Page 1
WATCH BBQ ASSEMBLY REGISTER THE BBQ FOR ON VIDEO HERE: EXTENDED WARRANTY: MANUAL Installation, use, maintenance and safety FCC-G-19000-41 / K104BGD1 OUTDOOR USE ONLY READ THE MANUAL, FOLLOW THE ASSEMBLY INSTRUCTIONS STEP BY STEP. GET TO KNOW YOUR GRILL AND THE SAFETY INSTRUCTIONS BEFORE USING THE APPLIANCE!
Contents Warnings ............................3 Technical Data ..........................4 Read before assembly ......................5 Parts list ............................6 Exploded Drawing ........................7 Hardware ............................7 Assembly instructions ......................8 Connecting gas ........................16 Gas leak test - To be done before using the grill .............17 Last check ............................18 Lighting instructions ........................19 Maintenance ..........................20 Advice, tips and safety ....................22 Troubleshooting .........................23...
ACCUMULATION CAN ALSO CAUSE OXYGEN DEFICIENCY. ● THE BARBECUE MUST BE CLEANED REGULARLY AND THOROUGHLY TO PREVENT UNCONTROLLED GREASE FIRE. READ MORE ABOUT GREASE FIRE ON PAGE ALSO READ PAGE FOR MORE ADVICE AND TIPS ON GRILLING AND SAFETY. fccbbq.com...
Technical Data Tekniske data Total Heat input: 17 kW Gas consumption: 1238 gram/hour Gascylinder (not included): Use standard cylinder approved for use in the Nordic Region. Even though butane and propane gas can be used, we recommend propane for use in the Nordic Region.
Transport damage to parts, varnish or enamel must be reported to the dealer or support@fccbbq.com before the grill is installed and used. Please note that some parts may be located in the Styrofoam to protect the part during transport.
Parts list CODE DESCRIPTION CODE DESCRIPTION REAR LOW PANEL THERMOMETER BOTTOM PANEL THERMOMETER BEZEL SIDE LOW PANEL RIGHT LID SCREW DOOR SPINDLE LID HANDLE DOOR STOPPER LID BUFFER CART TRIANGULAR SUPPORT BRACKET WARMING RACK WHEEL PLUG CAST IRON GRID 195MM WHEEL CASTOR HEAT DISTRIBUTION PANEL DOOR...
Page 15
Fast forward – The chefs have now travelled to more than 65 countries all over the world. Royalties as well as celebrities have enjoyed the culinary concept the chefs offer tremendously. But, as the chefs say “it’s not about how famous our guests are, it is all about sharing the fun of cooking». fccbbq.com...
Connecting gas FOLLOW THESE INSTRUCTIONS CAREFULLY TO AVOID SERIOUS DAMAGE TO YOUR BBQ AND CAUSE PERSONAL INJURY. HOSE • Connect the gas hose to the gas inlet on the grill. Tighten well. • Install the regulator and hose. Follow the installation instructions that came with the controller set.
YOUR BARBECUE. 7. If detected leakage cannot be rectified, do not attempt to cure leakage but consult your dealer or FCC BBQ Products support at support@fccbbq.com for help in solving the problem. ● LEAK TEST MUST BE DONE REGULARLY AND EVERY TIME THE GAS CONTAINER, REGULATOR OR HOSE IS REPLACED.
Last Check PLACEMENT OF THE BBQ • Ensure that the BBQ is placed at least 150cm in all directions from house walls, trees, plants and other flammable materials or liquids when in use. • Do not place the BBQ under a roof or overhang. •...
● IF THE BURNER DOES NOT IGNITE, TURN THE SWITCHES TO THE OFF POSITION (CLOSE THE GAS SUPPLY) AND WAIT 5 MINUTES BEFORE TRYING TO IGNITE AGAIN. ● IF THE GRILL STILL DOES NOT LIGHT WITH NORMAL OR MANUAL METHOD, READ THE TROUBLESHOOTING TABLE OR CONTACT YOUR DEALER. fccbbq.com...
Maintenance KEEP THE FIREBOX, FLAME TAMERS, COOKING GRATE AND ACCESSORIES CLEAN TO AVOID GREASE FIRES. IF A GREASE FIRE OCCUR and on the grease tray. In case of grease fire, if possible close the gas Do not leave the barbecue when it is lit and close supply on the regulator / barbecue and the gas supply as soon as possible if there is a disconnectthe regulator.
Page 21
FIRES CAUSED BY FAT, DAMAGE THE METAL, PAINT AND ENAMEL. DAMAGE TO THE BARBECUE CAUSED BY FAT BURNING, IS NOT COVERED BY THE GUARANTEE AS IT IS DUE TO INCORRECT USE. fccbbq.com...
Advice, tips and safety SAFETY AND INFORMATION • The gas cylinder should always be placed next to the grill when in use. • Close the gas supply on the regulator when the grill is not in use and when storing the gas cylinder under the barbecue, disconnect the regulator.
Windy conditions exposed position Replace gas valve. TROUBLE TURNING THE Gas valve jammed NB! Knobs should be KNOBS pressed in and turned Trim away excess fat from HEAVY SMOKE Fatty foods on the BBQ meat. Clean the fat tray. fccbbq.com...
Serial number is located on the inside of the cabinet door. Produced in China for FCC Products We are always looking for ways we can improve our products. Therefore, we reserve the right to change technical specifications at any time. You will always find the latest manual on www.fccbbq.com.