Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for hestan GCD
Summary of Contents for hestan GCD
- Page 1 OUTDOOR COOKING Grill Cart GCD / GCR Use & Care Manual Installation & Operation...
- Page 2 Electrical Parts & Components – disconnect all power supplies and batteries before servicing. READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING YOUR GRILL TO REDUCE THE RISK OF FIRE, BURN HAZARD, OR OTHER INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE. ©2017 Hestan Commercial Corporation...
-
Page 3: Table Of Contents
TABLE OF CONTENTS MODEL NUMBERS INTRODUCTION PRECAUTIONS REGULATORY / CODE REQUIREMENTS PORTABLE LP CYLINDERS CART & GRILL ASSEMBLY GAS CONNECTIONS PARTS LIST SERVICE WARRANTY ©2017 Hestan Commercial Corporation... -
Page 4: Model Numbers En
GCD30 30” DOUBLE DOOR TOWER CART GCR30 30” DOUBLE DRAWER AND DOOR TOWER CART GCD36 36” DOUBLE DOOR TOWER CART GCR36 36” DOUBLE DRAWER AND DOOR TOWER CART GCR42 42” DOUBLE DRAWER AND DOOR TOWER CART ©2017 Hestan Commercial Corporation... -
Page 5: Introduction
(box, pallet, straps) until the unit has been inspected. PRECAUTIONS - BEFORE YOU USE YOUR GRILL CART When properly cared for, your Hestan grill cart will provide safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat, which can cause serious injury or even death if the instructions are not followed carefully. -
Page 6: Precautions
Clean and perform general maintenance on the grill and cart twice a year. Watch for corrosion, cracks, or insect activity. See the CLEANING AND MAINTENANCE section of the Hestan Grill manual for more information. 13. Do not push down on an extended drawer as this may result in damage to the drawer slides, or in extreme cases, could cause the cart to tip forward causing injury. -
Page 7: Portable Lp Cylinders
3. The LP cylinder must be disconnected and stored OUTSIDE in a well-ventilated area, out of the reach of children. 4. Do not store a full cylinder in direct sunlight. READ AND UNDERSTAND THE GAS CONNECTION AND LEAK TESTING SECTIONS DETAILED IN YOUR HESTAN GRILL MANUAL, BEFORE USING YOUR GRILL. ©2017 Hestan Commercial Corporation... -
Page 8: Cart & Grill Assembly
Never locate the grill over, under, or next to unprotected combustible construction. Please read the Hestan Grill manual for more information on proper placement. 1. Engage the brakes on the casters to prevent movement of the cart. Ensure all packaging, straps, etc. - Page 9 CART & GRILL ASSEMBLY (continued) 3. Open the right door, or pull out both drawers (depending on which Hestan cart you own). Install the electrical box supplied with your grill (highlighted here in red) on the 2 studs at the rear, inside wall of the cart.
- Page 10 Be careful with the motor cover at the rear of the grill, check that the fan can rotate freely without touching the cover. Check the wire harness for interferences. PANELS TO BE FLUSH PANELS TO BE FLUSH ©2017 Hestan Commercial Corporation...
- Page 11 11. Reach inside the right front area of the cart wall and install 2 flat washers and hex bolts as shown here using a 7/16” wrench or socket wrench. Do not tighten yet. Repeat this on the opposite side of the cart. ©2017 Hestan Commercial Corporation...
- Page 12 Note: If the holes do not wish to align, a large bar-clamp may be used as shown below to help pull everything together. Use rags or small pieces of cardboard to cushion the clamp and not scratch the finish on your grill and cart. ©2017 Hestan Commercial Corporation...
- Page 13 16. Proceed with the remainder of the grill installation as documented in the Use & Care Manual that came with your Hestan grill. Follow all instructions for regulator installation, gas connections, leak testing, burner adjustment, etc. before using your grill. After all these steps are completed, you can re-install the control panel and knobs, and the rear access panel on the cart.
- Page 14 CART & GRILL ASSEMBLY (continued) 17. Your new Hestan cart comes with doors pre-installed and adjusted at the factory. However, it may be necessary to adjust them once the grill head is installed. As shown below, remove the damper to access the adjustment screws. If for some reason you wish to detach the door, pinch the back of the hinge to un-clip it from the mounting base.
- Page 15 20. To re-install the door and/or damper, follow the instructions shown below. MOUNTING MOUNTING BASE BASE PUSH HERE UNTIL REAR ENGAGES PUSH HINGE UNTIL REAR CLIP ENGAGES ATTACH DAMPER CART WALL AT THIS NOTCH CART WALL ATTACH AT THIS STRUCTURE STRUCTURE NOTCH FIRST DOOR DOOR ©2017 Hestan Commercial Corporation...
-
Page 16: Gas Connections
LEAK TESTING GENERAL Although all gas connections on your Hestan grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible movement in shipment, or excessive pressure unknowingly being applied to parts of the unit. -
Page 17: Parts List
PARTS LIST Please visit the Hestan website to access the parts list for your Hestan Outdoor product: www.hestanoutdoor.com. SERVICE All warranty and non-warranty repairs should be performed by qualified service personnel. To locate an authorized service agent in your area, contact your Hestan dealer, local representative, or the manufacturer. - Page 18 Product; damage from service by someone other than an authorized agent or representative of the Hestan Commercial Service Network; normal wear and tear; damage from exposure of the Product to a corrosive atmosphere containing chlorine, fluorine, or any other damaging chemicals;...
- Page 19 This warranty gives you specific legal rights, and you may also have other rights which vary depending on location. Any questions about this Limited Warranty may be directed to Hestan Commercial Products at (888) 905-7463 ©2017 Hestan Commercial Corporation...
- Page 20 RETAIN THIS MANUAL FOR FUTURE REFERENCE Hestan Commercial Corporation 3375 E. La Palma Ave Anaheim, CA 92806 (888) 905-7463 ©2017 Hestan Commercial Corporation P/N 010252 REV C...
Need help?
Do you have a question about the GCD and is the answer not in the manual?
Questions and answers