Page 1
All manuals and user guides at all-guides.com WAX3F RM-ED009 WAX3F SERVICE MANUAL CHASSIS MODEL MODEL COMMANDER DEST COMMANDER DEST KDL-40V3000 KDL-40V3000 RM-ED009 RM-ED009 KDL-46V3000 KDL-46V3000 RM-ED009 RM-ED009 KDL-40V3000 / KDL-46V3000 RM-ED009 FLAT PANEL COLOR TV - 1 -...
COMPONENTS IDENTIFIED BY SHADING AND MARKED THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
All manuals and user guides at all-guides.com WAX3F RM-ED009 SPECIFICATIONS ITEM MODEL Television System Stereo System Channel Coverage Color System Analogue: VHF : E2-E12 Analogue: UHF : E21-E69 Analogue: PAL, SECAM CATV : S1-S20 B/G/H, D/K, I, L NTSC 3.58/4.43 GERMAN/NICAM HYPER : S21-S41 (VIDEO ONLY)
All manuals and user guides at all-guides.com WAX3F RM-ED009 CONNECTORS 21 Pin Connector (SCART) Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A...
Page 6
All manuals and user guides at all-guides.com WAX3F RM-ED009 HDMI Connector Pin No Signal Assignment Pin No Signal Assignment TMDS Data2+ TMDS Clock Shield TMDS Data2 Shield TMDS Clock- TMDS Data2- TMDS Data1+ Reserved (N.C. on device) TMDS Data1 Shield TMDS Data1- TMDS Data0+ DDC/CEC Ground...
All manuals and user guides at all-guides.com WAX3F RM-ED009 WAX3F SELF DIAGNOSTIC SOFTWARE The identification of errors within the WAX3F chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.
All manuals and user guides at all-guides.com WAX3F RM-ED009 SECTION 2 DISASSEMBLY 2-1. REAR COVER REMOVAL Two Screws Seventeen Two Screws Screws 2-2. STAND REMOVAL – 8 –...
All manuals and user guides at all-guides.com WAX3F RM-ED009 2-5. BE1F BOARD REMOVAL One Screw 4 One Screw Two Screws (Hex) 6 BE1F Board, Shield Top Two Screws 7 BE1F Board Seven Screws BE1F Board, Shield Bottom One Screw (To Tuner) –...
All manuals and user guides at all-guides.com WAX3F RM-ED009 SECTION 3 SET-UP ADJUSTMENTS 3-2. Signal Level Adjustment 3-1. How to enter Service Mode Service adjustments to this model can be performed using the 3-2-1. Set up of AD calibration1 adjustment for supplied remote Commander RM-ED009.
All manuals and user guides at all-guides.com WAX3F RM-ED009 5. Read SREG_TCD3_SATURATION via ECS. 4. Read SREG_AVE_VAL_B_AREA6 via ECS 6. Restore the original value. SREG_NR = 4 (Auto). (READ_AREA = 6). 7. Send ECS command ADJUST_LEVEL_SETTING_CLR. 5. Confirm that 8 bits of MSB of item number 3) and 4) are within spec of the table below.
All manuals and user guides at all-guides.com WAX3F RM-ED009 11. Wait for calculation in TV Micro. Offset Value C (This calculation value is “A”). 12. Calculate register SREG_G_GAM_IDX_OFST using the formula tmp75_temp 9100<tmp75_ 10368<tmp75 11136<tmp75 =<9100 temp=<10368 _temp=11136 _temp and tables below. 40"...
Page 17
All manuals and user guides at all-guides.com WAX3F RM-ED009 7. Set up SREG_TEST_G_LEVEL = 76 (30 IRE). 8. Adjust SREG_WB_GAM_R(B)03 chroma values so that they are within tolerance in the table below. Tolerance 40" 0.1917 0.4327 0.0008->0.0014 46" 0.1906 0.4317 0.0008->0.0014 9.
All manuals and user guides at all-guides.com WAX3F RM-ED009 3-4-3. White Balance of Colour Temperature “Neutral”, “Warm 1” and “Warm 2” The offset value for Color Temerature “Neutral”, “Warm 1”, and “Warm 2” is set in NVM Data as shown in the table below. Note: The offset values in the table below have been applied from NVM version “TD1009E”.
All manuals and user guides at all-guides.com WAX3F RM-ED009 4-2. CIRCUIT BOARD LOCATION 5-2. CIRCUIT BOARD LOCATION Reference Information D3 (46 inches) RESISTOR : METAL FILM : SOLID FPRD : NON FLAMMABLE CARBON DF1 (40 inches) FUSE : NON FLAMMABLE FUSIBLE DF2 (46 inches) BE1F : NON FLAMMABLE METAL OXIDE...
Page 25
All manuals and user guides at all-guides.com Q2024 002:6K R2249 HDMI_MUTE 1/16W Q2029 003:9G;003:11K;003:16J R2234 Q2006 RT1N141M-TP-1 003:4G RT1N141M-TP- C2183 A TT_SW R2245 C2177 Q2030 R2235 Q2025 RT1N141M-TP-1 1/16W C2180 CHIP Q2023 0 . 1 1005 Q2026 L2009 10uH HDMI_MUTE 003:6F;003:11K;003:16J 2012 L2014...
Page 26
All manuals and user guides at all-guides.com Q2006 RT1N141M-TP-1 R2163 Q2030 Q2025 1/16W RT1N141M-TP-1 SP_SD Q2026 Q2009 RT1N141M-TP-1 HDMI_MUTE 003:6F;003:11K;003:16J HEADPHONE OUTPUTS C2142 100p R2184 C2140 R2170 1/16W C2088 2 . 2 R2179 4 . 7 k 2 . 2 100k C2134 1/16W...
Page 27
All manuals and user guides at all-guides.com BE1F.-WAX3F << STBY3.3V >> RESET R3044 X3009 R3040 R3051 32.768kHz 1/16W 1/16W CHIP R3144 1/16W CHIP 2 . 2 k CHIP 1005 1/16W 1005 IC3003 C3087 RN-CP 1005 LM393DT (A) 0 . 1 0.5% SC2_IN_AVLINK RB3018...
Page 28
All manuals and user guides at all-guides.com BE1F.-WAX3F D3.3V STBY3.3V C3081 C3083 0 . 1 M24256-BWMN6TP(A) JL3082 R3167 IC3005 3216 RESET 1005 1/16W EEPROM R3193 R3144 2 . 2 k 1/16W 1/16W RN-CP JL3083 0.5% C3044 C3064 NVM_WP C3036 C3065 Temp Sensor RB3017 JL3084...
Page 29
All manuals and user guides at all-guides.com DCC_LUT_SEL2/HF_CONT2 PD0/DREG 005:3F 004:14E RESET_TR PD1/DACK0X ON_TIMER_LED PD2/DEOP0X PD3/DREQ1 PD4/DACK1X/INT 0 0 4 : 1 0 J 008:7E PD5/DEOP1X/INT2 INV_MD0 DC_ALERT1 004:14E DC_ALERT1 PE0/DREQ2/TRG1 JL3002 Q3003 007:12H PIC_MUTE_LED PE1/DACK2X/TRG2 RT1P140M-TP-1 R3053 R3056 HPD_TV3 PE2/DEOP2X/TRG R3054 XX R3057...
Page 30
All manuals and user guides at all-guides.com D-IRO I r - S w i t c h R3276 VDDE R3226 POWER_INT C3071 HP_DET A23/P57 100p R3005 1/16W KEY_1 R3061 002:11K A22/P56 SP_SD JL1060 PINT 003:10F A21/P55 POWER_KEY 0 0 4 : 1 3 I R3274 A20/P54 100k...
Page 31
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F 4A/14 SVP-WX DDR & CPU I/F, POWER & GND D3.3V STBY3.3V R4512 VDDH VDDH VDDMQ CHIP D3.3V R4518 FL4701 R4723 C4720 C4739 TC7SH86FU(T5RSOYJF) 0 . 0 0 1 0 . 1 R4709 1/16W IC4703...
Page 32
All manuals and user guides at all-guides.com BE1F.-WAX3F SC1_B,SC1_FB,SC1_G,SC1_R 002:6D SC2_B,SC2_FB,SC2_G,SC2_R CP1_IN_CB,CP1_IN_CR,CP1_IN_Y 0 0 2 : 6 I 0 0 2 : 8 J CP1_IN_Y JL4508 TMDS_RX0- Y_G1 RX0- TO HDMI CP1_IN_CB JL4509 C4510 0 . 1 1005 TMDS_RX0+ PB_B1 RX0+ JL4510 CP1_IN_CR...
Page 33
All manuals and user guides at all-guides.com MD[30] 1/16W CHIP RESET MD30 REGVCC LVDS_VSSP 004:6F MD[31] 006:4K RESET_TR MD31 DGND L VDS_VSSO V5SF MD[0-31] L VDS_VSSO D4710 C4702 FB4701 DQS[3] 0 . 1 DQS3 L VDS_VSSA 0 0 4 : 1 1 J MA[11] DQS[2] 1005...
Page 34
All manuals and user guides at all-guides.com JL4731 R4531 XX VDO[5] D3.3V DCC_LUT_SEL1/HF_CONT 004:10E LVDS_VSSP DAP_7 TC1P DCC_LUT_SEL1 R4532 XX JL4714 004:10E L VDS_VSSO DPA_8 DCC_LUT_SEL0 RB4501 DCC_LUT_SEL0/C1.5V/P1.5V_ALERT JL4715 R4533 XX R4535 DCC_SEL1/3.3V/2.5V_ALERT L VDS_VSSO DPA_9 TD1M DCC_SEL1 R4534 XX JL4732 004:8H L VDS_VSSA...
Page 35
All manuals and user guides at all-guides.com ~ BE1F Board Schematic Diagram [ Micro Processor, Video/Audio Processor, Audio Amplifier, AV Switch, Tuner, Rear Input Terminals ] Page 5/14 ~ - 35 -...
Page 36
All manuals and user guides at all-guides.com BE1F.-WAX3F TO U2 PWB RESER BE1F 6A/14 0 0 7 : 6 I ; 0 0 7 : 9 F ; 0 0 7 : 1 0 J *R5636 GND_D CHIP TMDS CLK- 1005 TMDS CLK+ GND_D...
Page 37
All manuals and user guides at all-guides.com BE1F.-WAX3F 2 PWB RESER TO WX&TMDS341 BE1F 6B/14 TO TAS 0 0 7 : 6 I ; 0 0 7 : 9 F ; 0 0 7 : 1 0 J *R5636 GND_D CHIP RXC_2R- S CLK-...
Page 44
BE1F 8D/14 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORISED ONLY FOR RESPONDING TO A REQ UEST FOR QUOTATION OR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTME NT OF SONY.
Page 45
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F FE_+3V3_2 9A/14 FE_CI_TSD[0-7] RB7200 FE_CI_TSD[4] BOOTSEL0 FE_CI_TSD[5] BOOTSEL1 FE_CI_TSD[6] BOOT_NAND_SEL_0 FE_+3V3_2 FE_CI_TSD[7] BOOT_NAND_SEL_1 RDATA[0] = ENDIAN = Big Endian FB7200 RDATA[2:1] = 10 = MRGMODE1-0 = Full merge & All bytes RB7201 RDATA[3] = -- = RESERVED...
Page 46
All manuals and user guides at all-guides.com BE1F.-WAX3F FE_+2V5_DDR BE1F PLACE THESE CAPACITORS CLOSE TO IC PINS. PLACE THESE CAPACITORS CLOSE TO IC PINS. 9B/14 C7219 C7228 C7227 C7226 C7225 C7224 C7213 C7214 C7215 C7216 C7217 C7218 C7220 100p 100p 100p 100p 100p...
Page 47
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F LAYOUT NOTE:- 9C/14 REMOVE GND PLANE AROUND AND UNDERNEATH IC7202 FE_+3V3 AND X7200 INCLUDING TRACKS FROM XTAL TO IC. FB7201 C7204 C7205 C7209 0 . 1 4 . 7 C7211 0.001 0 .
Page 48
All manuals and user guides at all-guides.com BE1F.-WAX3F 010:H2 FE_NCI_EN 010:O10;012:B10 FE_CI1_CE1B FE_CI1_CE1B 010:N10;011:C4 FE_FOEB FE_FOEB 0 1 0 : I 1 0 EMMA2LR FE_IORDB 010:H10;012:B10 FE_IORDB FE_D_IOWRB FE_IOWRB 010:N10;011:C5;012:B10 FE_FWEB FE_FWEB 0 1 0 : I 1 0 FE_CI1_RSTB FE_CI1_RSTB 010:H10 FE_REGB...
Page 49
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F 10B/14 TS from CAM TS to CAM FE_CAM_DAT[3] R7317 FE_CI1_CD1B CD1# R7318 FE_CAM_DAT[4] 0 1 0 : I 1 0 FE_CAM1_RSTB FE_CI1_CD2B EMMA2LR R7319 FE_CAM_TSOD[3] 0 1 0 : I 1 0 FE_CI1_VS1B TSD[3] MDO3...
Page 52
All manuals and user guides at all-guides.com BE1F.-WAX3F MOUNT ALL THESE CONNECTORS IN THE "FE" AREA BE1F 11A/14 FE_+3V3_2 *** MOUNT *** 182020911 CN7503 JL7521 JL7516 PMSBS RB7503 FE_MS_CLK +3V3D FE_MS_CLK JL7517 FE_+3V3 PMSDIO FE_MS_INS FE_MS_INS 010:D3 FE_MS_DAT[0] 010:G3 FE_MS_DAT[0] JL7518 FE_MS_BS PMSINS...
Page 53
All manuals and user guides at all-guides.com BE1F.-WAX3F 11,010:K10;011:C11 FE_RADD[15-25] CN7501 BE1F FE_RADD[18] FB7500 11B/14 TS_D[0] TS to AVC FE_RADD[19] FB7501 TS_D[1] FE_RADD[20] FB7502 TS_D[2] FE_RADD[21] FB7503 TS_D[3] FE_RADD[22] FB7504 TS_D[4] FE_RADD[23] FB7505 TS_D[5] FE_RADD[24] FB7506 FE_+3V3 TS_D[6] FE_RADD[25] FB7507 TS_D[7] FE_RADD[15] FB7508...
Page 54
All manuals and user guides at all-guides.com BE1F.-WAX3F EMMA 1V5 REG IC7601 PQ070XNA1ZPH BE1F Cu Heatsink FE_+3V3 FE_+1V5 12/14 IC7600 NCP1117STAT3 - - - - - - - - - - - FE_+3V3 JL7601 Add 16mmx16mm area VOUT 1005 C7611 F7602 FB7603 C7603...
Page 55
All manuals and user guides at all-guides.com BE1F.-WAX3F UNREG6.5V BE1F 13A/14 FE_+5V_REG C6742 C6744 C6743 P l a c e o n A s i d e u n d e r T U 3 9 0 1 lOGIC AND VOLTAGE SWITCHING ET6700 FE_+3V3_DEMOD FE_5VAEMI_F...
All manuals and user guides at all-guides.com H1.-WAX3F POWER *R106 SWITCH BUTTON S101 C101 D101 *R108 JL101 HOME INPUT SEL VOL+ VOL- MENU WEGAGA TE POWER INT KEY1 *R107 JL102 *R102 CN101 JL103 S104 S107 S106 S105 S103 S102 C103 *R105 R104 *R103...
All manuals and user guides at all-guides.com SECTION 5 EXPLODED VIEWS NOTE : Non-serviceable items with no part number and no Items marked “*” are not stocked since they are seldom required for description are not stocked because they are not required for routine service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these items. with a collation number in the remarks column. 5-1. CHASSIS 2-580-606-01 SCREW, +PSW M5X8 2-580-600-01 SCREW, +PSW M4X8 2-674-965-41 SCREW, +PSW 3SG 3-252-830-01 SCREW, +PWHTP B3 Note : The components identified by mark contain confidential information. Strictly follow the instructions when ever the components are repaired and/or replaced.
All manuals and user guides at all-guides.com SECTION 6 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page G3 BOARD COMPLETE Parts List : ....................91 BE1F BOARD COMPLETE Parts List : ....................94 U2 BOARD COMPLETE Parts List : ....................
Page 92
All manuals and user guides at all-guides.com D1 G3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D6152 6-501-545-01 DIODE SG10SC6-F5 < IC > D6153 6-501-545-01 DIODE SG10SC6-F5 D6201 8-719-058-74 DIODE 05NU42-TPA2 IC6100 6-707-749-01 IC CXD9841P D6203 6-500-567-31 DIODE 10ERB20-TB3 IC6150 6-709-368-01 IC MM1431ATT (CN) D6204 6-500-567-31 DIODE 10ERB20-TB3 IC6200 6-708-801-01 IC MIP2H2 IC6250...
Page 93
All manuals and user guides at all-guides.com REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < RESISTOR > R6157 1-216-841-11 METAL CHIP 47K 5% 1/10W R6158 1-249-389-11 CARBON 4.7 5% 1/4W JR6001 1-216-864-11 SHORT CHIP 0 R6159 1-218-863-11 METAL CHIP 4.7K 0.5% 1/10W JR6002 1-216-295-91 SHORT CHIP 0 R6200 £ 1-246-188-51 FUSIBLE 10 5% 1/2W JR6003 1-216-296-11 SHORT CHIP 0 R6201 1-218-865-11 METAL CHIP 5.6K 0.5% 1/10W JR6004 1-216-295-91 SHORT CHIP 0...
Page 94
All manuals and user guides at all-guides.com Note : The components identified by mark contain confidential information. BE1F Strictly follow the instructions when ever the components are repaired and/or replaced. REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6420 1-216-817-11 METAL CHIP 470 5% 1/10W < RELAY >...
Page 101
All manuals and user guides at all-guides.com Note : The components identified by mark contain confidential information. BE1F Strictly follow the instructions when ever the components are repaired and/or replaced. REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D1305 * 6-501-770-01 DIODE MAZ8130G0LS0 ET6700 1-780-152-11...
Page 103
All manuals and user guides at all-guides.com BE1F REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK FL7440 1-234-558-21 FILTER, LOW PASS IC7306 6-707-853-01 IC TC74LCX541FT(EKJ) IC7307 6-707-853-01 IC TC74LCX541FT(EKJ) < IC > IC7308 6-707-853-01 IC TC74LCX541FT(EKJ) IC7309 6-707-853-01 IC TC74LCX541FT(EKJ) IC2001 6-702-714-01 IC MSP3417G-QG-B8V3 IC7310 6-707-853-01 IC TC74LCX541FT(EKJ) IC2002 6-711-253-01 IC CXD9890AQ IC2003 8-759-278-58...
Page 127
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F.-WAX3F SC1_B,SC1_FB,SC1_G,SC1_R 002:6D SC2_B,SC2_FB,SC2_G,SC2_R CP1_IN_CB,CP1_IN_CR,CP1_IN_Y 0 0 2 : 6 I 0 0 2 : 8 J CP1_IN_Y JL4508 TMDS_RX0- Y_G1 RX0- JL4509 TO HDMI CP1_IN_CB C4510 0 . 1 1005 TMDS_RX0+ BE1F PB_B1 RX0+...
Page 128
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F.-WAX3F TO U2 PWB RESER TO WX&TMDS341 BE1F BE1F 6B/14 6A/14 TO TAS 0 0 7 : 6 I ; 0 0 7 : 9 F ; 0 0 7 : 1 0 J *R5636 GND_D CHIP...
Page 129
FE_+3V3 8D/14 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORISED ONLY FOR RESPONDING TO A REQ UEST FOR QUOTATION OR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTME NT OF SONY.
Page 130
All manuals and user guides at all-guides.com BE1F.-WAX3F BE1F.-WAX3F 010:H2 FE_NCI_EN 010:O10;012:B10 FE_CI1_CE1B FE_CI1_CE1B 010:N10;011:C4 FE_FOEB FE_FOEB BE1F 0 1 0 : I 1 0 EMMA2LR 010:H10;012:B10 FE_IORDB FE_IORDB 10B/14 FE_D_IOWRB FE_IOWRB 010:N10;011:C5;012:B10 FE_FWEB FE_FWEB 0 1 0 : I 1 0 FE_CI1_RSTB FE_CI1_RSTB 010:H10...
Page 131
All manuals and user guides at all-guides.com BE1F.-WAX3F FE_+5V_REG FE_5VAEMI_F UNREG6.5V FE_5VAEMI_F FE_+5V_REG F6700 0.5A R6792 JL6703 FE_+3V3_DEMOD R6791 R6790 JL6731 5V(LNA) FE_+5V_REG C6742 C6716 FE_+32V_INT Place close to UFE FB6702 0 . 0 1 FB6718 FB6706 JL6747 LNA SW FE_LNA_SW R6778 R6795...
Page 132
All manuals and user guides at all-guides.com U2.-WAX3F U2.-WAX3F D3.3V JL253 D3.3V_HDMI R289 CHIP D3.3V_HDMI C266 0 . 1 R314 4 . 7 k 1005 R281 1/16W 4 . 7 k CHIP GND_D JL255 R290 CHIP D5V_HDMI C267 0 . 1 D3.3V_HDMI 1005 R309...