Page 1
ORDER NO.DSD0504042A3 DVD Video Recorder DMR-ES10PL / DMR-ES10GT Vol. 1 Colour (S).......Silver Type Please use this manual together with the service manual for Model DMR-ES10P (DSD0502037C1). PDF created with pdfFactory Pro trial version www.pdffactory.com...
Page 2
2005 Matsushita Electric Industrial Co., Ltd. All rights reserved. Unauthorized copying and distribution is a violation of law. 1. Introduction 2. Specifications PDF created with pdfFactory Pro trial version www.pdffactory.com...
Page 3
3. Replacement Parts List Notes: *Important safety notice: Components identified by mark have special characteristics important for safety. Furthermore, special parts which have purposes of fire-retardant (resistors), high-quality sound PDF created with pdfFactory Pro trial version www.pdffactory.com...
Page 4
Chinese.] *All parts mentioned on this parts list are supplied by PAVCSG. 3.1. Change In Replacement Parts List (DMR-ES10P - DMR-ES10PL) Mentioned in the parts list in only those different from Model DMR-ES10P-S PDF created with pdfFactory Pro trial version...
Page 5
Part Name & Description Pcs. Remarks DMR-ES10P-S DMR-ES10PL-S L7502 ELESN390JA G0C390JA0055 COIL L7505 G0C220JA0019 ----- COIL deletion R7401 ERJ3GEY0R00V ERJ3GEYJ101V 1/10W 100 R7526 ERJ3GEYJ332V ERJ3GEYJ274V 1/10W 270K 3.2. Power Supply P.C.B. Replacement Parts List (DMR-ES10PL) PDF created with pdfFactory Pro trial version www.pdffactory.com...
Page 16
4.7K P001 COLD AC SOCKET IMPORTANT SAFETY NOTICE: DMR-ES10PL COMPONENTS IDENTIFIED WITH THE MARK HAVE THE SPECIAL CHARACTERISTICS FOR SAFETY. Power Supply NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERRING.THE CORRECT PART NUMBER IS SHOWN WHEN REPLACING ANY OF THESE COMPONENTS.ONLY THE SAME TYPE.
Page 18
1000P 4.7K 1SS270A7 4.7K DMR-ES10PL Power Supply DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERRING.THE CORRECT PART NUMBER IS SHOWN N THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. Schematic Diagram...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL CONTENTS Page Page 1 Safety precautions 13 Caution after replacing parts 1.1. General guidelines 13.1. After replacing the RAM Drive with new one 2 Prevention of Electrostatic Discharge (ESD) to Electrostatic 13.2.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 1 Safety precautions 1.1. General guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 2 Prevention of Electrostatic Discharge (ESD) to Electrostatic Sensitive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatic Sensitive (ES) Devices.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 3 Precaution of Laser Diode 4 Handling the Lead-free Solder 4.1. About lead free solder (PbF) Distinction of PbF P.C.B.: P.C.B.s (manufactured) using lead free solder will have a PbF stamp on the P.C.B. Caution: ·...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 6 New Feature 6.1. Quick start function(REC) (Note: Descriptions concerning HDD is applied only to models with HDD.) 1. General A few seconds after tuning on the unit,you can start recording to DVD-RAM,HDD. You can switch the operation of this function (ON/OFF) on the menu screen.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 7 Taking out the Disc from RAM-Drive Unit when the Disc cannot be ejected by OPEN/CLOSE button 7.1. Forcible Disc Eject 7.1.1. When the power can be turned off. 1.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 8 Service Explorer Confirm “RAM-Drive Last Error” in Service Mode Execute Service Mode 1. Press [REC], [CH UP] and [OPEN/CLOSE] simultaneous ly for 5 seconds when P-off. FL Display: *After finishing display “(7).
Page 37
(5) Error occurring Disc type is displayed for 5 seconds. (6) Disc Maker´s ID is displayed for 5 seconds. Example of Disc Maker´s ID: DVD-R Disc FL Display (Disc Maker´s ID) Disc Maker Country Panasonic Japan Pioneer Japan Mitsubishi Chemical Corporation Japan Japan...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 9 Self-Diagnosis and Special Mode Setting 9.1. Self-Diagnosis Functions Self-Diagnosis Function provides information for errors to service personnel by “Self-Diagno sis Display” when any error has occurred. U**, H** and F** are stored in memory and held. You can check latest error code by transmitting [0] [1] of Remote Controller in Service Mode.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Error Code Diagnosis contents Description Monitor Display Automatic FL display PLEASE Unit is in termination process Unit is in termination process now. No display WAIT “BYE” is displayed and power will be turned off.
Page 41
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Item FL display Key operation Mode name Description Front Key Aging Contents (Example): Demonstration Ejection of the disc is prohibited. *When lock the tray. When the power is on, press lock/unlock [STOP] [POWER]...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 9.3. Service Modes Service mode setting: While the power is off, press REC, CH UP and OPEN / CLOSE simultaneous ly for five seconds. Item FL display Key operation Mode name Description (Remote controller key)
Page 43
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Item FL display Key operation Mode name Description (Remote controller key) Audio Mute (XTMUTE) Check whether mute is applied normally by Press [2] [1] in service mode. the timer microprocessor. Audio Mute (XDMUTE) Check whether mute is applied normally by Press [2] [2] in service mode.
Page 44
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Item FL display Key operation Mode name Description (Remote controller key) Turn on all FL/LEDs All segments of FL and all LEDs are turned All segments are turned on. Press [5] [1] in service mode.
Page 45
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Item FL display Key operation Mode name Description (Remote controller key) P50(H) Output Timer Microprocessor IC7501-83 output High Press [8] [4] in service mode. signal for AV1-pin 10 passing through inverter (approx.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 10 Assembling and Disassembling 10.1. Disassembly Flow Chart The following chart is the procedure for disassemblin g the casing and inside parts for internal inspection when carrying out the servicing.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 10.3. Top Case 10.5. Digital P.C.B. 1. Remove the 2 screws (A) and 3 screws (B). 1. Remove FFC and a Screw (A). 2. Slide Top Case rearward and open the both ends at rear 2.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 10.9. Front (L) P.C.B. 10.11. Tuner P.C.B. and Nicam Decoder P.C.B. 1. Remove a Screw (A) to remove Front (L) P.C.B. 1. Pull out the Tuner P.C.B. in the direction of the arrow. 2.
Perform auto recording and playback for one minute using the RAM No abnormality should be seen in the picture, sound or operation. disc. *Panasonic DVD-RAM disc should be used when recording and playback. If a problem is caused by a VCD, DVD-R, DVD-Video, Audio- CD, or No abnormality should be seen in the picture, sound or operation.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 15 Voltage and Waveform Chart Note) Circuit voltage and waveform described herein shall be regarded as reference information when probing defect point, because it may differ from an actual measuring value due to difference of Measuring instrument and its measuring condition and product itself.
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 17.2. Analog Video Block Diagram :REC SIGNAL :PB SIGNAL IC3001 (VIDEO PROCESSOR) MAIN P.C.B. JK3903 (SW1) (SW2) COMP 6MHz P9001 P7402 C OUT DM 6MHz BIAS 12MHz COMPONENT VIDEO OUT (SW3) P9001...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 17.3. Analog Audio Block Diagram :REC SIGNAL :PB SIGNAL JK3001 REAR JACK D4005 Q4006 MIX L OUT2 MUTE FROM LINE OUT XTMUTE QR4002-QR4005 TIMER Q4007 IC7501- 63 Q4004 SECTION MIX R OUT2 MUTE...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 18.3. Main Net Section (Main P.C.B. (1/3)) Schematic Diagram (M) TO P1102 POWER P.C.B. TO P9001 P1501 LB1504 DIGITAL P.C.B. J0JKB0000003 (Audio Net Section) < X SW 5.8V > P7402 X SW 5.8V X SW 5.8V...
Page 71
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL G IIC DATA A G IIC CLK A < X SW 5.8V > G CPS VOUT A C1538 C7406 RFC A MUTE M:Main Net Section(Page: G RFC AOUT A (EB)only AI:A/V I/O Section(Page: TO PS7801...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 18.4. A/V I/O Section (Main P.C.B. (2/3)) Schematic Diagram (AI) S VIDEO VIDEO AUDIO AUDIO VIDEO AUDIO AUDIO VIDEO AUDIO AUDIO IN L IN R L OUT R OUT AV4 IN L AV4 IN R AV4 IN...
Page 73
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL COMPONENT VIDEO OUT DIGITAL AUDIO OUT S VIDEO AV4 IN S VIDEO OUT (PROGRESSIVE/INTERLACE) (PCM/BITSTREAM) JK3003 JK3903 K1U407B00004 K2HA210B0002 AV4 Y/C JACK OPTICAL COMPONENT ANA5V VIDEO OUT JACK C4902 C4901 6V47...
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL 21 Replacement Parts List Notes: Ref. Part No. Part Name & Remarks Description *Important safety notice: 12-4 RGK1885-S REC BUTTON RING Components identified mark have special 12-5 RGK1886-Q FL ORNAMENT characteristic s important for safety.
Page 90
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C1517 ECJ1VC1H471J 50V 470P C4018 F2A1H4R7A236 50V 4.7U (EB) C1518 F2A1A101A389 10V 100U C4019 F2A1V100A534 35V 10U...
Page 91
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C7546 F1H0J1050012 6.3V 1U K4012 D0YBR0000002 CHIP RESISTOR (EB) C7550 ECEA0JKA470B 6.3V 47U K7401 D0YBR0000002 CHIP RESISTOR...
Page 92
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description QR7403, UNR521500L TRANSISTOR R4077 D0GB101JA002 1/10W 100 R4078,7 D0GB272JA002 1/10W 2.7K QR7501 UNR521300L TRANSISTOR (EG,EC)
Page 93
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R7587 D0GB224JA002 1/10W 220K D7802 MAZ4300NMF DIODE R7588 D0GB104JA002 1/10W 100K R7589 D0GB221JA002 1/10W 220 K7807...
Page 94
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C7301 F1H1H1030006 50V 0.01U (EG) R7301 D0YBR0000002 CHIP RESISTOR C7302 D0YBR0000002 CHIP RESISTOR R7304 D0GB101JA002 1/10W 100...
Page 95
DMR-ES10EB / DMR-ES1 0EC / DMR-ES1 0EG / DMR-ES1 0EP / DMR-ES10EBL Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C1607 F2A1A681A539 10V 680U R1208 ERJ6GEYJ222V 1/8W 2.2K C1608 F1J1E104A081 25V 0.1U R1209,1 ERJ6GEYJ102V 1/8W 1K...