Power Jack Fuse; Liquid Petroleum Gas (Lpg); Fill Valve - Airstream FLYING CLOUD 2023 Owner's Manual

Power Jack Fuse

Should an electrical failure occur, first check to see if
the fuse, located in the battery box, has blown� If the
fuse is not blown and the jack still will not operate you
can manually operate the jack by placing the manual
override handle into the alignment tube and engaging
the drive pin� Rotating the handle counterclockwise
to raise or clockwise to lower the trailer� If the fuse is
blown, replace the fuse with the same type and check
to see if the jack is now operable�
Refer to the Maintenance section for replacement and
maintenance of the power jack�

Liquid Petroleum Gas (LPG)

Fill Valve

The LPG tanks are equipped with fill valve connections
RV Type I Acme� The large, green, nylon swivel nut is
a right-hand thread and is designed for hand operation
only�
The valve features an internal spring-loaded module
that will not allow gas to flow from the cylinder until a
positive seal has been made at the connection� The
valve outlet has 1-5/16 in� Acme threads on the outlet
exterior, and female POL, left-handed threads on its
interior� This feature allows for connection of the new
wrenchless, right-handed, Acme RV connection while
still accommodating the standard left-handed POL
fittings used for filling propane cylinders.
The mating, green nylon nut swivels on a black
bushing that is heat-sensitive� Between 240 and
300°F, the bushing will yield (melt) allowing the spring-
loaded module in the valve to push the brass nipple
back (approximately 1/4 in�), closing the module and
stopping the flow of gas from the cylinder. Inside the
brass nipple is a flow-limiting device designed to sense
2023 Flying Cloud
excessive gas flow. If an excessive flow is sensed, the
flow-limiting device shuts the flow down to a maximum
of 10 SCFH (Standard Cubic Feet per Hour) or less�
This is also referred to as the bypass flow.
Bypass flow is extremely important in the proper
operation of this connection. The flow-limiting device
may activate if the cylinder valve is opened quickly�
When all appliances are off, the bypass flow allows
the pressure downstream from the flow-limiting device
to equalize. When pressure is equalized, the flow-
limiting device will supply normal flow to the system.
Equalization occurs in approximately 5 seconds and,
in most cases, goes completely unnoticed� If, however,
an appliance is left on or there is a leak or open flow
in the system, the bypass pressure will not be able to
equalize and allow the flow-limiting device to re-open.
Symptoms of this condition would be appliances that
light but have lower than normal flame or starve out
from lack of gas, a substantial reduction in the flame
when another appliance is operating, or pilots that are
difficult to light. If this should happen, the following
steps should eliminate the condition:
1� Close LPG cylinder valve�
2� Extinguish all flames and smoking materials.
3� Be sure all gas appliances, including their pilot
lights, are off�
4� Open LPG cylinder valve slowly� Do not snap open�
5� Wait at least 15 seconds before lighting appliances�
6� If operational difficulties continue, there may be
a leak in the system� Immediately close the LPG
cylinder valve and have the system inspected by a
qualified RV service technician.
When reconnecting a full cylinder to an auto
changeover regulator, it is not necessary to shut off the
appliances or close the valve of the cylinder already in
service�
Leaking LPG may ignite, causing a fire or
explosion, which could result in serious bodily
injury, property damage, and/or death.
How long a full tank of gas will last is dependent
on usage� In cold weather, when you are using the
furnace, large amounts of hot water, and are doing
extensive cooking, you will naturally use more than you
will in warm weather when you may do limited cooking�
On the average, with normal cooking and other
appliance use, you can probably count on two to three
weeks of service from each tank�
Exterior
WARNING
6-7