Table of Contents
Advertisement
Quick Links
HP
HP
TWO
TWO
Division: Tecnoter srl
,
,
WAYS
TWO
WAYS
TWO
SERIES
SERIES
HOST
HOST
CAT 330 N
CAT 330 N
Reach boom 516-8562
Stick 3,2 mt 516-8567
Installation manual
Hp two ways, two
pumps. Basic ver.
O KEL
ILBJ
ILBJ
– BASIC VERSION
– BASIC VERSION
PUMPS
PUMPS
O
O
MACHINE
MACHINE
G
G
EXT
EN
EXT
EN
KEL
ILBJ
CAT 330NG
Reach – 3,2 mt
Page 1/16
Rev: 1.1_En –
05/03/2020
Advertisement
Table of Contents
Related Manuals for TECNOTER ILBJ O Series
Summary of Contents for TECNOTER ILBJ O Series
- Page 1 MACHINE HOST MACHINE CAT 330 N CAT 330 N Reach boom 516-8562 Stick 3,2 mt 516-8567 Installation manual Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 1/16 Rev: 1.1_En – pumps. Basic ver. O KEL Reach – 3,2 mt...
- Page 2 Before using this manual, please access SIS and print the following documents: Electric schematic Hydraulic schematic 558-8894 560-3923 558-2722 562-6221 356-8134 490-2714 Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 2/16 Rev: 1.1_En – pumps. Basic ver. O KEL Reach – 3,2 mt...
-
Page 3: Table Of Contents
Addressees............................6 GENERAL INFORMATION.......................7 Manufacturer identification......................7 INSTALLATION PROCEDURE......................8 Line Gp stick – line Gp boom......................9 Line Gp front..........................11 Electronic set-up..........................15 CONTACTS............................16 Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 3/16 Rev: 1.1_En – pumps. Basic ver. O KEL Reach –... -
Page 4: Introduction
If the manufacturer made any change in this manual, the customer must verify that only updated versions of it would be present in site where the system is used. Division: Tecnoter srl Hp two ways, two ILBJ... -
Page 5: How To Read The Manual
Par. = Paragraph Pag. = Page Fig. = Figure Tab. = Table UNIT OF MEASURE Units from the International System of Units (SI) Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 5/16 Rev: 1.1_En – pumps. Basic ver. -
Page 6: Preservation Of The Manual
• have the skill of assembly and operating the specific type of equipment; • have familiarity with the specific regulations of the matter. • Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 6/16 Rev: 1.1_En –... -
Page 7: General Information
GENERAL INFORMATION Manufacturer identification Manufacturer Tecnoter srl a socio unico VAT: IT13072070157 Head office P.zza Eleonora Duse 3 20121 Milano Italy Production site Via Carlo Alberto dalla Chiesa 6 20098 San Giuliano Milanese (MI) Italy After sales service / Spare parts... -
Page 8: Installation Procedure
Double check each hydraulic installation before operate the system. Attention: In case of local laws or restrictions were applicable on the use of this upgrade kit, the operator must strictly observe them. Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 8/16 Rev: 1.1_En –... -
Page 9: Line Gp Stick - Line Gp Boom
253-6558 to the tube just installed 2. Using the provided clamps, bolts and washers, install the tube 253-6454 with valve 389-2407 on the stick (Rh side), then connect the hose 253-6562 to the tube 253-6458 Division: Tecnoter srl Hp two ways, two ILBJ... - Page 10 7. Using the provided clamps, bolts and washers, install the Lh line 556-1395 plus 556-1396 on the Lh side of the boom 8. Connect the hose 282-5760 to the Lh line, rear side 9. Connect the boom tubes to the stick hoses Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 10/16 Rev: 1.1_En –...
-
Page 11: Line Gp Front
2. referring the SIS page 490-2714, connect the harnesses as indicated WARNING: harnesses, valves 555-8147 with rods, seals and accessories are not included in the kit Print SIS pages 560-3923 558-8894 490-2714 Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 11/16 Rev: 1.1_En –... - Page 12 555-8147 cabin side 10. Connect the hose 282-5760 to the block BLCK1GC Print SIS pages 560-3923 WARNING: illustration for reference only. Some parts have been replaced by Tecnoter parts Strictly follow this manual TM1516F916 AD166-MDOF Division: Tecnoter srl...
- Page 13 Assembly the group following the next picts NORLM9SIMDOF 442-0234 Option FL1146WOR- 1143WOOR SLR320330NG BLCK114GCFP BA114330320NG N000MDBBFDSC Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 13/16 Rev: 1.1_En – pumps. Basic ver. O KEL Reach – 3,2 mt 05/03/2020...
- Page 14 555-8147 18. Connect the hose 356-8077 to the block BLCK114GCFP using the bolt VEI12X160 19. Fix the hose support 520-3045 with clip where indicated in SIS page Division: Tecnoter srl Hp two ways, two ILBJ...
-
Page 15: Electronic Set-Up
Multi function with combined attachments: not installed Return filter: not installed Solenoid variable relief (E-RV1, E-RV2): not installed Activation: Rh modulation handle (or switch if available and preferred) Division: Tecnoter srl Hp two ways, two ILBJ CAT 330NG Page 15/16 Rev: 1.1_En –... -
Page 16: Contacts
CONTACTS Please don't hesitate to contact our technical service for any further detail. Thank you for choosing Tecnoter products Tecnoter Group Offices: Piazza Eleonora Duse, 3 20121 Milan Italy Facility: Via Dalla Chiesa, 6 20098 San Giuliano Milanese Italy Web: www.tecnotergroup.com...
Need help?
Do you have a question about the ILBJ O Series and is the answer not in the manual?
Questions and answers