Table of Contents
Advertisement
Quick Links
Coolgenix™ Case Cleaning Checklist
Do not perform these procedures until you have been properly trained by store personnel to clean
the cases or watched the Hillphoenix Case Cleaning Guidelines video. Make sure you follow safety
procedures outlined by your organization and abide by any state and local codes that may apply.
Pre-Cleaning Check List
Identify the cases that need to be cleaned (Note: Multiple cases usually run on the same
refrigeration circuit, so plan on cleaning all cases on that circuit at one time)
Post safety signs in the area of the cases that are going to be cleaned
Remove the product from the cases and relocate to a refrigerated storage area
Turn off the refrigeration to the cases, there are several options:
Turn off at the power supply
If your case is equipped with a clean switch button, push the button. The push button allows
for a 90 minute delay and will automatically turn back on after 90 minutes
If your case is equipped with a cleaning toggle switch, flip the manual toggle off to clean and
manually flip back on when case is cleaned
If you are unable to turn the refrigeration off to the case by the above methods, put the case
in a manual defrost through the Dixell Controller -
Push the DOWN key for more than 2 seconds and a manual defrost will start on
the Dixell Controller. The controller must be turned back on when finished
cleaning.
If your case is equipped by a different type of controller, refer to the controller manual for
putting the case into manual defrost for case cleaning
Turn off the electrical circuits to the case at the power supply
Wait until the Coolgenix deck pans are room temperature before removing - the center pan will
Visually inspect the cases for debris and ice
Check the drain to make sure it is not clogged
Gather all necessary cleaning materials
Mild cleaning solution
Sanitizer
!
!
CAUTION
have a sensor attached on the bottom of the deck pan, detach the
sensor before removing the pan
Location of pan sensor found on the
bottom of the center deck pan in the
display case.
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Dover Hillphoenix Coolgenix
Summary of Contents for Dover Hillphoenix Coolgenix
- Page 1 Coolgenix™ Case Cleaning Checklist CAUTION Do not perform these procedures until you have been properly trained by store personnel to clean the cases or watched the Hillphoenix Case Cleaning Guidelines video. Make sure you follow safety procedures outlined by your organization and abide by any state and local codes that may apply. Pre-Cleaning Check List Identify the cases that need to be cleaned (Note: Multiple cases usually run on the same refrigeration circuit, so plan on cleaning all cases on that circuit at one time)
- Page 2 Clean towels or paper towels Soap and hot water (Cleaning tank only) Non-abrasive cleaning pads Glass cleaner Case Cleaning Check List Clean the top sill Spray the top sill with a mild cleaning solution and wipe it down with a clean cloth or paper towel Spray the top sill with sanitizer and allow it to air dry 2.
- Page 3 Spray the Coolgenix deck pans, spanner bars and rear pan support bars with a mild cleaning solution and wipe them down with a clean cloth or paper towel DO NOT put the deck pans in the dishwasher. Elevated temperatures can cause them to distort and leak with the increase in internal temperature Spray the deck pans, spanner and rear pan support bars with sanitizer and allow them to air dry 4.
- Page 4 Turn on the electrical circuit and verify operation of electrical components Turn on the refrigeration to the cases either at the power supply, through the controller or it will automatically turn back on after 90 minutes if the push button cleaning switch is installed on the display case Re-install the Coolgenix deck pans, spanner bars, and rear pan support bars back into the case.
Need help?
Do you have a question about the Hillphoenix Coolgenix and is the answer not in the manual?
Questions and answers