For the latest Test all information, always consult the current PIONEER Service exposed metal surfaces Manual. A subscription to, or additional copies of, PIONEER Service Manual may be obtained at a nominal charge from PIONEER. Also test with plug reversed...
S-FCRW210-K S-FCRW710-K 2. DISASSEMBLY 2.1 SUBWOOFER 2.2 SATELLITE ¶ POWER AMP SECTION ¶ ¶ ¶ ¶ ¶ METAL GRILLE Remove the 8 screws from the power amplifier. The metal grill is attached to the cabinet by butyl rubber. Remove the connector lead, etc.
Page 4
S-FCRW210-K S-FCRW710-K 3.2 EXTERIOR SECTION 3.2.1 POWERED SUBWOOFER Parts List Mark No. Description Parts No. Cabinet 277478 Amplifier Assy (HTP-A3) 277374 Front Panel 277443 Port Flare Assy 278000 Woofer 277572 Logo Badge 277458 Woofer Gasket 277745 Port Gasket 277750 Screw for Woofer + AMP 278015 3.2.2 SATELLITE SPEAKER...
Page 5
S-FCRW210-K S-FCRW710-K 3.3 POWER AMP SECTION NOTES : ¶ Parts marked by “ NSP ” are generally unavailable because they are not in our Master Spare Parts List. ¶ The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
S-FCRW210-K S-FCRW710-K 4. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM 4.1 EXTERIOR SECTION OPERATON Gain Adj Photo ASSY : AWU7761 MAIN Volume Coupler +16v +6 V PC41 TLP621(Y) IC 201 L. P. F. H. P. F. NJM2904M JA201 Line Q201 Buff Buff...
Page 7
S-FCRW210-K S-FCRW710-K +84v Charge balance and DC feedback Power Speaker Over Voltage Buff Detection C13, C14 - 84v Signal feedback Clip Det. AMP ASSY : AWU7760 DTA124EK Ó Slow ON/OFF 168v Mute Start − Ó G3SBA20L Thermal Detection IRF640 34.5dBv...
Page 8
S-FCRW210-K S-FCRW710-K 4.2 AMP and OPERATION ASSYS OPERATION ASSY SIGNAL ROUTE : AUDIO SIGNAL • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS ONLY. POWER TRANSFORMER AC POWER CORD...
Page 9
S-FCRW210-K S-FCRW710-K AMP ASSY ADX7356 POWER TRANSFORMER CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491005 FOR IC21, 4910003 FOR IC11, IC12 MFD. BY LITTELFUSE INC.
S-FCRW210-K S-FCRW710-K 5. PCB CONNECTION DIAGRAM NOTE FOR PCB DIAGRAMS: 1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below. Symbol in PCB...
Page 11
S-FCRW210-K S-FCRW710-K SIDE A AMP ASSY Q53 Q54 Q51 IC11IC12 IC21 Q21 IC43 VR41 IC44 (ANP7319-C) AC POWER CORD OPERATION ASSY...
Page 12
S-FCRW210-K S-FCRW710-K SIDE B AMP ASSY IC51 IC41 Q201 OPERATION ASSY IC203 IC202 IC201 (ANP7319-C)
S-FCRW210-K S-FCRW710-K 6. PCB PARTS LIST NOTES : ¶ Parts marked by “ NSP ” are generally unavailable because they are not in our Master Spare Parts List. ¶ The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
S-FCRW210-K S-FCRW710-K 7. ADJUSTMENT ATTENTION ¶ Don’ t make speaker terminal short circuit during the power supply injection. ¶ Since the PRIMARY part of the AMP ASSY is not insulated, be careful of electric shock. ¶ Be sure to disconnect the power supply cord before touching the AMP ASSY board.
S-FCRW210-K S-FCRW710-K 8. PANEL FACILITIES REAR SECTION 1 POWER indicator Illuminates RED when the power is being supplied. 2 Subwoofer LEVEL knob VOLUME Volume of subwoofer is adjusted with this knob. Turn this LINE LEVEL LEVEL POWER knob clockwise to raise the level.
S-FCRW210-K S-FCRW710-K 9. SPECIFICATIONS FRONT / FRONT CENTER SPEAKERS POWERED SUBWOOFER Enclosure ..........Closed box type Enclosure ......Floor standing bass-reflex System ..........2-way loudspeaker type. Drive Units Speaker ........... 20 cm (8 inch) Tweeter ............3/4” dome Midrange ........3” cone magnetically Power Amplifier ....