Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for VIAIR TLC DUAL 444C
Summary of Contents for VIAIR TLC DUAL 444C
-
Page 2: Important Safety Instructions
Each of our air compressors and parts have been carefully produced and packaged. Before you begin installation, please familiarize yourself with the TLC Dual 444C OBA Kit Components List in this Manual. Guidelines for Selecting Mounting Location: The selection of proper mounting location for your air compressor will help ensure a long and trouble free compressor service life. - Page 3 REDUCER...
- Page 5 TLC DUAL 444C OBA 1.5 GAL / 200 PSI AIR TANK & PLUMBING The tank comes with six 1/4" NPT port openings to allow installation in many configurations on your P/N 20011 vehicle. To ensure safe and trouble free use of your air tank, we strongly recommend that you install...
- Page 6 TLC DUAL 444C OBA 1.5 GAL / 200 PSI AIR TANK & PLUMBING (CONT'D) MOUNTING THE TANK: We have included 6 pieces of rubber bushings in your tank mounting hardware. You have the option of using two layers of rubber bushings on one of your tank legs to slightly tilt tank toward the drain cock port to improve drainage properties.
- Page 7 TLC DUAL 444C OBA 1.5 GAL / 200 PSI DUAL AIR COMPRESSOR INSTALLATION (CONT'D) Guidelines for Selecting Mounting Location: The selection of proper mounting location for your air compressor will help ensure a long and trouble free compressor service life. Please pay close attention to the following: Select a FLAT, UPRIGHT, &...
-
Page 8: Pressure Switch Installation
TLC DUAL 444C OBA 1.5 GAL / 200 PSI OPERATING INSTRUCTIONS IMPORTANT: The compressors have a maximum working pressure of 200 PSI. Always operate the compressor at or below the MAXIMUM PRESSURE RATING of the compressor. Operation exceeding maximum pressure ratings and or duty cycle will result in damage to air compressor. - Page 9 TLC DUAL 444C OBA 1.5 GAL / 200 PSI DASH PANEL GAUGE INSTALLATION Your VIAIR® TLC Onboard Air System comes complete with a Dash Panel Gauge to monitor the pressure of your VIAIR® air tank. Additionally, the Dash Panel Gauge has an ON/OFF switch pre installed that will allow you to tern the system off by cutting power to the pressure switch that you have already installed.
- Page 11 TLC DUAL 444C OBA 1.5 GAL / 200 PSI Pressure Regulator Diagram: (Figure 2) Gauge Quick Connect Stud Quick Connect Coupler *Tolerance: ± 3% Inflation Trigger Bleeder Valve USING THE TLC TIRE INFLATOR 1. Connecting the TLC inflator: Select an inflation attachment and connect it to the TLC Inflator Quick-Connect Coupler. Then, connect the Inflator to an air hose by inserting the Quick-Connect Stud into the air hose coupler.
-
Page 12: Troubleshooting Guide
TLC DUAL 444C OBA 1.5 GAL / 200 PSI TROUBLESHOOTING GUIDE: PROBLEM POSSIBLE CAUSE(S) CORRECTIVE ACTION Tank pressure drops when 1. Loose drain cock 1. Tighten drain cock compressor(s) shut off 2. Check valve leaking 2. Replace check valve or 3. - Page 13 TLC DUAL 444C OBA 1.5 GAL / 200 PSI COMPRESSOR APPLICATION GUIDE To ensure that you get the highest level of satisfaction from your compressor performance, refer to information below: VIAIR® COMPRESSOR REFERENCE CHART COMPRESSOR SERIES MAX. WORKING DUTY CYCLE PRESSURE (100 PSI @ 72°F)
-
Page 14: Specifications
TLC DUAL 444C OBA 1.5 GAL / 200 PSI COMPRESSOR MAINTENANCE & REPAIRS a. Drain Coil Hose and tank (if applicable) after each use. b. Replace compressor air filter element periodically (if applicable). Replacement frequency depends on operating frequency and operating environment. For frequent use in dusty environment, we recommend that you replace air filter element at least once a month. - Page 15 TLC DUAL 444C OBA 1.5 GAL / 200 PSI Wiring Diagram - Figure 3: (Fuse not included) Length of wire from battery to compressor (in feet) Amp Draw WIRE REFERENCE: 30 (Red) 85 (White) 86 (Black) 87 (Blue) USER MANUAL...
- Page 16 Corporation and no ownership rights are hereby transferred. No part of the Manual shall be used, ® reproduced, translated, converted, adapted, stored in a retrieval system, communicated or transmitted by any means, for any commercial purpose, including without limitation, sale, resale, license, rental or lease, without the prior express written consent of VIAIR ® VIAIR does not make any representations, warranties or guarantees, express or implied, as to the accuracy or completeness of the ®...
Need help?
Do you have a question about the TLC DUAL 444C and is the answer not in the manual?
Questions and answers