______________________________ 1500 2000 ...
Snorkel International, LLC Model: Snorkel SR5719 2009 Roseport Road Part Number: 159-0074-000 Elwood, KS 66024 Version: Stage 5 / Open Cab www.snorkellifts.com 9. MACHINE RECEIPT CARD The client is obliged to complete all fields (in block letters) of the table and send it by postal mail or e-mail to Snorkel Service.
Page 155
All parts returning should be still in a factory state, free of any alteration to the original design. If the parts are subject to repair it will need to be pre authorized by the Snorkel Product Sup- port Group and or Warranty Department prior to the repair being completed.
Page 156
10. Reimbursement policy, labor will be paid at 75% of posted hourly shop rate. Travel time will be paid at $50 per hour up to a maximum of 3 hours. Snorkel will pay 1 hour of troubleshooting time per warranty claim, unless expressly agreed otherwise in writing and in advance by Snorkel’s Warranty Department.
Page 157
Snorkel will not cover leaks from fittings, hoses and any other connection points after the unit has been in service for 90 days or 150 hours of operation which ever comes first.
Page 158
Distributor/SSC/Dealer. Warranty support should be from the Distributor/SSC/Dealer from whom the Snorkel product was purchased. Where Snorkel equipment is supplied directly from the factory the end customer, or if unable to contact the Distributor/SSC/Dealer, may contact the Snorkel Warranty Department for further assistance.
Page 160
Local Distributor / Lokaler Vertiebshändler / Distributeur local El Distribuidor local / ll Distributore locale EUROPE, MIDDLE EAST AFRICA & ASIA PHONE: +44 (0) 845 1550 058 FAX: +44 (0) 845 1557 756 NORTH & SOUTH AMERICA PHONE: +1 785 989 3000 TOLL FREE: +1 800 255 0317 FAX: +1 785 989 3070 AUSTRALIA...
Need help?
Do you have a question about the SR5719 and is the answer not in the manual?
Questions and answers