Char-Broil 5101194 User Manual
Char-Broil 5101194 User Manual

Char-Broil 5101194 User Manual

Commercial series outdoor stove top

Advertisement

OUTDOOR
STOVE TOP
To installer or assembler:
Leave this manual with consumer
for future reference.
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the appliance and
immediately call your gas supplier or your fire department.
WARNING
1. Do not store or use gasoline or other flammable liquids or
vapors in the vicinity of this or any other appliance.
2. An LP cylinder not connected for use shall not be stored in
the vicinity of this or any other appliance.
If you have any questions or need assistance during assembly, please call 1-800-232-3398.
To insure your satisfaction and for follow-up service, register your product online at www.grillregistration.com
FOR OUTDOOR USE ONLY.
DANGER
MODEL
05101194
To consumer:
Keep this manual for future reference.
WARNING
California Proposition 65
Combustion by-products produced when
using this product contain chemicals
known to the State of California to cause
cancer, birth defects, or other
reproductive harm.
WARNING
Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage. Read the
installation, operating and maintenance
instructions thoroughly before installing
or servicing this equipment.
04201101
05101194 • 42804116 • 07-14-05

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 5101194 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Char-Broil 5101194

  • Page 1 OUTDOOR STOVE TOP To installer or assembler: Leave this manual with consumer for future reference. FOR OUTDOOR USE ONLY. DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
  • Page 2: Use And Care

    OUTDOORS. The Outdoor Stove Top can use many of your indoor stock pots, griddles, and woks. Also, look for cooking accessories from Char-Broil at the store where you purchased the Outdoor Stove Top. • Never use a cooking pot or vessel larger than 12 quarts or 12.5”...
  • Page 3: Table Of Contents

    Table of Contents Use and Care ........2-10 Safety Symbols.
  • Page 4: Lp Cylinder Removal, Transport And Storage

    LP Cylinder • The LP cylinder used with your Outdoor Stove Top must meet the following requirements: • Purchase LP cylinders only with these required measurements: 12” (30.5cm) (diameter) x 18” (45.7 cm) (tall) with 20 lb.
  • Page 5: Lp Cylinder Exchange

    • A frosty regulator indicates gas overfill. Immediately close LP cylinder valve and call local LP gas dealer for assistance. • Do not release liquid propane (LP) gas into the atmosphere. This is a hazardous practice. • To remove gas from LP cylinder or call a local fire department for assistance.
  • Page 6: Leak Testing Valve, Hose And Regulator

    Hold coupling nut and regulator as shown for proper connection to LP cylinder valve. Turn the coupling nut clockwise to tighten to a full solid stop. The regulator will seal on the back-check feature in LP cylinder valve, resulting in some resistance.
  • Page 7: Ignitor Lighting

    WARNING For Safe Use of Your Outdoor Stove Top and to Avoid Serious Injury: • Do not let children operate or play near appliance. • Keep appliance area clear and free from materials that burn. • Do not block holes in sides or back of appliance.
  • Page 8: Natural Hazard • Spiders

    CAUTION Natural Hazard • Spiders FACT: Sometimes spiders and other small insects climb into the burner tube. The spiders spin webs, build nests and lay eggs. The webs or nests can be very small, but they are very strong and can block the flow of gas.
  • Page 9: Care And Cleaning Of Stainless Steel

    Routine Care The Char-Broil® Stainless Steel Grill Cleaner and the Thermos® Stainless Steel Grill Cleaner are good choices for routine cleaning of stainless steel surfaces. Mild stains and loose dirt and soil can also be removed with a soft cloth and clean warm water. Rinse with clean water and wipe dry.
  • Page 10: Troubleshooting

    Troubleshooting Problem Possible Cause Burner will not light — Electrode and burner are wet. using ignitor. — Electrode is cracked or broken, “sparks at crack”. — Wire is loose or disconnected. — Wire is shorting (sparking) between ignitor and electrode. —...
  • Page 11: Parts List

    Qty. Description A..1 ..Cover Assembly..... 29100873 B..1 ..Cast Iron Grate ..... 29100874 C.
  • Page 12: Parts Diagram

    Parts Diagram...
  • Page 13: Assembly

    Step 1 Slide tool hooks onto one of the towel bars prior to assembly. Attach each towel bar using two 1/4-20x3/4” machine screws DO NOT LIFT UNIT USING TOWEL BARS. Towel bar 55700667 Step 2 Feed burner tube through center hole of heat shield. Align the three threaded studs on bottom of burner with small holes in heat shield.
  • Page 14 Step 3 Position rotary ignitor as shown below. Attach ignitor behind control panel using two #8x1/2” self-tap screws Rotary ignitor 55700666 Step 4 Insert valve/hose through front opening and attach to control panel using two #8-32x3/8” machine screws. NOTE: Screws may already be installed in valve and must be removed to attach valve to control panel.
  • Page 15 Step 5 Align valve with burner tube. engagement. Secure control panel to body at each end using two 24x3/8” machine screws and two insert one #10x1/2” self-tap screw have someone hold panel in position while attaching hardware. #10x1/2” Self-Tap Screw from inside body #10-24x3/8”...
  • Page 16 Step 7 Lift body assembly and place onto base. Back/open-end of body assembly should face back of base. Back of base has locking casters, front has non-locking casters. Attach body assembly to base using nine #10-24x1/2” machine screws nine #10-24 hex/keps nuts Base 55700672 Step 8...
  • Page 17: Assembly

    #8x1/2” self-tap screws Step 10 LP GAS CYLINDER IS SOLD SEPARATELY. leak check the cylinder before attaching to Outdoor Stove Top and regulator (see Use & Care section). Once cylinder has been filled and leak checked, place cylinder into cylinder hole in base.
  • Page 19: Registration Card

    Please register your product online at: WWW.GRILLREGISTRATION.COM (If you register online, you do not need to send in this registration card.)
  • Page 20 Char-Broil, LLC • Columbus, GA 31902 • Assembly Instructions © 2005...

This manual is also suitable for:

Commercial 05101194

Table of Contents

Save PDF