Graseby 3000/500 Manual

Volumetric infusion pump
Table of Contents

Advertisement

M o d e l 3 0 0 0 / 5 0 0
a n d M i c r o 3 1 0 0 / 5 0 5
Vo l u m e t r i c I n f u s i o n
P u m p
Te c h n i c a l S e r v i c e
M a n u a l
0473

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 3000/500 and is the answer not in the manual?

Questions and answers

Summary of Contents for Graseby 3000/500

  • Page 1 M o d e l 3 0 0 0 / 5 0 0 a n d M i c r o 3 1 0 0 / 5 0 5 Vo l u m e t r i c I n f u s i o n P u m p Te c h n i c a l S e r v i c e M a n u a l...
  • Page 3 The pump must be referred to a suitably qualified technician or returned to Graseby Medical in order to have the fault rectified. WARNING: Before using the pump, it should be inspected for physical damage. The pump should not be used if damage is evident, and should be returned to service personnel for repair before being returned to use.
  • Page 4 22. WARNING: If a backup alarm sounds, the pump should be immediately removed from the patient and sent to be repaired by a Graseby Medical qualified technician. Failure to do so may cause patient injury or death.
  • Page 5 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Cautions Cautions tell you about dangerous conditions that can occur and cause damage to the pump if you do not obey all of the instructions in this manual.
  • Page 6 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . I s s u e A ( A p r i l 2 0 0 2 ) 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 7 G r a s e b y M e d i c a l L t d . Vo l u m e t r i c I n f u s i o n P u m p s © Graseby Medical Limited 2002 Trademarks and acknowledgements: Contents — i...
  • Page 8 Vo l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . l i r Contents —...
  • Page 9: Table Of Contents

    Introduction Scope of this manual ...................... 1 - 1 Related manuals ......................1 - 1 Graseby service contacts ....................1 - 1 Product Overview ......................1 - 2 System description ......................1 - 2 Optional labels ........................ 1 - 2 Software versions ......................
  • Page 10 Vo l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . About Snapshot screens ....................
  • Page 11 G r a s e b y M e d i c a l L t d . Vo l u m e t r i c I n f u s i o n P u m p s Chapter 7 - Maintenance Procedures Maintenance Procedures ....................
  • Page 12 Vo l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Chapter 9 - Illustrated Parts List Illustrated Parts List for pump Serial numbers from 3000 to 60,000 ......................
  • Page 13 Summary of hardware connection and handshaking ........... 12 - 7 Example Commands ....................12 - 8 Interfacing with pump software version 0.68 and above ..........12 - 9 Model 3000/500 3100/505 Computer Interface ............12 - 9 Protocol Definition ......................12 - 9 Character ........................12 - 9 Format - version 0.68 and above ................
  • Page 14 I n t r o d u c t i o n C h a p t e r 1...
  • Page 15: Chapter 1 - Introduction

    Related manuals Chapter 9 Illustrated Parts List Chapter 9 Illustrated Parts List, Graseby service contacts UK service address USA service address 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 1 —...
  • Page 16: Product Overview

    Model 3000/500 Micro 3100/505 Note: Graseby Volumetric Infusion Pumps are also known as the Model 500 and Micro 505. With the exception of the numbering the 3000/500 and the 3100/505 versions of the pumps are identical. Optional labels Software versions Chapter 4, Volumetric Pump Menus.
  • Page 17 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s About Version 0.71 Upgrading to Version 0.71 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 18 S p e c i f i c a t i o n C h a p t e r 2...
  • Page 19: Specifications

    60,000 From bottom of drip chamber to top of pump Model 3000/500 Micro 3100/505 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 2 —...
  • Page 20 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Model 3000/500 Micro 3100/505...
  • Page 21 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Power Over-current protection Voltage...
  • Page 22 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Primary and Secondary Infusions Rate range Model 3000/500 Range Increment Micro 3100/505...
  • Page 23 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Volume to be infused range Model 3000/500 Range Increment...
  • Page 24 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Rate range Model 3000/500 Range Increment...
  • Page 25 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Symbols used on the pump Front panel symbols Inside battery door symbols...
  • Page 26: Standards

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Standards Electrical Safety Design Standards...
  • Page 27: Trumpet Curves

    Trumpet curves Model 3000/500 Graseby Standard Adult Set, 8C-820 Micro 3100/505 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 2 —...
  • Page 28 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . I s s u e A ( A p r i l 2 0 0 2 ) 2 —...
  • Page 29 O v e r v i e w o f P u m p O p e r a t i o n & I n i t i a l C h e c k s C h a p t e r 3...
  • Page 30: Overview Of Pump Operation & Initial Checks

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Overview of Pump Operation &...
  • Page 31: Exterior Of The 500/3000 Pump - Front

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Exterior of the 500/3000 pump - front (Revised case design shown here) Indicators and displays...
  • Page 32: Exterior Of The Pump - Rear

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Exterior of the pump - rear (Revised case design shown here) 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 33: How The Pump Is Powered

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . How the pump is powered AC power connection Battery and portable operation...
  • Page 34: How The Pump Works

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s How the pump works Instruction Manual Technical User Manual...
  • Page 35 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Pressure / occlusion monitoring Pumps with revision 0.64 and higher software Occlusion...
  • Page 36 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Backlight for Message Display Backlight on AC Backlight on Battery...
  • Page 37 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . LED/segment monitoring I s s u e A ( A p r i l 2 0 0 2 ) 3 —...
  • Page 38: Power Up Tests And Checks

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Power up tests and checks On/Off Cold boot...
  • Page 39 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Options On/Off Silence...
  • Page 40 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s End of cold boot - special infusion modes Warm boot insistent...
  • Page 41: Powering Down

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Powering down Manual power down On/Off...
  • Page 42: Power Monitoring

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Power monitoring On AC Mains Instruction Manual, Security on the...
  • Page 43 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . WARNING: Correct management of battery charging, as described in this documentation is essential to ensure that the pump can operate...
  • Page 44: Alarms

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Alarms insistent non-insistent...
  • Page 45 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Non-insistent alarm Silence Hold...
  • Page 46 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Audio alarm specifications Name of alarm Description...
  • Page 47 V o l u m e t r i c P u m p M e n u s C h a p t e r 4...
  • Page 48: Volumetric Pump Menus

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Volumetric Pump Menus Which version of software is in the pump? Introduction to menus...
  • Page 49: About The Technician Menu

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . About the Technician menu Common parameters on Technician and Biomedical menus: Entering the Technician menu...
  • Page 50: Summary Of Technician Menu Parameters

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Summary of Technician menu parameters Options 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 51: Using Technician Parameters

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Using Technician parameters Options Pump Identifier...
  • Page 52 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s KVO rate entry Occlusion default setting Occlusion Alarm Setting...
  • Page 53 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Volume Over Time Dose-Rate Calculation DRC Recovery...
  • Page 54 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Service Date Micrograms Options...
  • Page 55: About The Biomedical Menu

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . About the Biomedical menu System faults Entering the Biomedical menu...
  • Page 56 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Using the Biomedical menu - after a fault has occurred 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 )
  • Page 57: Summary Of Biomedical Menu Parameters

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Summary of Biomedical menu parameters Options 4 —...
  • Page 58: About Snapshot Screens

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s About Snapshot screens Using PC history software to interpret snapshot screens To display Snapshot Screen-a...
  • Page 59: Decoding Snapshot Screen-A

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Decoding Snapshot screen-a Top row of snapshot screen-a: Example shows...
  • Page 60 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Snapshot screen-a - system state codes list continues ...
  • Page 61 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . System state codes, continued 4 —...
  • Page 62: Decoding Snapshot Screen-B

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Decoding Snapshot screen-b Note 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 63 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Converting Snapshot screen-b values from decimal to binary 4 —...
  • Page 64 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Chart A Pump Main Modes Bit 7 Bit 6...
  • Page 65 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Chart D Pump sensor flags and occlusion alarm setting Bit 7...
  • Page 66 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Chart F - Battery Voltage Analog-to-Digital Value...
  • Page 67 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Chart G - State Code 33 - Corrupted Triple Redundant variable in NV RAM Variable Identifier Chart G - State Code 35 - Undefined interrupt...
  • Page 68 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Chart G - State Code 93 To convert the GGG value: To interpret the result...
  • Page 69: Using Biomedical Parameters

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Using Biomedical Parameters Options Time and date display...
  • Page 70 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Charge History Pressure display parameter (on battery power) 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 71 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Pressure display - calibration mode Field Range...
  • Page 72 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Baud rate Options On/Off...
  • Page 73 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Model number and software version Audio alarm test non-insistent...
  • Page 74: Enabling Special Programming Functions

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Audio alarm specifications Enabling special programming functions Enable/disable rate taper...
  • Page 75 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Enable/disable volume over time Enable/disable dose-rate calculation 4 —...
  • Page 76: About The Service Functions Menu

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s About the Service Functions menu Entering the Service Functions menu Occlusion Alarm Setting...
  • Page 77: Service Functions Menu Parameters

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Service Functions menu parameters Options Screen...
  • Page 78 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Status of sensors Sensor Description...
  • Page 79: Mechanical Systems

    M e c h a n i c a l S y s t e m s C h a p t e r 5...
  • Page 80: Linkage System

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Mechanical Systems Linkage system load...
  • Page 81: Cassette Housing And Door

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Cassette housing and door insistent insistent...
  • Page 82 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Figure 5.2 Cassette housing and door 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 83: Cam Housing Switch And Safety Clip Switch

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Cam housing switch and safety clip switch Cam housing Stepping motor...
  • Page 84 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 5 —...
  • Page 85: Cams, Pistons And Valves Of The Pumping Mechanism

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Cams, pistons and valves of the pumping mechanism Pumping cycle description (Figs 5.3, 5.4 and 5.5) I s s u e A ( A p r i l 2 0 0 2 )
  • Page 86 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s [13] [14] [15]...
  • Page 87 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . valve opens to allow fluid flow to upper upper piston draws...
  • Page 88: Encoder Wheel And Interrupter

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Encoder wheel and interrupter Figure 5.6 Encoder wheel...
  • Page 89: Empty Bag Contacts

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Empty bag contacts No flow above pump...
  • Page 90 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Photo sensor Over pressure valve and swing arm Back pressure regulation...
  • Page 91: Pole Clamp And Iv Pole

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Pole clamp and IV pole Modular connection system Attaching a single pump to an IV pole...
  • Page 92 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Attaching more than one pump to an IV pole (Revised case design shown here) Inspecting the modular connections...
  • Page 93 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . How to connect pumps together Note: As you tighten the screw on the pole clamp, the actuator arm adjusts the modular connection hook and disconnect button.
  • Page 94 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Moving an IV pole with pumps connected Disconnecting modular connected pumps WARNING:...
  • Page 95: Electronic Circuits

    E l e c t r o n i c C i r c u i t s C h a p t e r 6...
  • Page 96: Maintenance Procedures

    M a i n t e n a n c e P r o c e d u r e s & T r o u b l e s h o o t i n g C h a p t e r 7...
  • Page 97: Introduction

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Maintenance Procedures Introduction 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 98: Recommended Test Equipment

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Recommended test equipment Recommended troubleshooting equipment I s s u e A ( A p r i l 2 0 0 2 )
  • Page 99: Service Tool Kit

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Service tool kit Diameter Length...
  • Page 100: Periodic Cleaning

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Periodic cleaning Recommended cleaning agents Cleaning...
  • Page 101 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Cleaning agents NOT recommended for use Activated dealdehydes Alcohol solutions...
  • Page 102: Recommended Yearly Checks And Tests

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Chemical decontamination procedures Recommended yearly checks and tests I s s u e A ( A p r i l 2 0 0 2 )
  • Page 103 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Carry out lubrication Recommended lubricant Check pole clamp screws...
  • Page 104 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Recommended annual functional and accuracy tests WARNING: Do not perform these tests while the pump is in use on a patient,...
  • Page 105 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s 3.
  • Page 106 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . 4.
  • Page 107 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s 6.
  • Page 108 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . 10.
  • Page 109 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Hold Note: Occlusion...
  • Page 110 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Silence 13.
  • Page 111 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s non- insistent Hold...
  • Page 112 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Method 2 I s s u e A ( A p r i l 2 0 0 2 ) 7 —...
  • Page 113 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 7 —...
  • Page 114: Recommended Functional & Accuracy Tests: Checklist

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Recommended Functional &...
  • Page 115: Troubleshooting

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Troubleshooting Troubleshooting, Chapter 4 WARNING: Unplug the AC power cord before opening the pump housing to avoid risk of electric...
  • Page 116 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Table 7.2 Error code related troubleshooting chart Code Error/event Possible cause/solution...
  • Page 117 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Table 7.3 Symptom/cause troubleshooting chart Symptom Possible cause/solution...
  • Page 118 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Symptom Possible cause/solution Back Up...
  • Page 119: Replacing The Lcd

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Replacing the LCD Identify the LCD type 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 120 Replacement components for EL type display Part name Part numbers for model Contents 3000/500 3100/505 I s s u e A ( A p r i l 2 0 0 2 ) 7 — 2 4 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 121: Reinitialising The Pump After Replacing The Nvram (Ic18)

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Reinitialising the pump after replacing the NVRAM (IC18) NV RAM U18 Part Numbers CPU board initialisation for Version 0.53 software...
  • Page 122 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . CPU board initialisation for Version 0.53 software continued Options...
  • Page 123 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s CPU board initialisation for Version 0.63 software continued Special Functions...
  • Page 124 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . CPU board initialisation for Version 0.63 software continued Options...
  • Page 125 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s CPU board initialisation for Version 0.63 software continued Resetting or verifying the Rev to Pos Range...
  • Page 126 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . CPU board initialisation for Version 0.65 / 0.67 / 0.71 software continued Special Functions...
  • Page 127 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Technician Menu (Version 0.71 software only) Total Volume Options...
  • Page 128: Adjustment Of The "Cassette Fitted" Micro Switch

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Adjustment of the ‘Cassette Fitted’...
  • Page 129 D i s a s s e m b l y / R e a s s e m b l y & C a l i b r a t i o n I n s t r u c t i o n s C h a p t e r 8...
  • Page 130: Disassembly And Reassembly Instructions

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Disassembly and reassembly instructions Note: Battery removal...
  • Page 131: Front Housing Removal

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Front housing removal On/Off (Original case design...
  • Page 132: Door Assembly Removal

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Door assembly removal Figure 8.2 Door disassembly...
  • Page 133 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Door Rear - reassembly procedure for CE marked pumps ONLY, with serial numbers 3000 to 59,999 and for ALL versions of pumps with serial numbers from 60,000...
  • Page 134: Cpu/Power Supply Board Removal

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s CPU/Power supply board removal WARNING: Unplug the AC power cord before opening the pump housing to avoid risk of electric shock, which could result in death or serious injury.
  • Page 135: I/O Board Assembly Removal

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . I/O board assembly removal WARNING: Unplug the AC power cord before opening the pump housing to avoid risk of electric shock, which could result in death or serious injury.
  • Page 136: Display Board Assembly Removal

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Display board assembly removal Troubleshooting WARNING: Unplug the AC power cord before opening the pump housing to avoid risk of electric...
  • Page 137 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Membrane switch replacement (Original case design) WARNING: Unplug the AC power cord before opening the pump housing to avoid risk of electric...
  • Page 138 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Membrane switch replacement (Revised case design) WARNING: Unplug the AC power cord before opening the pump housing to avoid risk of electric...
  • Page 139: Pump Assembly Removal

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Pump assembly removal Figure 8.4 Pump assembly removal...
  • Page 140: Motor Assembly Removal

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Motor assembly removal Figure 8.5 Motor assembly...
  • Page 141: Realignment Of Motor Coupler

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Realignment of motor coupler 8 —...
  • Page 142: Cassette Housing Disassembly

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Cassette housing disassembly Safety clip mechanism disassembly Reassembly...
  • Page 143: Cam Housing Switch Disassembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Cam housing switch disassembly Reassembly Figure 8.7...
  • Page 144: Calibration And Adjustment Of Components

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Calibration and adjustment of components Cam housing switch adjustment Figure 8.8 Cam switch adjustment...
  • Page 145: Occlusion Alarm Adjustment

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Occlusion alarm adjustment 1/2"...
  • Page 146 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s To calibrate the occlusion alarms Options Options...
  • Page 147: Voltage Checks

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Voltage Checks Power supply voltage check 16V DC check - power cord connected...
  • Page 148 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s 12V DC check - battery D11 Cathode TP7 (CPU/Power supply)
  • Page 149 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . 5.0V DC check - power cord connected The front housing must be removed to verify the 5.0V DC voltage.
  • Page 150: Low And Dead Battery Alarm Check

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Low and dead battery alarm check Low battery alarm Battery...
  • Page 151 I l l u s t r a t e d P a r t s L i s t C h a p t e r 9...
  • Page 152: Chapter 9 - Illustrated Parts List

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59,999 CAUTION...
  • Page 153: General Assembly Of The Volumetric Pump

    General assembly of the volumetric pump Item Description Part number 3000/500 3100/505 When ordering a Keypad Overlay, also order an Overlabel if one is shown for your country in the list below: Note: If no Overlabel is listed for your country, then no Overlabel is required.
  • Page 154 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59.999 Figure 1 General Assembly of the Volumetric pump 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 155 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 9 —...
  • Page 156 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Item Description...
  • Page 157 G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Item Description Part number 3000/500 3100/505 See Figure 5 see Figure 6 See Figure 4 Note: If a replacement LCD is required and the Display Board is fitted with inverter U401, then the Display Board must be modified and the Display Conversion Kit should be ordered.
  • Page 158 Item Description Part number 3000/500 3100/505 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 )
  • Page 159: Pump Assembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Pump assembly Item...
  • Page 160: Rear Housing Assembly

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Rear housing assembly Item...
  • Page 161 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Item Description...
  • Page 162 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Item Description...
  • Page 163: Display Board Assembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Display board assembly Item...
  • Page 164 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Item Description...
  • Page 165: Cpu Power Supply/Rs232 Board Assembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 CPU power supply/RS232 board assembly Item...
  • Page 166 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 3000 to 59,999 Figure 5 CPU power supply/RS232 board assembly 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 167: I/O Board Assembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 3000 to 59,999 I/O board assembly Item...
  • Page 168: Illustrated Parts List For Serial Numbers From 60,000

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for Serial numbers from 60,000 CAUTION Because the circuit boards used in the pumps primarily consist...
  • Page 169: General Assembly Of The Volumetric Pump

    Illustrated Parts List for pump Serial numbers from 60,000 only General assembly of the volumetric pump Item Description Part number 3000/500 3100/505 see Figure 8 see Figure 9 9 — 1 8 I s s u e A ( A p r i l 2 0 0 2 )
  • Page 170 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 60,000 only Figure 7 General Assembly of the Volumetric pump 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l...
  • Page 171 V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 60,000 only Item Description Part number 3000/500 3100/505 See Figure 11 see Figure 12 See Figure 10...
  • Page 172: Pump Assembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 60,000 only Pump assembly Item...
  • Page 173: Rear Housing Assembly

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 60,000 only Rear housing assembly Item...
  • Page 174 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 60,000 only Figure 9 Rear housing assembly - labels 9 —...
  • Page 175: Display Board Assembly

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 60,000 only Display board assembly Item...
  • Page 176: Cpu Power Supply/Rs232 Board Assembly

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Illustrated Parts List for pump Serial numbers from 60,000 only CPU power supply/RS232 board assembly Item...
  • Page 177: I/O Board Assembly

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Illustrated Parts List for pump Serial numbers from 60,000 only I/O board assembly Item...
  • Page 178: Electrical Diagrams

    E l e c t r i c a l D i a g r a m s C h a p t e r 1 0...
  • Page 179: Introduction

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Electrical Diagrams Introduction This chapter contains the following diagrams:...
  • Page 180 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . CPU/Power Supply Board Audio Unit...
  • Page 181 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s CPU/Power Supply Board AC_ON RESET...
  • Page 182: Electrical Routeing Block Diagram

    Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . Figure 10-3 Electrical routeing block diagram I s s u e A ( A p r i l 2 0 0 2 ) 10 —...
  • Page 183: Display Board Schematic

    G r a s e b y M e d i c a l L t d . Volumetric Infusion Pumps Figure 10-4 Display board schematic 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 1 0 —...
  • Page 184: Cpu/Power Supply Schematic (Sheet 1 Of 3)

    Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . Figure 10-5 CPU/Power supply schematic (sheet 1 of 3) I s s u e A ( A p r i l 2 0 0 2 ) 10 —...
  • Page 185 G r a s e b y M e d i c a l L t d . Volumetric Infusion Pumps Figure 10-6 CPU/Power supply schematic - CE (sheet 2 of 3) 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 1 0 —...
  • Page 186: Cpu/Power Supply Circuit (Sheet 3 Of 3)

    Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . Figure 10-7 CPU/Power supply circuit (sheet 3 of 3) I s s u e A ( A p r i l 2 0 0 2 ) 10 —...
  • Page 187: Input/Output Schematic

    G r a s e b y M e d i c a l L t d . Volumetric Infusion Pumps Figure 10-8 Input/Output schematic 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 1 0 —...
  • Page 188: Rs232 Schematic

    Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . Figure 10-9 RS232 schematic I s s u e A ( A p r i l 2 0 0 2 ) 10 —...
  • Page 189: Waveform Diagrams

    W a v e f o r m D i a g r a m s C h a p t e r 1 1...
  • Page 190: Introduction

    G r a s e b y M e d i c a l L t d . Volumetric Infusion Pumps Waveform Diagrams Introduction Oscilloscope waveforms at selected test points are shown in the following list of figures: Figure Title 11.1 Air detect - emitter, TP3 on I/O board 11.2...
  • Page 191 Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . 999 mL/h (99.9 mL/h on 3100/505) .5 V/Div 10 ms/Div Normal Triggering Positive Slope Figure 11.1 Air detect - emitter, TP3 on I/O board 11 —...
  • Page 192 Figure 11.2 Air detect - detector, TP2 on I/O board The wave form can be seen approximately every 5 seconds on the 3000/500 pumps, and approximately every 60 seconds on 3100/505 pumps. 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 ) 1 1 —...
  • Page 193 Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . 50.0 mL/h 10 V/Div 10 ms/Div Normal Triggering Positive Slope Figure 11.3 Motor drive pulses, TP7 on I/O board Motor Drive Pulses - 50.0 mL/h 11 —...
  • Page 194 G r a s e b y M e d i c a l L t d . Volumetric Infusion Pumps 100 mL/h (99.9 mL/h on the 3100/505 pumps) 10 V/Div 5 ms/Div Normal Triggering Positive Slope Figure 11.4 Motor drive pulses, TP7 on I/O board Motor Drive Pulses - 100 mL/h (99.9 on the 3100/505 pumps) 3 0 0 0 / 3 1 0 0 a n d 5 0 0 / 5 0 5 S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 2 )
  • Page 195 Volumetric Infusion Pumps G r a s e b y M e d i c a l L t d . 3000/500 pumps only: 900 mL/h 10 V/Div 5 ms/Div Normal Triggering Positive Slope Figure 11.5 Motor drive pulses, TP7 on I/O board Motor Drive Pulses - 900 mL/h 11 —...
  • Page 196 Pulse duration and time between pulses varies with pumping rate. Example above corresponds to a typical pulse width when pump is run at 999 mL/hr on 3000/500 pumps. For 505/3100 pumps the infusion can be run in the Diagnostic mode at 999 mL/hr...
  • Page 197 Negative Slope Figure 11.7 Interrupter detector, TP4, I/O board On the 3000/500 pumps the signal appears approximately every 3 seconds at 500 mL/h, and approximately every 15 seconds on the 3100/505 pumps, at 99.9 mL/h. 11 — 8 I s s u e A ( A p r i l 2 0 0 2 )
  • Page 198 R e m o t e M o n i t o r i n g & C o n t r o l o f t h e p u m p C h a p t e r 1 2...
  • Page 199: Remote Monitoring And Controlling Of The Pump

    Remote monitoring and controlling of the pump WARNING: While Graseby Medical Limited have taken all reasonable steps to ensure that the pump operates correctly while under remote control, it is the responsibility of the person who designs and implements the controlling device to ensure that the resulting system (pump and controlling device) is fit for its intended purpose.
  • Page 200: Summary Of Commands - Version 0.67 And Below

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Summary of commands - Version 0.67 and below Commands for monitoring the pump - CM Command...
  • Page 201: Record Format - Version 0.67 And Below

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Record Format - Version 0.67 and below <...
  • Page 202 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Monitoring commands Command Parameters and Data...
  • Page 203 G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s control/interface Command Form Description...
  • Page 204 V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Alarm bytes Bit # Description...
  • Page 205: Error Processing

    G r a s e b y M e d i c a l L t d . V o l u m e t r i c I n f u s i o n P u m p s Terminator Error Processing Summary of hardware connection and handshaking...
  • Page 206: Example Commands

    V o l u m e t r i c I n f u s i o n P u m p s G r a s e b y M e d i c a l L t d . Example Commands Version 0.65 software Command...
  • Page 207: Interfacing With Pump Software Version 0.68 And Above

    Volumetric Infusion Pumps Interfacing with pump software version 0.68 and above The information contained in this section applies to Graseby Model 3000/500 3100/505 pumps with main CPU versions greater than or equal to 0.68 Model 3000/500 3100/505 Computer Interface The Graseby Model 3000/500 3100/505 pumps are designed to interface with a computer that supports an RS-232 serial port.
  • Page 208: Character

    Graseby Medical L t d Volumetric Infusion Pumps Command Record Format - version 0.68 and above A command record consists of a string of characters sent from a host to the pump that are in a specific order and follow the rules listed here.
  • Page 209 Graseby Medical L t d Volumetric Infusion Pumps CM (Computer Monitor) commands are used for monitoring pump information. The Return Record Format section gives details of parameters and return information. The pump shall respond, when queried, to the following “CM” or monitor-only commands:...
  • Page 210 Graseby Medical L t d Volumetric Infusion Pumps The pump will also respond to the following “CI” or interface/control commands: CI (Interface) Command Code Name Parameter Needed Silence Key Keypress Infused Volume Clear ü Time and Date Set ü Pump On or Off.
  • Page 211 Graseby Medical L t d Volumetric Infusion Pumps 0x9E7A, 0x8FF3, 0xBD68, 0xACE1, 0xD85E, 0xC9D7, 0xFB4C, 0xEAC5, 0x1B2B, 0x0AA2, 0x3839, 0x29B0, 0x5D0F, 0x4C86, 0x7E1D, 0x6F94, 0x9763, 0x86EA, 0xB471, 0xA5F8, 0xD147, 0xC0CE, 0xF255, 0xE3DC, 0x2464, 0x35ED, 0x0776, 0x16FF, 0x6240, 0x73C9, 0x4152, 0x50DB,...
  • Page 212 Graseby Medical L t d Volumetric Infusion Pumps For further background, see the Public Domain Internet Document “A Painless Guide to CRC Error Detection Algorithms” © Ross Williams 1993 Keywords: crc_v3.txt 12 - 14 Issue 1(April 2002) 3000/3100 and 500/505 Service Manual...
  • Page 213: Return Record Format

    Graseby Medical L t d Volumetric Infusion Pumps Record Terminator The last character of any record transmitted by the host or pump will be an ASCII ">" (3E hex). The use of this character is not allowed in the command parameter area.
  • Page 214 Graseby Medical L t d Volumetric Infusion Pumps verify that the return code is 'Command Accepted' and that the rate value returned is indeed the rate that was expected). Conversely, if the return code is not ‘Command Accepted’, the host should ignore the command data (DDD) returned because it may be invalid or non- existent.
  • Page 215 Graseby Medical L t d Volumetric Infusion Pumps Byte Bits Description represent the current alarm number. A value of zero implies no alarm. In general, an alarm will start an audible signal and change the standard message to an alarm specific message.
  • Page 216 Graseby Medical L t d Volumetric Infusion Pumps The response to all accepted CI commands will include the volume infused, volume limit, rate, and alarm bytes formatted as described in Table 1. 12 - 18 Issue 1(April 2002) 3000/3100 and 500/505 Service Manual...
  • Page 222: Pump Powered Down - Ac/Battery

    Graseby Medical Ltd. Volumetric Infusion Pumps Pump Powered Down - AC/Battery The Rate and VTBI values are always retained over a power cycle, regardless of the power source. The occlusion pressure setting will always be defaulted upon power down, regardless of the power source.
  • Page 223: Response Time-Outs And Error Processing

    Volumetric Infusion Pumps Graseby Medical L t d Response Time-outs and Error Processing It shall be the host's responsibility to monitor pump responses, detect a no response time-out and detect all other problems inherent in serial communication. Error detection and recovery are the responsibility of the host.
  • Page 224: Example Commands

    Graseby Medical Ltd. Volumetric Infusion Pumps Example Commands Version 0.68 and above Command Command Sent by Pump Response: Description: Host: Data query <09Dxxxx> <20RAAAAAAaaaa.abbbb.bccc.cXXXX> Enable CI commands <0BI60xxxx> <20RAAAAAAaaaa.abbbb.bccc.cXXXX> with 60 s timeout Set Limit to 1000 ml <0DL1000xxxx> <20RAAAAAAaaaa.a1000.0ccc.cXXXX>...
  • Page 225 I n d e x...
  • Page 226 S I M S G r a s e b y L t d . V o l u m e t r i c I n f u s i o n P u m p s Index Symbols adjustment 8 - 14 3000/3100 disassembly 8 - 13...
  • Page 227 V o l u m e t r i c I n f u s i o n P u m p s S I M S G r a s e b y L t d . pump 8 - 1 charging 4 - 23 Disconnect clearing 4 - 30...
  • Page 228 S I M S G r a s e b y L t d . V o l u m e t r i c I n f u s i o n P u m p s Linkage system 5 - 1 Optional labels 1 - 2 Lubrication 7 - 7 Oscilloscope waveforms 11 - 1...
  • Page 229 V o l u m e t r i c I n f u s i o n P u m p s S I M S G r a s e b y L t d . Software version 1 - 2 0.71 features 1 - 3 Quick Rate Change parameter 4 - 5 on Biomed menu 4 - 26...
  • Page 230 S I M S G r a s e b y L t d . V o l u m e t r i c I n f u s i o n P u m p s Valve integrity test 7 - 11 Version 0.53 initialisation 7 - 23 Version 0.63 initialisation 7 - 24 Version 0.65 / 0.67 / 0.71 initialisation 7 - 27...
  • Page 231 The details given in this Manual are correct at the time of going to press. The company, however, reserves the right to improve the equipment shown. For further information, please contact your local distributor or Graseby Medical direct on +44 (0)1923 246434 Graseby Medical Ltd.

This manual is also suitable for:

Micro 3100/505

Table of Contents

Save PDF