Page 1
READ INSTRUCTION MANUAL BEFORE ATTEMPTING TO ASSEMBLE OR OPERATE THIS PRODUCT. Adult assembly required. Keep screws and parts out of reach of children. INSTALLER: Leave these instructions with consumer. CONSUMER: Retain these instructions for future reference. LCG1STTC16 • IM • 050622...
Page 2
DANGER This instruction manual contains important information necessary for the proper • Never operate this appliance assembly and safe use of the appliance. unattended. Read and follow all warnings and • Never operate this appliance within 10 ft instructions before assembling and using (3.0 m) of any structure, combustible the appliance.
TABLE OF CONTENTS Warnings 2, 4-5 Parts Diagram and Parts List Assembly Instructions 7-10 LP Gas Cylinder/Leak Testing 11-12 Operation 13-14 Special Features Care and Maintenance 15-18 Troubleshooting 19-21 Warranty lococookers.com...
WARNINGS SAVE THESE INSTRUCTIONS • The installation must conform with local codes • When cooking, the appliance must always be or, in absence of local codes, with the National on a level, stable, noncombustible surface such Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage as brick, concrete or dirt and in an area free of and Handling of Liquefi...
Page 5
WARNINGS • Never drop food or accessories onto the cooking • The manufacturer has properly located the surface. Lower food and accessories slowly burners with respect to the orifi ces to allow the onto the cooking surface in order to prevent appliance to burn suffi...
PARTS LIST AND DIAGRAM Part # Description Qty Part # Description Burner Box Foot Lid Handle Grease Tray Lid Hinge Bracket, Long Control Knob Lid Hinge Bracket, Short Ignition Button and Bezel Cooktop Battery (AA) Cooktop Locking Foot Regulator Match Holder w/Chain Burner Tube, Pilot Battery Compartment Door Burner Tube, Non-Pilot...
Page 10
ASSEMBLY INSTRUCTIONS CONNECTING LP CYLINDER AND REGULATOR: Note: LP cylinder not included. 1. Make sure control knob is in the OFF position. 2. Remove the protective cap from LP cylinder. 3. Screw the LP cylinder clockwise into the regulator. 4. Slide the regulator onto the gas port on the right side of the griddle and rotate the regulator collar clockwise to secure.
LP GAS CYLINDER Liquefi ed Petroleum Gas (LP): LP CYLINDER • LP gas is odorless, non-toxic and colorless The LP cylinder must meet the following when produced. For your safety, LP gas has requirements in order to be used with been given an odor (similar to rotten eggs) so your appliance: you can smell if there is any leaking.
Page 12
LP GAS CYLINDER LP CYLINDER REMOVAL, TRANSPORT AND LEAK TESTING: STORAGE • A leak test is recommended before each 1. Turn control knob OFF. Unscrew regulator use and must be repeated each time LP collar from griddle, then unscrew LP cylinder cylinder is exchanged or refi...
OPERATION LIGHTING YOUR SMARTTEMP™ Match Lighting: PRECISION GRIDDLE: The match holder is located in a slot beneath • Read all instructions before lighting. the griddle on the left side, secured by a chain. Only light burners outdoors. 1. Lower the small slot door to pull match •...
OPERATION SPECIAL FEATURES FLARE-UPS/GREASE FIRES: Integrated Grease Management • Flare-ups are a common occurrence when Send grease where it belongs! cooking and result from a buildup of grease Adjustable feet at each corner allow you to raise on the griddle surface. However, frequent or lower the cooktop.
CARE AND MAINTENANCE SEASONING YOUR GRIDDLE: 5. Apply an even coat of cooking oil to the griddle surface and inner and outer walls It is important to season your griddle every with paper towels. time it is used. 6. Light burners and turn control knob to Seasoning prepares the griddle surface for use SEAR.
Page 16
CARE AND MAINTENANCE PROPER CARE AND MAINTENANCE WILL BURNER FLAME CHECK KEEP YOUR APPLIANCE OPERATING Always check the fl ame prior to each use. Light SMOOTHLY. the burners and turn control knob to SEAR. CLEAN THOROUGHLY AFTER EVERY USE. A blue fl ame with little or no yellow fl ame will provide the best heat.
Page 17
CARE AND MAINTENANCE CAUTION Check burner tubes for insects and insect nests. A clogged tube can obstruct the gas fl ow and can result in a fi re beneath the appliance. Prevent blockages by inspecting and cleaning burner tubes regularly. BURNER REMOVAL AND CLEANING: 2.
Page 18
CARE AND MAINTENANCE CAUTION When the burners are reassembled, make sure to properly align burners with valve orifi ces. Doing this is critical for maximum performance and effi ciency. 6. Follow steps in reverse order to reassemble burners in burner box. STORING YOUR GRIDDLE: 4.
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Burner will not light LP cylinder and/or regulator not Make sure the regulator is properly using ignitor. properly attached. attached to the griddle, and LP cylinder is properly attached to the regulator. The LP cylinder is empty. Refi...
Page 20
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Sudden drop in gas The LP cylinder is empty. Refi ll LP cylinder at an authorized fl ow or reduced fl ame dealer, exchange or purchase new fi lled height. LP cylinder. Overfi ll Protection Device (OPD) Turn control knob to OFF, wait 30 on LP tank has been activated/ seconds, then relight griddle.
Page 21
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Excess grease collects Cooktop not adjusted for grease Using included wrench, rotate cooktop on griddle surface while drainage. feet to raise or lower cooktop until cooking. grease fl ows toward drain. Error Code ErrF 1. Empty propane cylinder. 1.
We will not be responsible for labor charges and/or damage incurred in installation, repair or replacement, nor for incidental or consequential damage. Model Number: LCG1STTC16 This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.